热线外低Rayleigh数自然对流换热的机理

doi:10.11949/j.issn.0438-1157.20150010

化工学报 ›› 2015, Vol. 66 ›› Issue (7): 2420-2425.DOI: 10.11949/j.issn.0438-1157.20150010

热线外低Rayleigh数自然对流换热的机理

戴传山, 王珏

天津大学机械学院中低温热能高效利用教育部重点实验室, 天津 300072

收稿日期:2015-01-06 修回日期:2015-03-24 出版日期:2015-07-05 发布日期:2015-07-05
通讯作者: 戴传山

Mechanism of natural convection around heated microwire at low Rayleigh number

DAI Chuanshan, WANG Jue

Key Laboratory of Efficient Utilization of Low and Medium Grade Energy, MOE, School of Mechanical Engineering, Tianjin University, Tianjin 300072, China

Received:2015-01-06 Revised:2015-03-24 Online:2015-07-05 Published:2015-07-05

摘要/Abstract

摘要：

采用铂丝自测流体温度的实验方法,利用50×10^-6 m²·s^-1硅油对低Rayleigh数下水平与竖直热线外自然对流传热的机理进行了研究,对比实验测得的实验数据和Tsubouchi、Fand的实验数据发现,实验结果与Tsubouchi的拟合曲线吻合度较高,低Ra下水平热线外的Nu高于竖直热线,但均远高于数值模拟的预测值。为了解释该现象,进行了低振动Re下的自然对流数值模拟,发现在低于某一振动Re下,Nu将与Re无关,但此时Nu与实验测的Nu基本一致,与Tsubouchi的数据偏差也在5%以内,说明微尺度铂丝外自然对流可能存在振动的作用机理。

关键词: 自然对流, 尺度效应, 低Rayleigh数, 微尺度, 振动热线

Abstract:

The mechanism of natural convection around horizontal and vertical heated microwires in silicon oil is studied by using the wire itself for temperature measurement. The comparison between present measured Nusselt numbers and those in literature shows that the present data agreed better with those of Tsubouchi than those of Fand. The horizontal microwire presents a larger Nu than the vertical one at low Rayleigh number. However, all of these experimental Nu are much larger than the numerically simulated values. In order to give a theoretical explanation on this phenomenon, heated microwire with weak vibration was used in the numerical simulations. The simulated Nu shows a perfect match with the measured data and are in agreement with the correlation of Tsubouchi with a deviation less than 5%. Therefore, an enhanced heat transfer mode due to weak wire vibration is proposed, to fill the gap between simulated and experimental results.

Key words: natural convection, scale effect, low Rayleigh number, microscale, vibrating heated wire

中图分类号:

TK124

戴传山, 王珏. 热线外低Rayleigh数自然对流换热的机理[J]. 化工学报, 2015, 66(7): 2420-2425.

DAI Chuanshan, WANG Jue. Mechanism of natural convection around heated microwire at low Rayleigh number[J]. CIESC Journal, 2015, 66(7): 2420-2425.

参考文献 18

[1]	Lu Y W, Li X L, Li Q, Ma Z F. Numerical simulation and experimental investigation of natural convection heat transfer of molten salt around fine wire [J]. Sci. China Tech. Sci., 2013, 56(7): 1651-1656.
[2]	McAdams W H. Heat Transmission [M]. 3rd Ed. New York: McGraw-Hill, 1954.
[3]	Morgan V T. The overall convective heat transfer from smooth circular cylinders [J]. Advances in Heat Transfer, 1975, 11: 199-211.
[4]	Fand R M, Brucker J. A correlation for heat transfer by natural convection from horizontal cylinders that accounts for viscous dissipation [J]. International Journal of Heat and Mass Transfer, 1983, 26(5): 709-726.
[5]	Churchill S W, Chu H H S. Correlating equations for laminar and turbulent free convection from a horizontal cylinder [J]. International Journal of Heat and Mass Transfer, 1975, 18(9): 1049-1053.
[6]	Tsubouchi T, Masuda H. Heat transfer by natural convection from horizontal cylinders at low Rayleigh numbers [J]. Reports of Institute of High Speed Mechanical of Japan, 1967, 19: 205-219.
[7]	Raithby G D, Hollands K G T. Laminar and turbulent free convection from elliptic cylinders, with a vertical plate and horizontal cylinder as special cases [J]. Transactions of ASME, 1976, 98(1): 72-80.
[8]	Misumi T, Suzuki K, Kitamura K. Fluid flow and heat transfer of natural convection around large horizontal cylinders: experiments with air [J]. Heat Transfer—Asian Research, 2003, 32(4): 293-305.
[9]	Atayilmaz ? Ö, Teke ?. Experimental and numerical study of the natural convection from a heated horizontal cylinder wrapped with a layer of textile material [J]. International Communications in Heat and Mass Transfer, 2010, 37(1): 58-67.
[10]	Margaritis K, Sotiris P E, Konstantinos A Z, Thodoris D K. Heat transfer from small objects in microgravity: experiments and analysis [J]. International Journal of Heat and Mass Transfer, 2011, 54(15/16): 3323-3333.
[11]	Margaritis K, Sotiris P E, Thodoris D K. Unexpected natural convection heat transfer for small Rayleigh numbers in external geometry [J]. International Journal of Heat and Mass Transfer, 2013, 64: 773-782.
[12]	Yang Shiming (杨世铭), Tao Wenquan (陶文铨). Heat Transfer Theory (传热学) [M]. 4th ed. Beijing: Higher Education Press, 2006: 161-425.
[13]	Guan Ning (管宁), Liu Zhigang (刘志刚), Zhang Chengwu (张承武). Natural convection heat transfer for copper micro-wires in water [J]. CIESC Journal(化工学报), 2012, 63(7): 2070-2076.
[14]	Grigorescu S D, Iliescu C, Pantelimon B. A sensor self-heating method for lead's resistance compensation in two wires RTD's measurements// Proceedings of Conference on Precision Electromagnetic Measurements [C]. Boulder, CO, USA, 1994: 174-175.
[15]	Watanabe H. Further examination of the transient hot-wire method for the simultaneous measurement of thermal conductivity and thermal diffusivity [J]. Metrologia, 2002, 39(1): 65-81.
[16]	Li Qiang (李强), Xuan Yimin (宣益民). Measurement of thermal conductivities of nanofluids [J]. CIESC Journal(化工学报), 2003, 54(1): 42-46.
[17]	Penney W R, Jefferson T B. Heat transfer from an oscillating horizontal wire to water and ethylene glycol [J]. Journal of Heat Transfer, 1966, 88(4): 359-363.
[18]	Han Zhanzhong(韩占忠), Wang Jing(王敬), Lan Xiaoping(兰小平). FLUENT—Fluid Engineering Simulation Calculating Examples and Application(FLUENT流体工程仿真计算实例与应用) [M]. Beijing: Beijing Institute of Technology Press, 2005: 264-273.

热线外低Rayleigh数自然对流换热的机理

Mechanism of natural convection around heated microwire at low Rayleigh number

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 18

相关文章 15

编辑推荐

Metrics

本文评价

[1]	苏伟, 马东旭, 金旭, 刘忠彦, 张小松. 表面润湿性对霜层传递特性影响可视化实验研究[J]. 化工学报, 2023, 74(S1): 122-131.
[2]	王玉兵, 李杰, 詹宏波, 朱光亚, 张大林. R134a在菱形离散肋微小通道内的流动沸腾换热实验研究[J]. 化工学报, 2023, 74(9): 3797-3806.
[3]	陈美思, 陈威达, 李鑫垚, 李尚予, 吴有庭, 张锋, 张志炳. 硅基离子液体微颗粒强化气体捕集与转化的研究进展[J]. 化工学报, 2023, 74(9): 3628-3639.
[4]	葛运通, 王玮, 李楷, 肖帆, 于志鹏, 宫敬. 多相分散体系中微油滴与改性二氧化硅表面间作用力的AFM研究[J]. 化工学报, 2023, 74(4): 1651-1659.
[5]	鲁军辉, 李俊明. H₂O-CO₂、H₂O-N₂、H₂O-He水平管外自然对流凝结换热特性研究[J]. 化工学报, 2022, 73(9): 3870-3879.
[6]	杨霄, 丁锐, 李墨含, 宋正昶. 氧浓度对微通道内甲烷均相/非均相耦合反应特性的影响[J]. 化工学报, 2022, 73(12): 5427-5437.
[7]	刘冉, 李杰, 王玉兵, 詹洪波, 张大林. 微小菱形离散肋通道中R134a的冷凝换热实验研究[J]. 化工学报, 2022, 73(11): 4938-4947.
[8]	赵文静, 屠治荣, 孟祥铠, 江锦波, 彭旭东. 非规则V形表面织构化机械端面密封性能研究[J]. 化工学报, 2022, 73(10): 4585-4593.
[9]	王玲玥, 朱进容, 王从乐, 吕辉, 成纯富, 张金业. 圆管束中导流器对其自然对流换热的影响[J]. 化工学报, 2021, 72(S1): 310-317.
[10]	姜洪鹏, 白敏丽, 高栋栋, 高林松, 吕继组. 超疏水/亲水性结构表面流动沸腾传热实验研究[J]. 化工学报, 2021, 72(8): 4093-4103.
[11]	孙雪剑, 宋鹏云, 毛文元, 邓强国, 许恒杰, 陈维. 考虑密封环材料属性和表面形貌干气密封启停阶段的动态接触特性分析[J]. 化工学报, 2021, 72(8): 4279-4291.
[12]	贺征宇, 彭本利, 苏风民, 纪玉龙, 马鸿斌. 微纳结构超疏水表面参数影响含不凝气蒸汽冷凝传热的理论分析[J]. 化工学报, 2021, 72(5): 2570-2577.
[13]	王法军, 黄晋培, 徐建鸿. 微反应器内红色基KD重氮化反应动力学研究[J]. 化工学报, 2021, 72(2): 984-992.
[14]	李光晓,刘塞尔,苏远海. 微尺度内液-液传质及反应过程强化的研究进展[J]. 化工学报, 2021, 72(1): 452-467.
[15]	盛磊, 李培钰, 牛宇超, 贺高红, 姜晓滨. 微尺度过程强化的结晶颗粒制备研究进展[J]. 化工学报, 2021, 72(1): 143-157.