不同载气供料对煤粉料仓下料的影响

doi:10.3969/j.issn.0438-1157.2014.09.010

化工学报 ›› 2014, Vol. 65 ›› Issue (9): 3383-3388.DOI: 10.3969/j.issn.0438-1157.2014.09.010

不同载气供料对煤粉料仓下料的影响

陆海峰, 郭晓镭, 陶顺龙, 龚欣, 鲁军

华东理工大学煤气化及能源化工教育部重点实验室, 上海市煤气化工程技术研究中心, 上海 200237

收稿日期:2013-12-27 修回日期:2014-01-22 出版日期:2014-09-05 发布日期:2014-09-05
通讯作者: 龚欣
基金资助:
国家自然科学基金项目（21206041）；中国博士后科学基金项目（2012M520847）；中央高校基本科研业务费专项资金项目。

Effect of feeding gas on hopper discharge of pulverized coal

LU Haifeng, GUO Xiaolei, TAO Shunlong, GONG Xin, LU Jun

Shanghai Research Center of Gasification Technology, Key Laboratory of Coal Gasification and Energy Chemical Engineering of Ministry of Education, East China University of Science and Technology, Shanghai 200237, China

Received:2013-12-27 Revised:2014-01-22 Online:2014-09-05 Published:2014-09-05
Supported by:
supported by the National Natural Science Foundation of China (21206041), the China Postdoctoral Science Foundation Funded Project (2012M520847) and the Fundamental Research Funds for the Central Universities.

摘要/Abstract

摘要： 煤粉料仓下料是气流床粉煤气化工艺中粉体供料单元的重要组成部分，其安全稳定运行具有重大的经济意义。在煤粉循环供料系统上，研究了以空气和CO₂为载气的气力输送供料对料仓内煤粉重力下料和通气下料的影响。研究表明，料仓内粉体的堆积或流化状态对后续粉体的流动行为影响明显。对于重力下料，CO₂供料后的重力下料过程中煤粉床层空隙率较高，下料流率较大；对于通气下料，空气供料后煤粉难以被CO₂气体流化，从而对应较低的下料流率。

关键词: 粉体, 料仓下料, 气力输送, 流态化, 吸附

Abstract: Hopper discharge is one of the most important components in the entrained-flow gasification technology of pulverized coal. Safe and stabilized hopper discharge is of great economic significance. The effect of feeding gas, including air and CO₂ on hopper discharge was studied in the loop feeding system of pulverized coal. Both gravity discharge and aerated discharge were examined and analyzed. The behavior and flowability of powders would be influenced by their previous bulk or fluidized state. For gravity discharge, the pulverized coal fed by CO₂ showed a higher void and thus corresponded to higher discharge rate. For aerated discharge, the pulverized coal fed by air was hard to be fluidized by CO₂, resulting in lower discharge rate.

Key words: powder, hopper discharge, pneumatic conveying, fluidization, adsorption

中图分类号:

TQ536

陆海峰, 郭晓镭, 陶顺龙, 龚欣, 鲁军. 不同载气供料对煤粉料仓下料的影响[J]. 化工学报, 2014, 65(9): 3383-3388.

LU Haifeng, GUO Xiaolei, TAO Shunlong, GONG Xin, LU Jun. Effect of feeding gas on hopper discharge of pulverized coal[J]. CIESC Journal, 2014, 65(9): 3383-3388.

参考文献 18

[1]	Liu S D, Zhou Z Y, Zou R P, Pinson D, Yu A B. Flow characteristics and discharge rate of ellipsoidal particles in a flat bottom hopper [J]. Powder Technology, 2014, 253: 70-79
[2]	Liang Qinfeng, Guo Xiaolei, Dai Zhenghua, Liu Haifeng, Gong Xin. An investigation on the heat transfer behavior and slag deposition of membrane wall in pilot-scale entrained-flow gasifier [J]. Fuel, 2012, 102: 491-498
[3]	Lu Haifeng, Guo Xiaolei, Gong Xin, Huang Wanjie, Ma Sheng, Wang Chuanhong. Study of the flowability of pulverized coals [J]. Energy & Fuels, 2009, 23: 5529-5535
[4]	Lu Haifeng, Guo Xiaolei, Gong Xin, Cong Xingliang, Dong Weibin. Study on the fluidization and discharge characteristics of cohesive coals from an aerated hopper [J]. Powder Technology, 2011, 207: 199-207
[5]	Crewdson B J, Ormond A L, Nedderman R M. Air-impeded discharge of fine particles from a hopper [J]. Powder Technology, 1977, 16: 197-207
[6]	Altiner H K. Flow of solids form aerated hopper: effect of aeration methods [J]. AIChE J., 1983, 222: 55-59
[7]	Massimilla L, Betta V, Della Rocca C. A study of streams of solids flowing from solid-gas fluidized beds [J]. AIChE J., 1961, 7: 502-508
[8]	Lu Haifeng, Guo Xiaolei, Gong Xin, Cong Xingliang, Dong Weibin, Huang Wanjie. Effect of gas type on the fluidization and discharge characteristics of the pulverized coal [J]. Powder Technology, 2012, 217: 347-355
[9]	Lu Haifeng (陆海峰)，Guo Xiaolei (郭晓镭), Tao Shunlong (陶顺龙), Gong Xin (龚欣). Application of electrical capacitance tomography in hopper discharge of pulverized coal [J]. CIESC Journal (化工学报), 2014, 65 (2): 422-429
[10]	Gong Xin (龚欣), Guo Xiaolei (郭晓镭), Dai Zhenghua (代正华), Feng Jinhua (封金花), Chen Jinfeng (陈金峰), Zheng Yaohui (郑耀辉), Chen Feng (陈锋), Xiong Lang (熊浪), Yu Zunhong (于遵宏). High solids loading pneumatic conveying of pulverized coal [J]. Journal of Chemical Industry and Engineering (China) (化工学报)，2006, 57: 640-644
[11]	Cong Xingliang, Guo Xiaolei, Lu Haifeng, Gong Xin, Liu Kai, Sun Xiaolin, Xie Kai. Flow patterns of pulverized coal pneumatic conveying and time-series analysis of pressure fluctuations [J]. Chemical Engineering Science, 2013, 101: 303-314
[12]	Lu Haifeng, Guo Xiaolei, Gong Xin, Cong Xingliang, Liu Kai, Qi Haifeng. Experimental study on aerated discharge of the pulverized coal [J]. Chemical Engineering Science, 2012, 71: 438-448
[13]	Nielsen Jorgen. Pressures from flowing granular solids in silos [J]. Phil. Trans. R. Soc. Lond. A, 1998, 356: 2667-2684
[14]	Freeman R E. Measuring the flow properties of consolidated, conditioned and aerated powders-a comparative study using a powder rheometer and a rotational shear cell [J]. Powder Technology, 2007, 174: 25-33
[15]	Cong Xingliang, Guo Xiaolei, Gong Xin, Lu Haifeng, Liu Kai, Qi Haifeng. Investigations of pulverized coal pneumatic conveying using CO2 and air [J]. Powder Technology, 2012, 219: 135-142
[16]	Xie H Y, Geldart D. Fluidization of FCC powders in the bubble-free regime: effect of types of gases and temperature [J]. Powder Technology, 1995, 82: 269-277
[17]	Barletta D, Donsi G, Ferrari G, Poletto M, Russo P. Solid flow rate prediction in silo discharge of aerated cohesive powders [J]. AIChE J., 2007, 53: 2240-2253
[18]	Xu C B, Zhu J X. Effects of gas type and temperature on fine particle fluidization [J]. China Particuology, 2006, 4: 114-121

不同载气供料对煤粉料仓下料的影响

Effect of feeding gas on hopper discharge of pulverized coal

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 18

相关文章 15

编辑推荐

Metrics

本文评价

[1]	晁京伟, 许嘉兴, 李廷贤. 基于无管束蒸发换热强化策略的吸附热池的供热性能研究[J]. 化工学报, 2023, 74(S1): 302-310.
[2]	杨学金, 杨金涛, 宁平, 王访, 宋晓双, 贾丽娟, 冯嘉予. 剧毒气体PH₃的干法净化技术研究进展[J]. 化工学报, 2023, 74(9): 3742-3755.
[3]	李珍宝, 李超, 王虎, 王绍瑞, 黎泉. MPP抑制铝镁合金粉尘爆炸微观机理研究[J]. 化工学报, 2023, 74(8): 3608-3614.
[4]	盛冰纯, 于建国, 林森. 铝基锂吸附剂分离高钠型地下卤水锂资源过程研究[J]. 化工学报, 2023, 74(8): 3375-3385.
[5]	张瑞航, 曹潘, 杨锋, 李昆, 肖朋, 邓春, 刘蓓, 孙长宇, 陈光进. ZIF-8纳米流体天然气乙烷回收工艺的产品纯度关键影响因素分析[J]. 化工学报, 2023, 74(8): 3386-3393.
[6]	高燕, 伍鹏, 尚超, 胡泽君, 陈晓东. 基于双流体喷嘴的磁性琼脂糖微球的制备及其蛋白吸附性能探究[J]. 化工学报, 2023, 74(8): 3457-3471.
[7]	陈吉, 洪泽, 雷昭, 凌强, 赵志刚, 彭陈辉, 崔平. 基于分子动力学的焦炭溶损反应及其机理研究[J]. 化工学报, 2023, 74(7): 2935-2946.
[8]	王杰, 丘晓琳, 赵烨, 刘鑫洋, 韩忠强, 许雍, 蒋文瀚. 聚电解质静电沉积改性PHBV抗氧化膜的制备与性能研究[J]. 化工学报, 2023, 74(7): 3068-3078.
[9]	王新悦, 王俊杰, 曹思贤, 王翠, 李灵坤, 吴宏宇, 韩静, 吴昊. 玻璃内包材界面修饰对机械应力诱导的单克隆抗体聚集体形成的影响[J]. 化工学报, 2023, 74(6): 2580-2588.
[10]	陈韶云, 徐东, 陈龙, 张禹, 张远方, 尤庆亮, 胡成龙, 陈建. 单层聚苯胺微球阵列结构的制备及其吸附性能[J]. 化工学报, 2023, 74(5): 2228-2238.
[11]	蔺彩虹, 王丽, 吴瑜, 刘鹏, 杨江峰, 李晋平. 沸石中碱金属阳离子对CO₂/N₂O吸附分离性能的影响[J]. 化工学报, 2023, 74(5): 2013-2021.
[12]	李辰鑫, 潘艳秋, 何流, 牛亚宾, 俞路. 基于碳微晶结构的炭膜模型及其气体分离模拟[J]. 化工学报, 2023, 74(5): 2057-2066.
[13]	何汉兵, 刘真, 陈勇, 王小锋, 曾婧. 直写成型电极锰氧化物粉末的合成与浆料调控[J]. 化工学报, 2023, 74(5): 2239-2247.
[14]	王蕾, 王磊, 白云龙, 何柳柳. SA膜状锂离子筛的制备及其锂吸附性能[J]. 化工学报, 2023, 74(5): 2046-2056.
[15]	肖川宝, 李林洋, 刘武锋, 钟年丙, 解泉华, 钟登杰, 常海星. 光催化与离子交换吸附耦合有效去除2，4，6-三氯苯酚[J]. 化工学报, 2023, 74(4): 1587-1597.