EGSB处理中药废水过程中厌氧颗粒污泥特性变化

doi:10.3969/j.issn.0438-1157.2014.09.046

化工学报 ›› 2014, Vol. 65 ›› Issue (9): 3647-3653.DOI: 10.3969/j.issn.0438-1157.2014.09.046

EGSB处理中药废水过程中厌氧颗粒污泥特性变化

宿程远^1,2, 刘兴哲¹, 王恺尧¹, 李伟光¹

1 哈尔滨工业大学市政环境工程学院, 黑龙江哈尔滨 150090;
2 广西师范大学环境与资源学院, 广西桂林 541004

收稿日期:2013-12-26 修回日期:2014-02-19 出版日期:2014-09-05 发布日期:2014-09-05
通讯作者: 李伟光
基金资助:
国家科技重大专项项目（2012ZX07205-002）；广西自然科学基金项目。

Characteristics of anaerobic granular sludge in EGSB reactor treating traditional Chinese medicine wastewater

SU Chengyuan^1,2, LIU Xingzhe¹, WANG Kaiyao¹, LI Weiguang¹

1 School of Municipal and Environmental Engineering, Harbin Institute of Technology, Harbin 150090, Heilongjiang, China;
2 School of Environment and Resources, Guangxi Normal University, Guilin 541004, Guangxi, China

Received:2013-12-26 Revised:2014-02-19 Online:2014-09-05 Published:2014-09-05
Supported by:
supported by the National Science and Technology Major Project of China (2012ZX07205-002).

摘要/Abstract

摘要： 通过分析厌氧颗粒污泥粒径分布、机械强度、二价金属含量、胞外聚合物含量等，探讨了EGSB反应器处理中药废水过程中颗粒污泥特性变化。结果表明，在中药废水COD浓度为2000～5000 mg·L^-1、HRT为12 h、T为30℃的条件下，颗粒污泥粒径分布在500～1000 μm之间，完整系数（integrity coefficient，IC）小于20，颗粒污泥EPS总量、蛋白含量、多糖含量分别为85.59、63.67和21.92 mg·（g VSS）^-1，此时颗粒污泥絮凝性良好，机械强度高。当HRT减少为6 h时，IC为30.03，蛋白与多糖的比值增大到6.86，但多糖含量仅为18.11 mg·（g VSS）^-1；而当T降低为20℃时，颗粒污泥粒径分布在250～750 μm之间，IC增大到32.11，Ca²⁺、Mg²⁺、Mn²⁺含量减少为20.78、4.79和0.94 mg·L^-1，颗粒污泥EPS显著降低，其总量、蛋白含量、多糖含量仅为69.04、58.87和10.17 mg·（g VSS）^-1，在此运行条件下，出现了颗粒污泥的解体、流失，同时出水水质变差。

关键词: 废水, 厌氧, EGSB反应器, 颗粒污泥, 粒径分布, 胞外聚合物

Abstract: The characteristics of granular sludge in the EGSB reactor treating TCM wastewater were analyzed in terms of particle size distribution (PSD), integrity coefficient (IC), metal content and extracellular polymeric substances (EPS) of granular sludge. When COD concentration was 2000-5000 mg·L^-1, hydraulic residence time (HRT) was 12 h, temperature was 30℃, the peak of PSD was in the range of 500-1000 μm, IC value was less than 20, and the contents of total EPS, protein, polysaccharide in granular sludge were 85.59, 63.67 and 21.92 mg·(g VSS)^-1, respectively. At this stage, flocculation of granular sludge was good, and its mechanical strength was high. When HRT was reduced to 6 h, IC value increased to 30.03, and the ratio of protein and polysaccharide increased to 6.86. However，the concentration of polysaccharide in granular sludge decreased to 18.11 mg·(g VSS)^-1. When temperature decreased to 20℃, the peak of PSD was in the range of 250-750 μm and IC value was 32.11. The concentrations of Ca²⁺, Mg²⁺ and Mn²⁺ were only 20.78, 4.79 and 0.94 mg·L^-1, respectively. At the same time, the contents of total EPS, protein, polysaccharide in granular sludge were 69.04, 58.87 and 10.17 mg·(g VSS)^-1, respectively. During this period, granular sludge was washed out from the EGSB reactor and COD removal efficiency decreased.

Key words: wastewater, anaerobic, EGSB reactor, granular sludge, particle size distribution, extracellular polymeric substances

中图分类号:

X703.1

宿程远, 刘兴哲, 王恺尧, 李伟光. EGSB处理中药废水过程中厌氧颗粒污泥特性变化[J]. 化工学报, 2014, 65(9): 3647-3653.

SU Chengyuan, LIU Xingzhe, WANG Kaiyao, LI Weiguang. Characteristics of anaerobic granular sludge in EGSB reactor treating traditional Chinese medicine wastewater[J]. CIESC Journal, 2014, 65(9): 3647-3653.

参考文献 20

[1]	Mauren Fuentes, Nicolás J Scenna, Pío A Aguirre. A coupling model for EGSB bioreactors: hydrodynamics and anaerobic digestion processes [J]. Chemical Engineering and Processing, 2011, 50: 316-324
[2]	Liu Jianyong, Luo Jinghuan, Zhou Jizhi, Liu Qiang, Qian Guangren, Xu Zhiping. Inhibitory effect of high-strength ammonia nitrogen on bio-treatment of landfill leachate using EGSB reactor under mesophilic and atmospheric conditions [J]. Bioresource Technology, 2012, 113: 239-243
[3]	Liu Jianyong, Hu Jun, Zhong Jiangping, Luo Jinghuan, Zhao Aihua, Liu Feng, Hong Ruijing, Qian Guangren, Xu Zhiping. The effect of calcium on the treatment of fresh leachate in an expanded granular sludge bed bioreactor [J]. Bioresource Technology, 2011, 102: 5466-5472
[4]	Delforno T P, Okada D Y, Polizel J, Sakamoto I K, Varesche M B A. Microbial characterization and removal of anionic surfactant in an expanded granular sludge bed reactor [J]. Bioresource Technology, 2012, 107: 103-109
[5]	Liu Xiaomeng (刘晓猛). Interactions and formation mechanisms of microbial aggregates [D]. Hefei: University of Science and Technology of China, 2008
[6]	Liu Yonghong (刘永红), Zhao Lei (赵蕾), Zou Lei (邹磊), Zhou Xiaode (周孝德). Measurement on mechanic strength of anaerobic granular sludge by compression test method and analysis of its influencing factors [J]. Chinese Journal of Environmental Engineering (环境工程学报), 2012, 6 (11): 57-59
[7]	Wang Haoyu (王浩宇), Su Bensheng (苏本生), Huang Dan (黄丹), Cui Xiaojiao (崔晓姣), Zhu Jianrong (竺建荣). Profiles of Zeta potential and EPS in granulation process of aerobic sludge [J]. Environmental Science (环境科学), 2012, 33 (5): 1614-1620
[8]	Wang Zhiwei, Wu Zhichao, Tang Shujuan. Extracellular polymeric substances (EPS) properties and their effects on membrane fouling in a submerged membrane bioreactor [J]. Water Research, 2009, 43:2504-2512
[9]	Zhu Liang, Qi Hanying, Lü Meile, Kong Yun, Yu Yanwen, Xu Xiangyang. Component analysis of extracellular polymeric substances (EPS) during aerobic sludge granulation using FTIR and 3D-EEM technologies [J]. Bioresource Technology, 2012, 124:455-459
[10]	Khalida Muda, Azmi Aris, Mohd Razman Salim, Zaharah Ibrahim, Adibah Yahya, Mark C M van Loosdrecht, Azlan Ahmad, Mohd Zaini Nawahwi. Development of granular sludge for textile wastewater treatment [J].Water Research, 2010, 44:4341-4350
[11]	Liu Moping (刘模平).A new technology of electrokinetic remediation and the research on removal Cu in red soils [D]. Changsha: Hunan University, 2007
[12]	Domínguez L, Rodríguez M, Prats D. Effect of different extraction methods on bound EPS from MBR sludges (Ⅰ): Influence of extraction methods over three-dimensional EEM fluorescence spectroscopy fingerprint [J]. Desalination, 2010, 261:19-26
[13]	Ismail S B, de La Parra C J, Temmink H, van Lier J B. Extracellular polymeric substances (EPS) in upflow anaerobic sludge blanket (UASB) reactors operated under high salinity conditions [J]. Water Research, 2010, 44:1909-1917
[14]	Zheng Lei (郑蕾). Research on efficiency and mechanisms of heavy metal adsorption by EPS from activated sludge [D]. Harbin: Harbin Institute of Technology, 2006
[15]	Kankana Kundu, Shilpi Sharma, Sreekrishnan T R. Changes in microbial communities in a hybrid anaerobic reactor with organic loading rate and temperature [J]. Bioresource Technology, 2013, 129:538-547
[16]	Pereboom J. Size distribution model for methanogenic granules from full scale UASB and IC reactors [J]. Water Science and Technology, 1994, 30:211-221
[17]	Xiao Benyi (肖本益), Wang Ruiming (王瑞明), Jia Shiru (贾士儒). Effects of divalent metal ions on granules in up flow anaerobic sludge blanket (UASB) reactors [J]. China Water and Wastewater (中国给水排水), 2002, 18 (6): 26-28
[18]	Bahareh Kokabian, Babak Bonakdarpour, Shahrzad Fazel. The effect of salt on the performance and characteristics of a combined anaerobic-aerobic biological process for the treatment of synthetic wastewaters containing Reactive Black 5 [J]. Chemical Engineering Journal, 2013, 221: 363-372
[19]	Ye Fenxia, Liu Xinwen, Li Ying. Effects of potassium ferrate on extracellular polymeric substances (EPS) and physicochemical properties of excess activated sludge [J]. Journal of Hazardous Materials, 2012, 199/200: 158-163
[20]	Pan Xiangliang, Liu Jing, Zhang Daoyong, Chen Xi, Song Wenjuan, Wu Fengchang. Binding of dicamba to soluble and bound extracellular polymeric substances (EPS) from aerobic activated sludge: a fluorescence quenching study [J]. Journal of Colloid and Interface Science, 2010, 345: 442-447

EGSB处理中药废水过程中厌氧颗粒污泥特性变化

Characteristics of anaerobic granular sludge in EGSB reactor treating traditional Chinese medicine wastewater

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 15

编辑推荐

Metrics

本文评价

[1]	杨百玉, 寇悦, 姜峻韬, 詹亚力, 王庆宏, 陈春茂. 炼化碱渣湿式氧化预处理过程DOM的化学转化特征[J]. 化工学报, 2023, 74(9): 3912-3920.
[2]	杨欣, 彭啸, 薛凯茹, 苏梦威, 吴燕. 分子印迹-TiO₂光电催化降解增溶PHE废水性能研究[J]. 化工学报, 2023, 74(8): 3564-3571.
[3]	吕龙义, 及文博, 韩沐达, 李伟光, 高文芳, 刘晓阳, 孙丽, 王鹏飞, 任芝军, 张光明. 铁基导电材料强化厌氧去除卤代有机污染物：研究进展及未来展望[J]. 化工学报, 2023, 74(8): 3193-3202.
[4]	杨越, 张丹, 郑巨淦, 涂茂萍, 杨庆忠. NaCl水溶液喷射闪蒸-掺混蒸发的实验研究[J]. 化工学报, 2023, 74(8): 3279-3291.
[5]	张艳梅, 袁涛, 李江, 刘亚洁, 孙占学. 高效SRB混合菌群构建及其在酸胁迫条件下的性能研究[J]. 化工学报, 2023, 74(6): 2599-2610.
[6]	胡南, 陶德敏, 杨照岚, 王学兵, 张向旭, 刘玉龙, 丁德馨. 铁炭微电解与硫酸盐还原菌耦合修复铀尾矿库渗滤水的研究[J]. 化工学报, 2023, 74(6): 2655-2667.
[7]	张兰河, 赖青燚, 王铁铮, 关潇卓, 张明爽, 程欣, 徐小惠, 贾艳萍. H₂O₂对SBR脱氮效率和污泥性能的影响[J]. 化工学报, 2023, 74(5): 2186-2196.
[8]	张建华, 陈萌萌, 孙雅雯, 彭永臻. 部分短程硝化同步除磷耦合Anammox实现生活污水高效脱氮除磷[J]. 化工学报, 2023, 74(5): 2147-2156.
[9]	闫新龙, 黄志刚, 胡清勋, 张新, 胡晓燕. Cu/Co掺杂多孔炭活化过硫酸盐降解水中硝基酚研究[J]. 化工学报, 2023, 74(3): 1102-1112.
[10]	黄玉龙, 吕凡, 仇俊杰, 章骅, 何品晶. 易腐垃圾厌氧消化沼液理化性质及VOCs分子特征[J]. 化工学报, 2023, 74(3): 1275-1285.
[11]	李承威, 骆华勇, 张铭轩, 廖鹏, 方茜, 荣宏伟, 王竞茵. 氢氧化镧交联壳聚糖微球的微流控制备及其除磷性能[J]. 化工学报, 2022, 73(9): 3929-3939.
[12]	赵希强, 张健, 孙爽, 王文龙, 毛岩鹏, 孙静, 刘景龙, 宋占龙. 生物质炭改性微球去除化工废水中无机磷的性能研究[J]. 化工学报, 2022, 73(5): 2158-2173.
[13]	贾艳萍, 丁雪, 刚健, 佟泽为, 张海丰, 张兰河. Mn强化Fe/C微电解工艺条件优化及降解油墨废水机理[J]. 化工学报, 2022, 73(5): 2183-2193.
[14]	毛恒, 王月, 王森, 刘伟民, 吕静, 陈甫雪, 赵之平. APTES改性ZIF-L/PEBA混合基质膜强化渗透汽化分离苯酚研究[J]. 化工学报, 2022, 73(3): 1389-1402.
[15]	王祺, 房阔, 贺聪慧, 王凯军. 流动电极电容去离子技术综述：研究进展与未来挑战[J]. 化工学报, 2022, 73(3): 975-989.