100MW燃煤电厂非碳基吸附剂喷射脱汞实验研究

doi:10.3969/j.issn.0438-1157.2014.11.028

化工学报 ›› 2014, Vol. 65 ›› Issue (11): 4413-4419.DOI: 10.3969/j.issn.0438-1157.2014.11.028

100MW燃煤电厂非碳基吸附剂喷射脱汞实验研究

杜雯¹, 殷立宝², 禚玉群¹, 徐齐胜², 张亮¹, 陈昌和¹

1. 清华大学热能工程系, 热科学与动力工程教育部重点实验室, 北京 100084;
2. 南方电网公司广东电力科学院, 广东广州 510080

收稿日期:2014-04-29 修回日期:2014-06-11 出版日期:2014-11-05 发布日期:2014-11-05
通讯作者: 禚玉群
基金资助:
国家自然科学基金项目(51376109).

Experimental study on mercury capture using non-carbon sorbents in 100 MW coal-fired power plant

DU Wen¹, YIN Libao², ZHUO Yuqun¹, XU Qisheng², ZHANG Liang¹, CHEN Changhe¹

1. Key Laboratory of Thermal Science and Power Engineering of Ministry of Education, Thermal Engineering Department, Tsinghua University, Beijing 100084, China;
2. Electric Power Research Institute of Guangdong Power Grid Corporation, Guangzhou 510080, Guangdong, China

Received:2014-04-29 Revised:2014-06-11 Online:2014-11-05 Published:2014-11-05
Supported by:
supported by the National Natural Science Foundation of China (51376109).

摘要/Abstract

摘要： 选取一个100 MW燃煤电厂对氯化铜改性氧化铝和氯化铜改性沸石进行喷射脱汞实验,应用EPA 30B标准方法对静电除尘器(ESP)前后烟气中的汞价态分布进行了采样和测试.研究了吸附剂喷射量对烟气中汞脱除率的影响.现场测试的汞平衡结果为77.1%～111.5%.经修正的汞平衡结果表明,吸附剂喷射量越大,脱汞率越高.改性氧化铝的脱汞率最高可达30.6%,改性沸石的脱汞率最高可达29.2%.喷射非碳基吸附剂后烟气中元素汞(Hg⁰)显著下降,在喷射量为0.22 g·m^-3时,两种吸附剂可将烟气中Hg⁰比例由40%降低至22%左右,减少的Hg⁰主要转化为Hg^P.非碳基吸附剂与湿法脱硫(WFGD)系统协同使用可以有效减少Hg⁰向大气中的排放.

关键词: 烟道气, 吸附剂, 吸附, 脱汞, 非碳基

Abstract: The mercury removal from the flue gas discharged from a 100 MW coal-fired power plant in China by non-carbon sorbents CuCl₂ impregnated alumina and zeolite were experimentally investigated in this paper. When the sorbent were added into, the mercury speciation in flue gas across ESP was directly sampled and analyzed using EPA 30B standard method. The effect of injection rate was studied. The mercury balances measured on-site were between 77.1%—111.5%, and the results of mercury balance after correction suggested that the rates of mercury removal increased with increase of injecting amounts, and was up to 30.6% for modified alumina and 29.2% for modified zeolite. The Hg⁰ content in flue gas reduced considerably after sorbent injection, and decreased from 40% to 22% when the sorbent injection rate was 0.22 g·m^-3. Non-carbon sorbent injection combined with WFGD system could be an effective technology for controlling mercury emission of coal-fired power plant.

Key words: flue gas, sorbents, adsorption, mercury removal, non-carbon

中图分类号:

TK09

杜雯, 殷立宝, 禚玉群, 徐齐胜, 张亮, 陈昌和. 100MW燃煤电厂非碳基吸附剂喷射脱汞实验研究[J]. 化工学报, 2014, 65(11): 4413-4419.

DU Wen, YIN Libao, ZHUO Yuqun, XU Qisheng, ZHANG Liang, CHEN Changhe. Experimental study on mercury capture using non-carbon sorbents in 100 MW coal-fired power plant[J]. CIESC Journal, 2014, 65(11): 4413-4419.

参考文献 22

[1]	Pavlish J H, Sondreal E A, Mann M D, Olson E S, Galbreath K C, Laudal D L, Benson S A. Status review of mercury control options for coal-fired power plants [J]. Fuel Process. Technol., 2003, 82 (2/3): 89-165
[2]	Naylor T B. Flue Gases Research, Technology and Economics[M]. New York: Nova Science Publishers, 2009:151-202
[3]	Pacyna E G, Pacyn J M, Sundseth K, et al. Global emission of mercury to the atmosphere from anthropogenic sources in 2005 and projections to 2020 [J]. Atmos. Environ., 2010, 44 :2487-2499
[4]	Stiftung Wissenschaft und Politik(SWP). German Institute for International and Security Affairs. The UN Minamata Convention on Mercury[S]. 2013
[5]	Kilgroe J, Senior C. Fundamental science and engineering of mercury control in coal-fired power plants//Proceedings of Air Quality Ⅳ, International Conference on Mercury, Trace Elements, and Particulate Matter[C]. Arlington, VA, 2003
[6]	Cao Y, Chen B, Wu J S, Cui H, Smith J, Chen C K, Chu P, Pan W P. Study of mercury oxidation by a selective catalytic reduction catalyst in a pilot-scale slipstream reactor at a utility boiler burning bituminous coal [J]. Energy Fuels, 2007, 21: 145-156
[7]	Laudal D L, Pavlish J H, Brown T D, Galbreath K C, Thompson J S, Weber G F, Sondreal E. Pilot-scale evaluation of the impact of selective catalytic reduction for NOx on mercury speciation//Proceeding of the Air and Waste Management Association Annual Meeting[C]. Orlando, Florida, 2001
[8]	Constance L Senior. Oxidation of mercury across selective catalytic reduction catalysts in coal-fired power plants [J]. J. Air & Waste Manage. Assoc., 2006, 56: 23-31
[9]	US EPA. Information Collection Request-1999[G]. 2000
[10]	Srivastava R K, Hutson N, Martin B, Princiotta F, Staudt J. Control of mercury emissions from coal-fired electric utility boilers [J]. Environ. Sci. Technol., 2006, 40(5): 1385-1393
[11]	Environmental Health and Engineering Inc. EH&E Report 17505—Emission of hazardous air pollutants from coal-fired power plants[R]. 2011
[12]	Qiao S H, Chen J, Li J F, Qu Z, Liu P, Yan N Q, Jia J P. Adsorption and catalytic oxidation of gaseous elemental mercury in flue gas over MnOx/alumina [J]. Ind. Eng. Chem. Res., 2009, 48: 3317-3322
[13]	Zhang L, Zhuo Y Q, Du W, Tao Y, Chen C H, Xu X C. Hg removal characteristics of non-carbon sorbents in a fixed-bed reactor [J]. Ind. Eng. Chem. Res., 2012, 51: 5292-5298
[14]	Du W, Yin L B, Zhuo Y Q, Xu Q S, Zhang L, Chen C H. Catalytic oxidation and adsorption of elemental mercury over CuCl2-impregnated sorbents [J]. Ind. Eng. Chem. Res., 2014, 53(2): 582-591
[15]	Shen Boxiong(沈伯雄), Cai Ji(蔡记), Chen Jianhong(陈建宏), Li Zhuo(李卓), He Chuan(何川). Removal of elemental mercury from simulated flue gas by clay modified with KBr and KI [J]. CIESC Journal (化工学报), 2014, 65: 711-717
[16]	U.S. Environmental Protection Agency. Method 30B—Determination of total vapor phase mercury emissions from coal-fired combustion sources using carbon sorbent traps[S]
[17]	Wang Qichao(王起超), Shen Wenguo(沈文国), Ma Zhuangwei(麻壮伟). The estimation of mercury emission from coal combustion in China [J]. China Environmental Science (中国环境科学), 1999, 19(4): 318-321
[18]	Huang Wenhui(黄文辉), Yang Yichun(杨宜春). Mercury in coal of China [J]. Coal Geology of China (中国煤田地质), 2002, 14(B07): 37-40
[19]	Zhou Qiang(周强), Duan Yufeng(段钰锋), Hong Yaguang(洪亚光), Zhu Chun(朱纯), She Min(佘敏), Wei Hongqi(韦红旗). Experimental study on mercury capture using activated carbon injection in simulated flue gas [J]. Proceedings of the CSEE (中国电机工程学报), 2013, 33(5): 36-43
[20]	Hu Changxing(胡长兴), Zhou Jinsong(周劲松), Luo Zhongyang(骆仲泱), Gao Hongliang(高洪亮), Wang Qinhui(王勤辉), Cen Kefa(岑可法). Factors affecting amount of activated carbon injection for flue gas mercury control [J]. Journal of Chemical Industry and Engineering (China) (化工学报), 2005, 56(11): 2172-2177
[21]	He Boshu(何伯述), Wang Xin(王欣), Zhu Ling(朱玲), Li Mingyang(李鸣扬), Xue Jiwei(薛纪纬), Chen Zhenxing(陈振兴), Yan Linbo(严林博). Mercury removal experiments for a full-scale coal-fired plant with activated carbon injection [J]. Journal of Basic Science and Engineering (应用基础与工程科学学报), 2010, 18(5): 823-831
[22]	Jones A P, Hoffmann J W, Smith D N, Feeley T J, Murphy J T. DOE/NETL's phase II mercury control technology field testing program: preliminary economic analysis of activated carbon injection [J]. Environ. Sci. Technol., 2007, 41(4): 1365-1371

100MW燃煤电厂非碳基吸附剂喷射脱汞实验研究

Experimental study on mercury capture using non-carbon sorbents in 100 MW coal-fired power plant

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 22

相关文章 15

编辑推荐

Metrics

本文评价

[1]	晁京伟, 许嘉兴, 李廷贤. 基于无管束蒸发换热强化策略的吸附热池的供热性能研究[J]. 化工学报, 2023, 74(S1): 302-310.
[2]	杨学金, 杨金涛, 宁平, 王访, 宋晓双, 贾丽娟, 冯嘉予. 剧毒气体PH₃的干法净化技术研究进展[J]. 化工学报, 2023, 74(9): 3742-3755.
[3]	盛冰纯, 于建国, 林森. 铝基锂吸附剂分离高钠型地下卤水锂资源过程研究[J]. 化工学报, 2023, 74(8): 3375-3385.
[4]	张瑞航, 曹潘, 杨锋, 李昆, 肖朋, 邓春, 刘蓓, 孙长宇, 陈光进. ZIF-8纳米流体天然气乙烷回收工艺的产品纯度关键影响因素分析[J]. 化工学报, 2023, 74(8): 3386-3393.
[5]	高燕, 伍鹏, 尚超, 胡泽君, 陈晓东. 基于双流体喷嘴的磁性琼脂糖微球的制备及其蛋白吸附性能探究[J]. 化工学报, 2023, 74(8): 3457-3471.
[6]	陈吉, 洪泽, 雷昭, 凌强, 赵志刚, 彭陈辉, 崔平. 基于分子动力学的焦炭溶损反应及其机理研究[J]. 化工学报, 2023, 74(7): 2935-2946.
[7]	王杰, 丘晓琳, 赵烨, 刘鑫洋, 韩忠强, 许雍, 蒋文瀚. 聚电解质静电沉积改性PHBV抗氧化膜的制备与性能研究[J]. 化工学报, 2023, 74(7): 3068-3078.
[8]	王新悦, 王俊杰, 曹思贤, 王翠, 李灵坤, 吴宏宇, 韩静, 吴昊. 玻璃内包材界面修饰对机械应力诱导的单克隆抗体聚集体形成的影响[J]. 化工学报, 2023, 74(6): 2580-2588.
[9]	陈韶云, 徐东, 陈龙, 张禹, 张远方, 尤庆亮, 胡成龙, 陈建. 单层聚苯胺微球阵列结构的制备及其吸附性能[J]. 化工学报, 2023, 74(5): 2228-2238.
[10]	王蕾, 王磊, 白云龙, 何柳柳. SA膜状锂离子筛的制备及其锂吸附性能[J]. 化工学报, 2023, 74(5): 2046-2056.
[11]	蔺彩虹, 王丽, 吴瑜, 刘鹏, 杨江峰, 李晋平. 沸石中碱金属阳离子对CO₂/N₂O吸附分离性能的影响[J]. 化工学报, 2023, 74(5): 2013-2021.
[12]	李辰鑫, 潘艳秋, 何流, 牛亚宾, 俞路. 基于碳微晶结构的炭膜模型及其气体分离模拟[J]. 化工学报, 2023, 74(5): 2057-2066.
[13]	肖川宝, 李林洋, 刘武锋, 钟年丙, 解泉华, 钟登杰, 常海星. 光催化与离子交换吸附耦合有效去除2，4，6-三氯苯酚[J]. 化工学报, 2023, 74(4): 1587-1597.
[14]	时国华, 何林珅, 赵玺灵, 张世钢. 余热回收喷淋塔的烟气颗粒物脱除特性研究[J]. 化工学报, 2023, 74(4): 1735-1745.
[15]	潘煜, 王子航, 王佳韵, 王如竹, 张华. 基于可得然-氯化锂复合吸附剂的除湿换热器热湿性能研究[J]. 化工学报, 2023, 74(3): 1352-1359.