螺旋并联分配管对旋风分离器分离性能的影响

doi:10.11949/j.issn.0438-1157.20180626

化工学报 ›› 2018, Vol. 69 ›› Issue (11): 4770-4777.DOI: 10.11949/j.issn.0438-1157.20180626

螺旋并联分配管对旋风分离器分离性能的影响

唐子腾, 常玉龙, 徐磊, 黄渊, 汪华林

化学工程联合国家重点实验室, 华东理工大学, 上海 200237

收稿日期:2018-06-11 修回日期:2018-10-17 出版日期:2018-11-05 发布日期:2018-11-05
通讯作者: 汪华林
基金资助:
国家杰出青年科学基金项目（51125032）。

Effects of spiral channel on separation efficiency in cyclones

TANG Ziteng, CHANG Yulong, XU Lei, HUANG Yuan, WANG Hualin

State Key Laboratory of Chemical Engineering, East China University of Science and Technology, Shanghai 200237, China

Received:2018-06-11 Revised:2018-10-17 Online:2018-11-05 Published:2018-11-05
Supported by:
supported by the National Science Foundation for Distinguished Young Scholars of China (51125032).

摘要/Abstract

摘要：

为兼顾高分离精度及大处理量的要求，微小型旋风分离器并联得到越来越多应用。运用离散相模型和实验研究了螺旋并联分配管对旋风分离器分离性能的影响，分析了螺旋分配管分级和改变“序态”特性。结果表明，大颗粒易于从分配管前端出口逸出，依次进入旋风分离器固体颗粒呈现不同粒径分布，总体呈现分级特性；螺旋管对细颗粒物具有改变“序态”作用，进入旋风分离器颗粒粒径呈现外小内大趋势，内部相比外部颗粒浓度更高；内侧大颗粒构成的粒子环促进细小颗粒的去除，从而提高旋风分离器分离效率。实验进一步验证螺旋分配管分级和改变“序态”特性。研究结果对微小型旋风分离器并联设计具有指导意义。

关键词: 旋风分离器, 分离, 螺旋分配管, 数值模拟, 粒度分布

Abstract:

In order to give consideration to both the high separation accuracy and large processing capacity, the parallel configuration of mini-cyclones is being used more and more. The influences of the spiral channel on the separation performance of the gas cyclones were investigated and the classification capacity and influences on particle distribution of the spiral channel were analyzed by discrete phase model (DPM) and classification experiments. The results showed that the large particles were inclined to discharge from the former outlets of the spiral channel and then enter the cyclones successively. The discharged particles presented different size distributions in every outlets, which contribute to the classification. The spiral channel made influences on the fine particles to force them enter the cyclone with a state that the finer particles are close to the outside wall, and the concentration of internal section is higher than that of the external one. The particle rings formed by the large particles promoted the separation of fine particles, thereby increasing the separation efficiency of the cyclone. The experiment further verified the classification capacity and influences on particle distribution of spiral channel. The results could provide directive significance to the parallel configuration of mini-cyclones.

Key words: cyclone, separation, spiral channel, numerical simulation, size distribution

中图分类号:

TQ028.2

唐子腾, 常玉龙, 徐磊, 黄渊, 汪华林. 螺旋并联分配管对旋风分离器分离性能的影响[J]. 化工学报, 2018, 69(11): 4770-4777.

TANG Ziteng, CHANG Yulong, XU Lei, HUANG Yuan, WANG Hualin. Effects of spiral channel on separation efficiency in cyclones[J]. CIESC Journal, 2018, 69(11): 4770-4777.

参考文献 30

[1]	WU X, XIONG Z, JI Z. Separation performance of multi-cyclone separator for purification of natural gas[J]. The Chinese Journal of Process Engineering, 2010, 10(1):41-45.
[2]	RISBERG M, OHRMAN O G W, GEBART B R, et al. Influence from fuel type on the performance of an air-blown cyclone gasifier[J]. Fuel, 2014, 116(1):751-759.
[3]	PROMES E J O, WOUDSTRA T, SCHOENMAKERS L, et al. Thermodynamic evaluation and experimental validation of 253 MW integrated coal gasification combined cycle power plant in Buggenum, Netherlands[J]. Applied Energy, 2015, 155(1):181-194.
[4]	LIN C W, CHEN T J, HUANG S H, et al. Effect of aerosol loading on separation performance of PM2.5 cyclone separators[J]. Aerosol and Air Quality Research, 2018, 18(1):1366-1374.
[5]	KUO F Y, WEI H L, YAO D J. PM2.5 detection by cyclone separator combined with SH-SAW sensor[C]//2017 IEEE 12th International Conference on. IEEE, 2017:248-251.
[6]	LI R, ZHAO W, LI Y, et al. Heavy metal removal and speciation transformation through the calcination treatment of phosphorus-enriched sewage sludge ash[J]. Journal of Hazardous Materials, 2015, 283(1):423-431.
[7]	CONTINI D, GAMBARO A, DONATEO A, et al. Inter-annual trend of the primary contribution of ship emissions to PM2.5 concentrations in Venice (Italy):efficiency of emissions mitigation strategies[J]. Atmospheric Environment, 2015, 102(1):183-190.
[8]	OKUDA T, ISOBE R, NAGAI Y, et al. Development of a high-volume PM2.5 particle sampler using impactor and cyclone techniques[J]. Aerosol and Air Quality Research, 2015, 15(3):759-767.
[9]	LIU D, HSIAO T C, CHEN D R. Performance study of a miniature quadru-inlet cyclone[J]. Journal of Aerosol Science, 2015, 90(1):161-168.
[10]	SUN X, ZHANG Z, CHEN D R. Numerical modeling of miniature cyclone[J]. Powder Technology, 2017, 320(1):325-339.
[11]	ZHOU X, CHENG L, WANG Q, et al. Non-uniform distribution of gas-solid flow through six parallel cyclones in a CFB system:an experimental study[J]. Particuology, 2012, 10(2):170-175.
[12]	ABDUL-WAHAB S A, FAILAKA M F, AHMADI L, et al. Nonlinear programming optimization of series and parallel cyclone arrangement of NPK fertilizer plants[J]. Powder Technology, 2014, 264(1):203-215.
[13]	HUANG C, LÜ W, WANG J, et al. Uniform distribution design and performance evaluation for UU-type parallel mini-hydrocyclones[J]. Separation and Purification Technology, 2014, 125(1):194-201.
[14]	CHEN C, WANG H L, GAN G H, et al. Pressure drop and flow distribution in a group of parallel hydrocyclones:Z-Z-type arrangement[J]. Separation & Purification Technology, 2013, 108(16):15-27.
[15]	WANG S, LUO K, HU C, et al. CFD-DEM study of the effect of cyclone arrangements on the gas-solid flow dynamics in the full-loop circulating fluidized bed[J]. Chemical Engineering Journal, 2017, 172(1):199-215.
[16]	SONG J, WEI Y, SUN G, et al. Experimental and CFD study of particle deposition on the outer surface of vortex finder of a cyclone separator[J]. Chemical Engineering Journal, 2017, 309(1):249-262.
[17]	FU P, WANG F, MA L, et al. Fine particle sorting and classification in the cyclonic centrifugal field[J]. Separation and Purification Technology, 2016, 158(1):357-366.
[18]	LIU A L, ZHANG Y H, MA L, et al. Effect of inlet particle arrangement on separating property of a cyclone separator[J]. Korean Journal of Chemical Engineering, 2018, 1(1):1-8.
[19]	WADENPOHL D I C. Production of powder coatings with defined particle size distribution by grinding and inline classification[J]. International Journal of Mineral Processing, 2004, 74(3):S155-S164.
[20]	TSUJI H, MAKINO H, YOSHIDA H. Development of a particle size distribution measurement method at high temperature by use of classification during sampling[J]. Powder Technology, 2008, 180(1):190-195.
[21]	HIRAIWA Y, OSHITARI T, FUKUI K, et al. Effect of free air inflow method on fine particle classification of gas-cyclone[J]. Separation & Purification Technology, 2013, 118(6):670-679.
[22]	WAKIZONO Y, MAEDA T, FUKUI K, et al. Effect of ring shape attached on upper outlet pipe on fine particle classification of gas-cyclone[J]. Separation and Purification Technology, 2015, 141(1):84-93.
[23]	LIU P K, CHU L Y, WANG J, et al. Enhancement of hydrocyclone classification efficiency for fine particles by introducing a volute chamber with a pre-sedimentation function[J]. Chemical Engineering & Technology, 2010, 31(3):474-478.
[24]	LIU F, CHEN J, ZHANG A, et al. Performance and flow behavior of four identical parallel cyclones[J]. Separation & Purification Technology, 2014, 134(1):147-157.
[25]	孙占朋, 孙国刚, 独岩. 进料位置与风速对旋风分级器颗粒分级效果的影响[J]. 化工学报, 2018, 69(4):1324-1331. SUN Z P, SUN G G, DU Y. Effects of feed position and inlet gas velocity on particle classification in cyclonic classifier[J]. CIESC Journal, 2018, 69(4):1324-1331.
[26]	WANG Z B, CHU L Y, CHEN W M, et al. Experimental investigation of the motion trajectory of solid particles inside the hydrocyclone by a Lagrange method[J]. Chemical Engineering Journal, 2008, 138(1):1-9.
[27]	ZHANG C, WEI D, CUI B, et al. Effects of curvature radius on separation behaviors of the hydrocyclone with a tangent-circle inlet[J]. Powder Technology, 2017, 305(1):156-165.
[28]	HUANG A N, MAEDA N, SHIBATA D, et al. Influence of a laminarizer at the inlet on the classification performance of a cyclone separator[J]. Separation and Purification Technology, 2017, 174(1):408-416.
[29]	MISIULIA D, ANDERSSON A G, LUNDSTRÖM T S. Effects of the inlet angle on the flow pattern and pressure drop of a cyclone with helical-roof inlet[J]. Chemical Engineering Research and Design, 2015, 102(1):307-321.
[30]	FU P B, WANG F, YANG X J, et al. Inlet particle-sorting cyclone for the enhancement of PM25 separation[J]. Environmental Science & Technology, 2017, 51(3):1587-1594.

螺旋并联分配管对旋风分离器分离性能的影响

Effects of spiral channel on separation efficiency in cyclones

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 30

相关文章 15

编辑推荐

Metrics

本文评价

[1]	宋嘉豪, 王文. 斯特林发动机与高温热管耦合运行特性研究[J]. 化工学报, 2023, 74(S1): 287-294.
[2]	张思雨, 殷勇高, 贾鹏琦, 叶威. 双U型地埋管群跨季节蓄热特性研究[J]. 化工学报, 2023, 74(S1): 295-301.
[3]	叶展羽, 山訸, 徐震原. 用于太阳能蒸发的折纸式蒸发器性能仿真[J]. 化工学报, 2023, 74(S1): 132-140.
[4]	张义飞, 刘舫辰, 张双星, 杜文静. 超临界二氧化碳用印刷电路板式换热器性能分析[J]. 化工学报, 2023, 74(S1): 183-190.
[5]	王志国, 薛孟, 董芋双, 张田震, 秦晓凯, 韩强. 基于裂隙粗糙性表征方法的地热岩体热流耦合数值模拟与分析[J]. 化工学报, 2023, 74(S1): 223-234.
[6]	赵亚欣, 张雪芹, 王荣柱, 孙国, 姚善泾, 林东强. 流穿模式离子交换层析去除单抗聚集体[J]. 化工学报, 2023, 74(9): 3879-3887.
[7]	何松, 刘乔迈, 谢广烁, 王斯民, 肖娟. 高浓度水煤浆管道气膜减阻两相流模拟及代理辅助优化[J]. 化工学报, 2023, 74(9): 3766-3774.
[8]	刘爽, 张霖宙, 许志明, 赵锁奇. 渣油及其组分黏度的分子层次组成关联研究[J]. 化工学报, 2023, 74(8): 3226-3241.
[9]	韩晨, 司徒友珉, 朱斌, 许建良, 郭晓镭, 刘海峰. 协同处理废液的多喷嘴粉煤气化炉内反应流动研究[J]. 化工学报, 2023, 74(8): 3266-3278.
[10]	邢雷, 苗春雨, 蒋明虎, 赵立新, 李新亚. 井下微型气液旋流分离器优化设计与性能分析[J]. 化工学报, 2023, 74(8): 3394-3406.
[11]	张佳怡, 何佳莉, 谢江鹏, 王健, 赵鹬, 张栋强. 渗透汽化技术用于锂电池生产中N-甲基吡咯烷酮回收的研究进展[J]. 化工学报, 2023, 74(8): 3203-3215.
[12]	程小松, 殷勇高, 车春文. 不同工质在溶液除湿真空再生系统中的性能对比[J]. 化工学报, 2023, 74(8): 3494-3501.
[13]	刘文竹, 云和明, 王宝雪, 胡明哲, 仲崇龙. 基于场协同和耗散的微通道拓扑优化研究[J]. 化工学报, 2023, 74(8): 3329-3341.
[14]	张瑞航, 曹潘, 杨锋, 李昆, 肖朋, 邓春, 刘蓓, 孙长宇, 陈光进. ZIF-8纳米流体天然气乙烷回收工艺的产品纯度关键影响因素分析[J]. 化工学报, 2023, 74(8): 3386-3393.
[15]	洪瑞, 袁宝强, 杜文静. 垂直上升管内超临界二氧化碳传热恶化机理分析[J]. 化工学报, 2023, 74(8): 3309-3319.