水平管气液两相变质量流流型从分层流向非分层流的转变

doi:10.3969/j.issn.0438-1157.2013.10.016

化工学报 ›› 2013, Vol. 64 ›› Issue (10): 3606-3611.DOI: 10.3969/j.issn.0438-1157.2013.10.016

水平管气液两相变质量流流型从分层流向非分层流的转变

肖荣鸽^1,2, 王永红², 潘杰², 魏炳乾¹, 陈刚¹

1. 西安理工大学水电学院, 陕西西安 710048;
2. 西安石油大学石油工程学院, 陕西西安 710065

收稿日期:2013-02-25 修回日期:2013-05-18 出版日期:2013-10-05 发布日期:2013-10-05
通讯作者: 肖荣鸽(1978-),女,博士,讲师
作者简介:肖荣鸽(1978-),女,博士,讲师。
基金资助:
陕西省重点学科建设专项资金资助项目和中国石油科技创新基金研究项目(2012D-5006-0603)

Transition between stratified and non stratified flow pattern for gas-liquid flow in horizontal porous pipe

XIAO Rongge^1,2, WANG Yonghong², PAN Jie², WEI Bingqian¹, CHEN Gang¹

1. School of Hydraulic and Hydropower, Xi'an University of Technology, Xi'an 710048, Shaanxi, China;
2. School of Petroleum Engineering, Xi'an Shiyou University, Xi'an 710065, Shaanxi, China

Received:2013-02-25 Revised:2013-05-18 Online:2013-10-05 Published:2013-10-05
Supported by:
supported by the Special Funding Project of Shaanxi Provincial Key Disciplines and Specialties Construction and PetroChina Innovation Foundation(2012D-5006-0603).

摘要/Abstract

摘要： 基于文献中提出的针对常规管中气液两相流分层流稳定性的分析,考虑管壁入流对流型的影响,通过公式推导和分析得出了水平管中气液两相变质量流流型从分层流向非分层流转变的准则。通过室内实验研究和预测计算,分析了3种不同的流型转变准则中多个入流流量下管壁入流对流型转变的影响。研究结果表明,实际水平井筒的单位入流流量通常较小,对本地管道单元流型预测的影响可以忽略不计,但是通过不断累积,使得下游管道中流动参数发生变化,从而影响了下游管道单元中气液流动的流型。因此水平孔缝管中气液两相变质量流的流型判别可以采用常规管流型判别准则,但要分段进行。

关键词: 管壁入流, 气液两相流, 流型转变, 分层流, 非分层流

Abstract: Based on Kelvin-Helmholtz stability criteria for stratified flow in literature, the new criteria of transition from stratified flow to non-stratified flow for gas-liquid flow in horizontal wellbore was developed, in which the influence of wall inflow was considered.Experimental researches and prediction calculations were done in order to analyze how much wall inflow affected transition conditions.The volumetric flow rate per unit pipe length was small, and the influence of wall inflow might be neglected for the flow pattern prediction of local segment unit, but could not be neglected for the flow pattern prediction of downstream segments unit because it changed the value of flow parameters of downstream segments.Therefore, the transition criteria used for normal pipe flow might be directly used for gas-liquid flow in horizontal perforated pipe.But flow pattern prediction calculations should be done segment by segment in downstream units.

Key words: wall inflow, gas-liquid two-phase flow, flow pattern transition, stratified flow, non-stratified flow

中图分类号:

O359

肖荣鸽, 王永红, 潘杰, 魏炳乾, 陈刚. 水平管气液两相变质量流流型从分层流向非分层流的转变[J]. 化工学报, 2013, 64(10): 3606-3611.

XIAO Rongge, WANG Yonghong, PAN Jie, WEI Bingqian, CHEN Gang. Transition between stratified and non stratified flow pattern for gas-liquid flow in horizontal porous pipe[J]. CIESC Journal, 2013, 64(10): 3606-3611.

参考文献 20

[1]	Gu Hanyang(顾汉洋), Guo Liejin(郭烈锦),Chen Bin(陈斌),Wang Zhiwei(王智伟),Zhang Ximin(张西民).Shape of long bubbles in horizontal and inclined intermittent flows[J].Journal of Chemical Industry and Engineering (China)(化工学报), 2006,57(9): 2068-2073
[2]	Bai Bofeng(白博峰),Guo Liejin(郭烈锦),Zhao Liang(赵亮).Identification of flow regimes in vertical upward steam-water two-phase flow using differential pressure fluctuations[J].Journal of Chemical Industry and Engineering (China)(化工学报),1999,50(6): 799-804
[3]	Liu Xin(刘昕),Zhang Shusheng(张树生),Cheng Lin(程林),Chang Wei(常威).Flow pattern transition criteria of flow boiling in confined mini/micro-channel[J].CIESC Journal(化工学报), 2013,64(5): 1574-1579
[4]	Zhu Chunying(朱春英),Fu Taotao(付涛涛),Gao Xiqun(高习群),Liu Weili(刘玮莅),Ma Youguang (马友光).Study on the liquid-liquid two-phase flow patterns in micro-channels[J].Chemical Industry and Engineering Progress(化工进展),2011,30: 65-69
[5]	Luo Xiaoming,He Limin,Ma Huawei.Flow pattern and pressure fluctuation of severe slugging in pipeline-riser system[J].Chinese Journal of Chemical Engineering,2011,19(1): 26-32
[6]	Trallero J L,Sarica C,Brill J P.A study of oil-water flow patterns in horizontal pipes//SPE Ann.Tech.Conf.and Exhi.[C].SPE36609.Denver,Colorado,USA,1996:363-375
[7]	Vedapuri D,Jepson W P.A segregated flow model to predict water layer thickness in oil-water flows in horizontal and slightly inclined pipelines//International Symposium of Multiphase Flow[C].Beijing,China: BHR Group,1997: 325-331
[8]	Adler M N,Mewes D.Flow induced emulsification in the flow of two immiscible liquids in horizontal pipes[J].Int.J.Multiphase Flow,1997,23(1): 55-68
[9]	Bauner N,Moalem Naron D.Stability analysis of stratified liquid-liquid flow[J].Int.J.Multiphase Flow,1992,18(1): 103-121
[10]	Chen Jie(陈杰),Yu Da(于达),Yan Dafan(严大凡).Study on pattern transition of oil-water pipe flow[J].Chinese Journal of Hydrodynamics(水动力学研究与进展A辑),2003,18(3): 355-364
[11]	Barnea D,Shoham O,Taitel Y,Dukler A E.Gas-liquid flow in inclined tubes:flow pattern transitions for upward flow[J].Chemical Engineering Science,1985,40(1): 131-134
[12]	Taitel Y,Barnea D.Simplified transient simulation of two-phase flow using quasi-equilibrium momentum balances[J].International Journal of Multiphase Flow,1997,23(3): 493-501
[13]	Barnea D,Taitel Y.Kelvin-Helmholtz stability criteria for stratified flow:viscous versus non-viscous (inviscid) approaches[J].Int.J.Multiphase Flow,1993,19(4): 639-649
[14]	Ouyang L B,Aziz K.A simplified approach to couple wellbore flow and reservoir inflow for arbitrary well configurations//SPE Annual Technical Conference and Exhibition[C].New Orleans,Louisiana,1998
[15]	Ouyang L B,Petalas N,Arbabi S.An experimental study of single-phase and two-phase fluid flow in horizontal wells//SPE SPE Western Regional Meeting[C].Bakersfield,California,1998
[16]	Taitel Y,Dukler A E.A model for prediction of flow regime transitions in horizontal and near horizontal gas-liquid flow[J].AIChE J.,1976,22(1):47-55
[17]	Ouyang L B.Single phase and multiphase fluid flow in horizontal wells [D].US: Stanford University,1998
[18]	Chen Y.Modeling gas-liquid flow in pipes:flow pattern transitions and drift-flux modeling[D].US: Stanford University,2001
[19]	Wu Shiqi(吴世旗),Zhong Xingfu(钟兴福),Liu Xingbin(刘兴斌),Pei Chunxia(裴春侠).Technology of production profile logging in horizontal well and its application[J].Well Testing(油气井测试),2005,14(2): 57-59
[20]	Li Xiaoping(李晓平),Zhang Liehui(张烈辉),Li Yun(李允),Chen Hailong(陈海龙).Variation laws of pressure and production rate in horizontal well [J].Chinese Journal of Hydrodynamics(水动力学研究与进展A辑),2005, 20(4): 492-496

水平管气液两相变质量流流型从分层流向非分层流的转变

Transition between stratified and non stratified flow pattern for gas-liquid flow in horizontal porous pipe

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 15

编辑推荐

Metrics

本文评价

[1]	江河, 袁俊飞, 王林, 邢谷雨. 均流腔结构对微细通道内相变流动特性影响的实验研究[J]. 化工学报, 2023, 74(S1): 235-244.
[2]	袁佳琦, 刘政, 黄锐, 张乐福, 贺登辉. 泡状入流条件下旋流泵能量转换特性研究[J]. 化工学报, 2023, 74(9): 3807-3820.
[3]	高燕, 伍鹏, 尚超, 胡泽君, 陈晓东. 基于双流体喷嘴的磁性琼脂糖微球的制备及其蛋白吸附性能探究[J]. 化工学报, 2023, 74(8): 3457-3471.
[4]	邢雷, 苗春雨, 蒋明虎, 赵立新, 李新亚. 井下微型气液旋流分离器优化设计与性能分析[J]. 化工学报, 2023, 74(8): 3394-3406.
[5]	高金明, 郭玉娇, 鄂承林, 卢春喜. 一种封闭罩内顺流多旋臂气液分离器的分离特性研究[J]. 化工学报, 2023, 74(7): 2957-2966.
[6]	刘起超, 周云龙, 陈聪. 起伏振动垂直上升管气液两相流截面含气率分析与计算[J]. 化工学报, 2023, 74(6): 2391-2403.
[7]	江锦波, 彭新, 许文烜, 门日秀, 刘畅, 彭旭东. 泵出型螺旋槽油气密封泄漏特性及参数影响研究[J]. 化工学报, 2023, 74(6): 2538-2554.
[8]	董鑫, 单永瑞, 刘易诺, 冯颖, 张建伟. 非牛顿流体气泡羽流涡特性数值模拟研究[J]. 化工学报, 2023, 74(5): 1950-1964.
[9]	许文烜, 江锦波, 彭新, 门日秀, 刘畅, 彭旭东. 宽速域三种典型型槽油气密封泄漏与成膜特性对比研究[J]. 化工学报, 2023, 74(4): 1660-1679.
[10]	何万媛, 陈一宇, 朱春英, 付涛涛, 高习群, 马友光. 阵列凸起微通道内气液两相传质特性研究[J]. 化工学报, 2023, 74(2): 690-697.
[11]	白剑钊, 郭子轩, 王德武, 刘燕, 王若瑾, 唐猛, 张少峰. 摇摆对气液并流模式立体旋流筛板压降的影响研究[J]. 化工学报, 2023, 74(2): 707-720.
[12]	盛林, 昌宇, 邓建, 骆广生. 阶梯式T型微通道内有序气泡群的形成和流动特性研究[J]. 化工学报, 2023, 74(1): 416-427.
[13]	苏巧玲, 王军锋, 张伟, 詹水清, 吴天一. 低电导率工质中气泡的极化运动实验研究[J]. 化工学报, 2022, 73(9): 3861-3869.
[14]	张童, 杨扬, 叶丁丁, 陈蓉, 朱恂, 廖强. 催化剂分布对可渗透阳极微流体燃料电池性能特性影响的研究[J]. 化工学报, 2022, 73(9): 4156-4162.
[15]	李亚飞, 邓建强, 何阳. 跨临界CO₂快速膨胀过程中非平衡冷凝和闪蒸机理的数值研究[J]. 化工学报, 2022, 73(7): 2912-2923.