光电分解水制氢气泡动力学特性及其传质机理研究

doi:10.11949/0438-1157.20240348

摘要/Abstract

摘要：

光电极表面长时间连续生长的气泡是影响光电分解水制氢效率的重要因素。利用光电化学与气泡动力学多参数同步原位测量分析方法，系统研究了激光功率和电解池内压力对气泡动力学特性和气液界面传质过程的影响。结果表明，不同激光功率和压力下的气泡在脱离之前遵循相似的生长规律。气体质量产率在80 kPa取得极值，表明适当降低压力有利于气体的产生。此外，随着压力降低气泡脱离直径增大，周期缩短。对比考虑不同Marangoni力的力平衡模型，发现同时考虑浓度Marangoni力和热Marangoni力的力平衡模型对气泡脱离直径的预测误差小于5%，浓度Marangoni力是不同压力下影响气泡脱离直径的主要因素。通过求解传质系数，发现在低光电流密度内，不同压力条件下气液传质以单相自然微对流为主，但随着光电流密度的增大，气液界面扩张引起的气泡诱导微对流传质作用增强。

关键词: 光电化学分解水, 气泡, 制氢, 压力, 传质

Abstract:

The long-term continuous growth of bubbles on the surface of the photoelectrode is an important factor affecting the efficiency of photoelectrochemical water splitting for hydrogen production. The effects of laser power and pressure in the cell on the evolution characteristics of bubbles and the mass transfer process at the gas-liquid interface were systematically studied by a multi-parameter simultaneous in-situ measurement and analysis method of photochemistry and bubble dynamics. The results demonstrate that bubbles under different laser powers and pressures follow similar growth rules before detachment. The gas mass yield reaches an extreme value at 80 kPa, indicating that appropriately lowering the pressure is beneficial to gas production. In addition, as the pressure decreases, the bubble detachment diameter increases and period shortens. By comparing force balance models considering different Marangoni forces, it is found that the force balance model considering both concentration Marangoni force and thermal Marangoni force has a prediction error of less than 5% for bubble detachment diameter and the concentration Marangoni force is the main factor affecting bubble detachment diameter under different pressures. Through solving the mass transfer coefficients, it can be found that the gas-liquid mass transfer is dominated by single-phase free microconvection under different pressure conditions in low photocurrent densities, but the effect of bubble-induced microconvection induced by expansion of gas-liquid interface on mass transfer is enhanced with the increase of photocurrent density.

Key words: photoelectrochemical water splitting, bubble, hydrogen production, pressure, mass transfer

中图分类号:

O 643.3

罗欣怡, 徐强, 佘永璐, 聂腾飞, 郭烈锦. 光电分解水制氢气泡动力学特性及其传质机理研究[J]. 化工学报, 2024, 75(9): 3083-3093.

Xinyi LUO, Qiang XU, Yonglu SHE, Tengfei NIE, Liejin GUO. Study on bubble dynamic characteristics and mass transfer mechanism in photoelectrochemical water splitting for hydrogen production[J]. CIESC Journal, 2024, 75(9): 3083-3093.

图/表 12

图1 光电分解水制氢气泡动力学与光电化学同步原位测试实验平台1—激光器；2—扩束器；3—光学透镜；4—密封电解池；5—铂丝电极(对电极)；6—饱和Ag/AgCl电极(参比电极)；7—TiO2薄膜电极(工作电极)；8—LED光源；9—显微镜头；10—高速摄像机；11—同步器；12—真空泵；13—三通阀；14—压力传感器；15—电化学工作站；16—计算机及采集卡

Fig.1 Experimental platform for bubble dynamics and photoelectrochemical synchronous in-situ test in photoelectrochemical water splitting for hydrogen production

表1 单气泡动力学实验的参数设置

Table 1 Parameter settings for single bubble dynamics experiment

实验参数	数值
室温T/K	293.15
大气压p₀/kPa	97
实验系统压力p/kPa	60~97
电解液表面张力γ/(N·m^-1)	0.072
电解液密度ρ_L/(kg·m^-3)	1.0664×10³
电解液运动黏度ν_L/(m²·s^-1)	10^-6
激光光斑半径r_laser/nm	500
激光功率W/mW	8~12
外加偏压U（vs饱和Ag/AgCl）/V	0.2
电化学工作站采样频率f/s^-1	10³
高速摄像机拍摄帧率v/(帧·s^-1)	10³
高速摄像机分辨率	512×512
显微镜放大倍率	12.5

图2 不同激光功率和压力下的光电流曲线

Fig.2 Curves of photocurrent under different laser powers and pressures

图3 光电极表面光电流与气泡演化的关联（W=12 mW，p=80 kPa）

Fig.3 Correlation between photocurrent and bubble evolution on photoelectrode surface (W=12 mW and p=80 kPa)

图4 不同激光功率和压力下的标准化气泡直径

Fig.4 Normalized bubble diameters at different laser powers and pressures

图5 气泡脱离直径和周期随压力的变化

Fig.5 Changes of bubble detachment diameter and period with pressure

图6 不同激光功率和压力下动态接触角随时间的变化

Fig.6 Variation of dynamic contact angle with time under different laser powers and pressures

图7 气体产率随压力变化的曲线

Fig.7 Curves of variation of gas production rate with pressure

图8 PEC分解水反应中单个气泡上的力

Fig.8 Forces on a single bubble in PEC water splitting reaction

图9 气泡脱离直径实际测量值与力平衡模型预测值的比较

Fig.9 Comparison of the actual measured bubble detachment diameters with the predicted values of force balance models

图10 不同激光功率和压力下传质系数的瞬态行为

Fig.10 Transient behaviors of mass transfer coefficients under different laser powers and pressures

图11 平均传质系数随光电流密度的变化

Fig.11 Variation of Average mass transfer coefficients with photocurrent density

参考文献 53

1	Wolcott A, Smith W A, Kuykendall T R, et al. Photoelectrochemical water splitting using dense and aligned TiO₂ nanorod arrays[J]. Small, 2009, 5(1): 104-111.
2	郭烈锦, 曹振山, 王晔春, 等. 太阳能光催化分解水气泡动力学研究进展[J]. 西安交通大学学报, 2023, 57(3): 1-22.
	Guo L J, Cao Z S, Wang Y C, et al. Review of bubble dynamics in solar photocatalytic water splitting[J]. Journal of Xi’an Jiaotong University, 2023, 57(3): 1-22.
3	Swiegers G F, Terrett R N L, Tsekouras G, et al. The prospects of developing a highly energy-efficient water electrolyser by eliminating or mitigating bubble effects[J]. Sustainable Energy & Fuels, 2021, 5(5): 1280-1310.
4	Pinaud B A, Benck J D, Seitz L C, et al. Technical and economic feasibility of centralized facilities for solar hydrogen production via photocatalysis and photoelectrochemistry[J]. Energy & Environmental Science, 2013, 6(7): 1983-2002.
5	Maeda K, Domen K. Photocatalytic water splitting: recent progress and future challenges[J]. The Journal of Physical Chemistry Letters, 2010, 1(18): 2655-2661.
6	Luo X Y, Xu Q, Nie T F, et al. Influence of subatmospheric pressure on bubble evolution on the TiO₂ photoelectrode surface[J]. Physical Chemistry Chemical Physics, 2023, 25(23): 16086-16104.
7	Cao Z S, Wang Y C, Xu Q, et al. Visualization of bubble dynamic behaviors during photoelectrochemical water splitting with TiO₂ photoelectrode[J]. Electrochimica Acta, 2020, 347: 136230.
8	Wang M S, Nie T F, She Y L, et al. Study on the behavior of single oxygen bubble regulated by salt concentration in photoelectrochemical water splitting[J]. International Journal of Hydrogen Energy, 2023, 48(61): 23387-23401.
9	Lu X L, Nie T F, Li X P, et al. Insight into pH-controlled bubble dynamics on a Pt electrode during electrochemical water splitting[J]. Physics of Fluids, 2023, 35(10): 103314.
10	Nie T F, Xu Q, She Y L, et al. The behavior of surface nanobubbles on different substrates in electrochemistry[J]. Journal of Molecular Liquids, 2024, 394: 123791.
11	She Y L, Xu Q, Nie T F, et al. In situ investigation of oxygen bubble evolution at photoanode surface affected by reaction temperature[J]. The Journal of Physical Chemistry C, 2023, 127(29): 14197-14210.
12	Sielaff A, Dietl J, Herbert S, et al. The influence of system pressure on bubble coalescence in nucleate boiling[J]. Heat Transfer Engineering, 2014, 35(5): 420-429.
13	Matsushima H, Iida T, Fukunaka Y. Observation of bubble layer formed on hydrogen and oxygen gas-evolving electrode in a magnetic field[J]. Journal of Solid State Electrochemistry, 2012, 16(2): 617-623.
14	Timmermann J, Hoffmann M, Schlüter M. Influence of bubble bouncing on mass transfer and chemical reaction[J]. Chemical Engineering & Technology, 2016, 39(10): 1955-1962.
15	Vogt H, Stephan K. Local microprocesses at gas-evolving electrodes and their influence on mass transfer[J]. Electrochimica Acta, 2015, 155: 348-356.
16	Guo L J, Chen Y B, Su J Z, et al. Obstacles of solar-powered photocatalytic water splitting for hydrogen production: a perspective from energy flow and mass flow[J]. Energy, 2019, 172: 1079-1086.
17	Jianu O A, Rosen M A, Naterer G F, et al. Two-phase bubble flow and convective mass transfer in water splitting processes[J]. International Journal of Hydrogen Energy, 2015, 40(11): 4047-4055.
18	Cao Z S, Zhang B, Feng Y Y, et al. Mass transfer mechanism during bubble evolution on the surface of photoelectrode[J]. Electrochimica Acta, 2022, 434: 141293.
19	Wang M S, Xu Q, Nie T F, et al. Growth characteristics and the mass transfer mechanism of single bubble on a photoelectrode at different electrolyte concentrations[J]. Physical Chemistry Chemical Physics, 2023, 25(41): 28497-28509.
20	韩宁宁, 许壮, 何广利. 电解水制高压氢气——技术挑战与研究进展[J]. 储能科学与技术, 2024, 13(2): 626-633.
	Han N N, Xu Z, He G L. Pressurized water electrolysis—Challenge and recent progress[J]. Energy Storage Science and Technology, 2024, 13(2): 626-633.
21	Fujishima A, Zhang X T, Tryk D. TiO₂ photocatalysis and related surface phenomena[J]. Surface Science Reports, 2008, 63(12): 515-582.
22	van der Linde P, Peñas-López P, Moreno Soto Á, et al. Gas bubble evolution on microstructured silicon substrates[J]. Energy & Environmental Science, 2018, 11(12): 3452-3462.
23	Brandon N P, Kelsall G H. Growth kinetics of bubbles electrogenerated at microelectrodes[J]. Journal of Applied Electrochemistry, 1985, 15(4): 475-484.
24	Lu X L, Nie T F, Yadav D, et al. Enhancing hydrogen bubble release from a microelectrode through precise tuning of Marangoni forces with nonionic surfactant[J]. Physics of Fluids, 2024, 36(1): 013335.
25	Matsushima H, Kiuchi D, Fukunaka Y, et al. Single bubble growth during water electrolysis under microgravity[J]. Electrochemistry Communications, 2009, 11(8): 1721-1723.
26	Robinson A J, Judd R L. The dynamics of spherical bubble growth[J]. International Journal of Heat and Mass Transfer, 2004, 47(23): 5101-5113.
27	Scriven L E. On the dynamics of phase growth[J]. Chemical Engineering Science, 1959, 10(1/2): 1-13.
28	Hu X W, Wang Y C, Guo L J, et al. Diffusion-controlled growth of oxygen bubble evolved from nanorod-array TiO₂ photoelectrode[J]. Advances in Condensed Matter Physics, 2014, 2014: 970891.
29	Liu H B, Pan L M, Wen J. Numerical simulation of hydrogen bubble growth at an electrode surface[J]. The Canadian Journal of Chemical Engineering, 2016, 94(1): 192-199.
30	Hu X W, Cao Z S, Wang Y C, et al. Single photogenerated bubble at gas-evolving TiO₂ nanorod-array electrode[J]. Electrochimica Acta, 2016, 202: 175-185.
31	Nie T F, Li Z Q, Luo X Y, et al. Single bubble dynamics on a TiO₂ photoelectrode surface during photoelectrochemical water splitting[J]. Electrochimica Acta, 2022, 436: 141394.
32	Bernardin J D, Mudawar I, Walsh C B, et al. Contact angle temperature dependence for water droplets on practical aluminum surfaces[J]. International Journal of Heat and Mass Transfer, 1997, 40(5): 1017-1033.
33	Lax M. Temperature rise induced by a laser beam[J]. Journal of Applied Physics, 1977, 48(9): 3919-3924.
34	Mun J, Kim S W, Kato R, et al. Measurement of the thermal conductivity of TiO₂ thin films by using the thermo-reflectance method[J]. Thermochimica Acta, 2007, 455(1/2): 55-59.
35	Brian P L T. Effect of Gibbs adsorption on Marangoni instability[J]. AIChE Journal, 1971, 17(4): 765-772.
36	Hardy S C. The motion of bubbles in a vertical temperature gradient[J]. Journal of Colloid and Interface Science, 1979, 69(1): 157-162.
37	Lubetkin S. Thermal Marangoni effects on gas bubbles are generally accompanied by solutal Marangoni effects [J]. Langmuir, 2003, 19(26): 10774-10778.
38	Lubetkin S. The motion of electrolytic gas bubbles near electrodes[J]. Electrochimica Acta, 2002, 48(4): 357-375.
39	Luo X Y, Xu Q, Ye X M, et al. Mass transfer mechanism of single bubble evolution on TiO₂ electrode surface under decreased pressure[J]. International Journal of Hydrogen Energy, 2024, 61: 859-872.
40	Ye X M, Xu Q, Nie T F, et al. Study on bubble dynamics in photoelectrochemical water splitting with low-rate flow fields[J]. The Journal of Physical Chemistry C, 2023, 127(45): 22085-22096.
41	Vogt H. The concentration overpotential of gas evolving electrodes as a multiple problem of mass transfer[J]. Journal of the Electrochemical Society, 1990, 137(4): 1179-1184.
42	Vogt H. Interfacial supersaturation at gas evolving electrodes[J]. Journal of Applied Electrochemistry, 1993, 23(12): 1323-1325.
43	Vogt H. On the gas-evolution efficiency of electrodes(‍Ⅱ): Numerical analysis[J]. Electrochimica Acta, 2011, 56(5): 2404-2410.
44	Vogt H. The role of single-phase free convection in mass transfer at gas evolving electrodes (‍Ⅰ): Theoretical[J]. Electrochimica Acta, 1993, 38(10): 1421-1426.
45	Reddy Karri S B. Dynamics of bubble departure in micro-gravity[J]. Chemical Engineering Communications, 1988, 70(1): 127-135.
46	Siegel R, Keshock E G. Effects of reduced gravity on nucleate boiling bubble dynamics in saturated water[J]. AIChE Journal, 1964, 10(4): 509-517.
47	Beer H, Borrow P, Best R. Nucleate Boiling, Bubble Growth and Dynamics. Heat Transfer in Boiling[M]. New York: Academic Press, 1977: 21-52.
48	Fritz W. Berechnung des maximalvolume von dampfblasen[J]. Physik Zeitschr, 1935, 36: 379-384.
49	Chen J W, Guo L J, Hu X W, et al. Dynamics of single bubble departure from TiO₂ nanorod-array photoelectrode[J]. Electrochimica Acta, 2018, 274: 57-66.
50	Stephan K, Vogt H. A model for correlating mass transfer data at gas evolving electrodes[J]. Electrochimica Acta, 1979, 24(1): 11-18.
51	Colombet D, Legendre D, Tuttlies U, et al. On single bubble mass transfer in a volatile liquid[J]. International Journal of Heat and Mass Transfer, 2018, 125: 1144-1155.
52	Vogt H. The role of single-phase free convection in mass transfer at gas evolving electrodes (‍Ⅱ): Experimental verification[J]. Electrochimica Acta, 1993, 38(10): 1427-1431.
53	Lochiel A C, Calderbank P H. Mass transfer in the continuous phase around axisymmetric bodies of revolution[J]. Chemical Engineering Science, 1964, 19(7): 471-484.

编辑推荐 0

Metrics

阅读次数

全文

314

HTML			PDF

最新录用	在线预览	正式出版	最新录用	在线预览	正式出版
0	0	22	0	0	292

来源	本网站	其他网站

次数	108	206
比例	34%	66%

摘要

247

最新录用	在线预览	正式出版

0	0	247

来源	本网站	其他网站

次数	69	178
比例	28%	72%

[1]	王军锋, 张俊杰, 张伟, 王家乐, 双舒炎, 张亚栋. 液相放电等离子体分解甲醇制氢：电极配置的优化[J]. 化工学报, 2024, 75(9): 3277-3286.
[2]	杨子驰, 谢冰琪, 石瑞莘, 雷虹, 陈晨, 周才金, 张吉松. 套管膜式微反应器内高效安全的气液传质-反应过程研究进展[J]. 化工学报, 2024, 75(9): 3011-3027.
[3]	唐昊, 胡定华, 李强, 张轩畅, 韩俊杰. 抗加速度双切线弧流道内气泡动力学行为数值与可视化研究[J]. 化工学报, 2024, 75(9): 3074-3082.
[4]	王冉, 王焕, 熊晓云, 关慧敏, 郑云锋, 陈彩琳, 秦玉才, 宋丽娟. FCC催化剂传质强化活性位利用效率的可视化分析[J]. 化工学报, 2024, 75(9): 3198-3209.
[5]	罗正航, 李敬宇, 陈伟雄, 种道彤, 严俊杰. 摇摆运动下低流率蒸汽冷凝换热特性和气泡受力数值模拟[J]. 化工学报, 2024, 75(8): 2800-2811.
[6]	曲玖哲, 杨鹏, 杨绪飞, 张伟, 宇波, 孙东亮, 王晓东. 硅基微柱簇阵列微通道流动沸腾实验研究[J]. 化工学报, 2024, 75(8): 2840-2851.
[7]	曹佳蕾, 孙立岩, 曾德望, 尹凡, 高子翔, 肖睿. 双流化床化学链制氢反应器的数值模拟[J]. 化工学报, 2024, 75(8): 2865-2874.
[8]	丁家琦, 刘海涛, 赵普, 朱香凝, 王晓放, 谢蓉. 煤炭超临界水制氢反应器内多相流场智能滚动预测研究[J]. 化工学报, 2024, 75(8): 2886-2896.
[9]	童永祺, 程杰, 林海, 陈曦, 赵海波. 10 MW_th化学链燃烧反应装置的CPFD模拟[J]. 化工学报, 2024, 75(8): 2949-2959.
[10]	郑晓园, 蔡炎嶙, 应芝, 王波, 豆斌林. 污水污泥磷形态亚临界水热转化研究[J]. 化工学报, 2024, 75(8): 2970-2982.
[11]	杨锦蕊, 郑宏飞, 马兴龙, 金日辉, 梁深. 两级叠置式加湿除湿海水淡化装置性能研究[J]. 化工学报, 2024, 75(7): 2446-2454.
[12]	赵赫, 费滢洁, 朱春英, 付涛涛, 马友光. 高黏体系中纳米颗粒稳定气泡的形变及破裂行为[J]. 化工学报, 2024, 75(6): 2180-2189.
[13]	关朝阳, 黄国庆, 张一喃, 陈宏霞, 杜小泽. 泡沫铜导离气泡强化流动沸腾换热实验研究[J]. 化工学报, 2024, 75(5): 1765-1776.
[14]	汪威, 白旭, 赵翔, 马学良, 林纬, 喻九阳. 基于响应面法的气浮旋流分离条件优化[J]. 化工学报, 2024, 75(5): 1929-1938.
[15]	王金山, 王世学, 朱禹. 冷却表面温差对高温质子交换膜燃料电池性能的影响[J]. 化工学报, 2024, 75(5): 2026-2035.