排气管直径与深度对水力喷射空气旋流器传质性能的影响

doi:10.11949/j.issn.0438-1157.20141651

化工学报 ›› 2015, Vol. 66 ›› Issue (5): 1642-1648.DOI: 10.11949/j.issn.0438-1157.20141651

排气管直径与深度对水力喷射空气旋流器传质性能的影响

程治良, 徐飞, 全学军, 邱发成, 代明星

重庆理工大学化学化工学院, 重庆 400054

收稿日期:2014-11-03 修回日期:2015-02-05 出版日期:2015-05-05 发布日期:2015-05-05
通讯作者: 全学军
基金资助:
国家自然科学基金项目(21176273);重庆理工大学基金项目(2014ZD04,2014XH16)。

Effect of diameter and length of vortex finder in water-sparged aerocyclone reactor on its mass transfer performance in air stripping of ammonia

CHENG Zhiliang, XU Fei, QUAN Xuejun, QIU Facheng, DAI Mingxing

School of Chemistry and Chemical Engineering, Chongqing University of Technology, Chongqing 400054, China

Received:2014-11-03 Revised:2015-02-05 Online:2015-05-05 Published:2015-05-05
Supported by:
supported by the National Natural Science Foundation of China (21176273) and the Research Project of Chongqing University of Technology (2014ZD04, 2014XH16).

摘要/Abstract

摘要： 对水力喷射空气旋流器(WSA)的中心排气管直径D_e和排气管插入深度S进行了设计优化研究,实验考察了不同D_e和S对WSA脱氨传质系数K_La和气相压降的影响,提出了综合评价传质过程效率的概念——单位压降传质效率η_p,讨论了D_e和S的设计取值。研究表明,当D_e增大时,K_La和气相压降均随之降低,较小D_e的WSA具有较高的气液传质性能,但气相压降比较大,而K_La和气相压降均随S增大而增大。综合能效关系表明,随着D_e的增大η_p增大,随着S的增大η_p出现先增大后降低的趋势,WSA设计中D_e与WSA直径D之比D_e/D宜为0.42～0.53,S与WSA筒体长度H之比S/H适宜取值约为0.70。

关键词: 脱氨, 空气旋流器, 废水, 传质, 气液两相流

Abstract: Water-sparged aerocyclone (WSA) is a new gas-liquid mass transfer equipment, which takes the advantage of coupling effect of air cyclone and liquid jet fields. In order to improve its mass transfer performance and establish design principles, the effect of diameter (D_e) and length (S) of the vortex finder in the WSA on its mass transfer performance and air pressure drop in air stripping of ammonia was investigated and optimized. A new concept, mass transfer efficiency per gas pressure drop, η_p, and its calculation equation were put forward. The WSA with smaller D_e and longer S showed higher mass transfer efficiency than that with larger D_e and shorter S in air stripping of ammonia. However, this kind of WSA had higher air pressure drop, which would consume more energy. Calculation of η_p, which was a comprehensive indicator considering energy consumption and mass transfer efficiency, showed that it increased with the increase of D_e/D and S/H,but it deceased a little when S/H increased from 0.71 to 0.93. The optimal D_e/D and S/H should be 0.43 to 0.53 and 0.70, respectively. These results could be used as a guide for the design of WSA with good mass transfer performance.

Key words: ammonia removal, aerocyclone, wastewater, mass transfer, gas-liquid flow

中图分类号:

TQ028
X505

程治良, 徐飞, 全学军, 邱发成, 代明星. 排气管直径与深度对水力喷射空气旋流器传质性能的影响[J]. 化工学报, 2015, 66(5): 1642-1648.

CHENG Zhiliang, XU Fei, QUAN Xuejun, QIU Facheng, DAI Mingxing. Effect of diameter and length of vortex finder in water-sparged aerocyclone reactor on its mass transfer performance in air stripping of ammonia[J]. CIESC Journal, 2015, 66(5): 1642-1648.

参考文献 25

[1]	Jiao W Z, Liu Y Z, Qi G S. Gas pressure drop and mass transfer characteristics in a cross-flow rotating packed bed with porous plate packing [J]. Ind. Eng. Chem. Res., 2010, 49 (8): 3732-3740
[2]	Libralato G, Ghirardini A V, Avezzù F. Evaporation and air-stripping to assess and reduce ethanolamines toxicity in oily wastewater [J]. J. Hazard. Mater., 2008, 153 (3): 928-936
[3]	Cormos A-M, Gaspar J. Assessment of mass transfer and hydraulic aspects of CO2 absorption in packed columns [J]. Int. J. Greenh. Gas Con., 2012, 6: 201-209
[4]	Chen Jianfeng (陈建峰). The Technology and Applications of High Gravity—New Reactive and Separation Technology (超重力技术及其应用——新一代反应与分离技术) [M]. Beijing: Chemical Industry Press, 2002: 1-3
[5]	Zhao Qinghua (赵清华), Quan Xuejun (全学军), Cheng Zhiliang (程治良), Bai Weiyang (白薇扬). Mass transfer characteristics and mechanism in a water-sparged aerocyclone [J]. CIESC Journal (化工学报), 2013, 64 (10): 3652-3657
[6]	Zhang Jianwen (张建文), Gao Dongxia (高冬霞),Li Yachao (李亚超), Chen Jianfeng (陈建峰). Research progress of multiphase transport in high gravity environment in rotating packed bed [J]. CIESC Journal (化工学报), 2013, 64 (1): 243-251
[7]	Xiang Yang (向阳), Liu Liang (刘良), Chu Guangwen (初广文), Zou Haikui (邹海魁), Chen Jianfeng (陈建峰). Numerical simulation for water deoxygenation in rotating packed bed [J]. CIESC Journal (化工学报), 2014, 65 (7): 2785-2792
[8]	Cao Zhongwen (曹仲文). Investigation into the absorption in a cyclone absorber of spraying liquid from side wall [D]. Wuxi: Jiangnan University, 2008
[9]	Bokotko R P, Hupka J, Miller J D. Flue gas treatment for SO2 removal with air-sparged hydrocyclone technology [J]. Environ. Sci. Technol., 2005, 39 (4): 1184-1189
[10]	Quan Xuejun, Wang Fuping, Zhao Qinghua, Zhao Tiantao, Xiang Jinxin. Air stripping of ammonia in a water-sparged aerocyclone reactor [J]. J. Hazard. Mater., 2009, 170 (2/3): 983-988
[11]	Quan Xuejun, Ye Changying, Xiong Yanqi, Xiang Jinxin, Wang Fuping. Simultaneous removal of ammonia, P and COD from anaerobically digested piggery wastewater using an integrated process of chemical precipitation and air stripping [J]. J. Hazard. Mater., 2010, 178 (1/2/3): 326-332
[12]	Zhao Qinghua (赵清华), Quan Xuejun (全学军), Cheng Zhiliang (程治良), Yan Yunpeng (晏云鹏). Wet desulfurization of flue gas and mass transfer mechanism in water-sparged aerocyclone [J]. CIESC Journal (化工学报), 2013, 64 (11): 3393-4000
[13]	Cheng Zhiliang (程治良), Quan Xuejun (全学军), Dai Li (代黎), Yan Yunpeng (晏云鹏). Treatment of Cr (Ⅵ)-containing wastewater in a water-sparged aerocyclone [J]. CIESC Journal (化工学报), 2014, 65 (4): 1403-1410
[14]	Cheng Zhiliang (程治良), Quan Xuejun (全学军), Yan Yunpeng (晏云鹏), Dai Li (代黎). Jet flow pattern and its effects on mass transfer area and gas phase pressure drop in a water-sparged aerocyclone [J]. CIESC Journal (化工学报), 2014, 65 (8): 2914-2920
[15]	Cheng Zhiliang (程治良), Quan Xuejun (全学军), Dai Li (代黎), Yan Yunpeng (晏云鹏),Zhao Qinghua (赵清华).Optimization of spray hole distribution in water-sparged aerocyclone [J]. CIESC Journal (化工学报), 2013, 64 (9): 3182-3188
[16]	Elsayed K, Lacor C. Modeling, analysis and optimization of aircyclones using artificial neural network, response surface methodology and CFD simulation approaches [J]. Powder Technology, 2011, 212: 115-133
[17]	Alitalo A, Kyrö A, Aura E. Ammonia stripping of biologically treated liquid manure [J]. J. Environ. Qual., 2012, 41:273-280
[18]	Elsayed K, Lacor C. The effect of cyclone vortex finder dimensions on the flow pattern and performance using LES [J]. Comput. Fluids,2013, 71: 224-239
[19]	Raoufi A, Shams M, Farzaneh M, Ebrahimi R. Numerical simulation and optimization of fluid flow in cyclone vortex finder [J]. Chem. Eng. Process., 2008, 47: 128-137
[20]	Gao Cuizhi (高翠芝), Sun Guogang (孙国刚), Dong Ruiqian (董瑞倩). Effect of vortex finder on axial velocity distribution patterns in cyclones [J]. CIESC Journal (化工学报), 2010, 61 (9): 2409-2416
[21]	Chen Jianlei (陈建磊), He Limin (何利民), Luo Xiaoming (罗小明), Wang Xin (王鑫), Wang Liman (王立满), Yang Donghai (杨东海). Simulation of zero axial velocity surface distribution in cylindrical cyclone separator [J]. CIESC Journal (化工学报), 2013, 64 (9): 3241-3249
[22]	Elsayed K, Lacor C. Optimization of the cyclone separator geometry for minimum pressure drop using mathematical models and CFD simulations [J]. Chem. Eng. Sci., 2010, 65 (22): 6048-6058
[23]	Elsayed K, Lacor C. CFD modeling and multi-objective optimization of cyclone geometry using desirability function, artificial neural networks and genetic algorithms [J]. Appl. Math. Model., 2013, 37 (8): 5680-5704
[24]	Liu Xuan (刘玄), Cheng Shusen (程树森). Numerical study of flow field in a cyclone [J]. Chinese Journal of Environmental Engineering (环境工程学报), 2009, 3 (6): 1069-1072
[25]	Huang Bin (黄滨), Wang Leqin (王乐勤), Jiao Lei (焦磊), Hao Zongrui (郝宗睿). Numerical simulation of the influence of the lengths of exit tubes on the internal flow fied of cyclone separators [J]. Chem. Eng. Machinery (化工机械), 2010, 37 (1): 53-57

排气管直径与深度对水力喷射空气旋流器传质性能的影响

Effect of diameter and length of vortex finder in water-sparged aerocyclone reactor on its mass transfer performance in air stripping of ammonia

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 25

相关文章 15

编辑推荐

Metrics

本文评价

[1]	晁京伟, 许嘉兴, 李廷贤. 基于无管束蒸发换热强化策略的吸附热池的供热性能研究[J]. 化工学报, 2023, 74(S1): 302-310.
[2]	江河, 袁俊飞, 王林, 邢谷雨. 均流腔结构对微细通道内相变流动特性影响的实验研究[J]. 化工学报, 2023, 74(S1): 235-244.
[3]	杨百玉, 寇悦, 姜峻韬, 詹亚力, 王庆宏, 陈春茂. 炼化碱渣湿式氧化预处理过程DOM的化学转化特征[J]. 化工学报, 2023, 74(9): 3912-3920.
[4]	李艺彤, 郭航, 陈浩, 叶芳. 催化剂非均匀分布的质子交换膜燃料电池操作条件研究[J]. 化工学报, 2023, 74(9): 3831-3840.
[5]	袁佳琦, 刘政, 黄锐, 张乐福, 贺登辉. 泡状入流条件下旋流泵能量转换特性研究[J]. 化工学报, 2023, 74(9): 3807-3820.
[6]	邢雷, 苗春雨, 蒋明虎, 赵立新, 李新亚. 井下微型气液旋流分离器优化设计与性能分析[J]. 化工学报, 2023, 74(8): 3394-3406.
[7]	杨欣, 彭啸, 薛凯茹, 苏梦威, 吴燕. 分子印迹-TiO₂光电催化降解增溶PHE废水性能研究[J]. 化工学报, 2023, 74(8): 3564-3571.
[8]	高燕, 伍鹏, 尚超, 胡泽君, 陈晓东. 基于双流体喷嘴的磁性琼脂糖微球的制备及其蛋白吸附性能探究[J]. 化工学报, 2023, 74(8): 3457-3471.
[9]	高金明, 郭玉娇, 鄂承林, 卢春喜. 一种封闭罩内顺流多旋臂气液分离器的分离特性研究[J]. 化工学报, 2023, 74(7): 2957-2966.
[10]	江锦波, 彭新, 许文烜, 门日秀, 刘畅, 彭旭东. 泵出型螺旋槽油气密封泄漏特性及参数影响研究[J]. 化工学报, 2023, 74(6): 2538-2554.
[11]	刘起超, 周云龙, 陈聪. 起伏振动垂直上升管气液两相流截面含气率分析与计算[J]. 化工学报, 2023, 74(6): 2391-2403.
[12]	张媛媛, 曲江源, 苏欣欣, 杨静, 张锴. 循环流化床燃煤机组SNCR脱硝过程气液传质和反应特性[J]. 化工学报, 2023, 74(6): 2404-2415.
[13]	张艳梅, 袁涛, 李江, 刘亚洁, 孙占学. 高效SRB混合菌群构建及其在酸胁迫条件下的性能研究[J]. 化工学报, 2023, 74(6): 2599-2610.
[14]	张兰河, 赖青燚, 王铁铮, 关潇卓, 张明爽, 程欣, 徐小惠, 贾艳萍. H₂O₂对SBR脱氮效率和污泥性能的影响[J]. 化工学报, 2023, 74(5): 2186-2196.
[15]	董鑫, 单永瑞, 刘易诺, 冯颖, 张建伟. 非牛顿流体气泡羽流涡特性数值模拟研究[J]. 化工学报, 2023, 74(5): 1950-1964.