起伏振动状态下倾斜管内两相流多尺度熵分析

doi:10.11949/j.issn.0438-1157.20171087

摘要/Abstract

摘要：

将振动装置和气液两相流实验回路相结合，在起伏振动状态下对倾斜管内气液两相流进行实验研究，观察记录流型并使用多尺度熵方法对压差波动信号进行分析。研究结果表明振动条件下倾斜管内出现两种新流型为珠状流、起伏弹状流。同时对95种流动条件下的5种典型流型的差压波动信号进行多尺度熵分析。结果表明，不同流型在低尺度（前9个）下的熵值变化率有明显不同，高尺度下的熵值可以反映不同流型的动力学特性。

关键词: 起伏振动, 多尺度, 熵, 倾斜管, 气液两相流

Abstract:

After combined vibration apparatus with experiment loop of two-phase flow, gas-liquid two-phase flow in inclined pipe was studied experimentally under fluctuant vibration. The flow patterns were recorded and pressure fluctuation signal was analyzed by multiscale entropy method. The results indicate that two new flow patterns of bead flow and fluctuant slug flow are created in inclined pipe under vibration condition. Multiscale entropy analyses were performed on pressure fluctuation signals of five typical flow patterns under 95 different flow conditions. Results show that entropy change rate of different flow patterns at low scale (first nine) is obviously different and entropy at high scale can reflect dynamic characteristics of different flow patterns.

Key words: fluctuant vibration, multiscale, entropy, inclined pipe, gas-liquid two-phase flow

中图分类号:

O359

周云龙, 李珊珊. 起伏振动状态下倾斜管内两相流多尺度熵分析[J]. 化工学报, 2018, 69(5): 1884-1891.

ZHOU Yunlong, LI Shanshan. Multiscale entropy analysis of two-phase flow in inclined pipe under vibration condition[J]. CIESC Journal, 2018, 69(5): 1884-1891.

参考文献 31

[1]	李洪伟, 周云龙, 宋倩, 等. 水平气液两相流流型图像信息递归特征分析[J]. 化工学报, 2010, 61(6):1431-1436. LI H W, ZHOU Y L, SONG Q, et al. Recursive feature of gas-liquid two-phase flow pattern based on information entropy series of flow image[J]. CIESC Journal, 2010, 61(6):1431-1436.
[2]	金光远, 阎昌琪, 孙立成, 等. 摇摆条件下窄矩形通道内两相流动瞬态阻力特性研究[J]. 原子能科学技术, 2013, 47(9):1549-1553. JIN G Y, YAN C Q, SUN L C, et al. Research on transient flow resistance of two -phase flow in narrow rectangular channel in rolling motions[J]. Atomic Energy Science and Technology, 2013, 47(9):1549-1533.
[3]	栾峰, 阎昌琪, 曹夏昕. 摇摆对竖直管内气-水两相流流型的影响分析[J]. 工程热物理学报, 2007, 28(suppl.1):217-220. LUAN F, YAN C Q, CAO X X. Research for rolling effects upon flow pattern of upward gas-water flow in vertical tubes[J]. Journal of Engineering Thermophysics, 2007, 28(suppl.1):217-220.
[4]	王广飞, 曹夏昕. 摇摆状态下窄矩形通道内两相流流型特性研究[J]. 原子能科学技术, 2011, 45(11):1329-1333. WANG G F, CAO X X. Flow pattern characteristics of two-phase flow through narrow rectangular channel under roling condition[J]. Atomic Energy Science and Technology, 2011, 45(11):1329-1333.
[5]	张金红, 阎昌琪, 方红宇, 等. 摇摆对水平管内气液两相流流型的影响[J]. 核科学与工程, 2007, 27(3):206-211. ZHANG J H, YAN C Q, FANG H Y, et al. Effects of rolling on gas-water two-phase flow in horizontal pipes[J]. Chinese Journal of Nuclear Science and Engineering, 2007, 27(3):206-211.
[6]	贾辉, 曹夏昕, 阎昌琪, 等. 摇摆状态下气液两相流流型转变的实验研究[J]. 核科学与工程, 2006, 26(3):209-214. JIA H, CAO X X, YAN C Q, et al. Experimental study on two-phase flow pattern transition in rolling tubes[J]. Chinese Journal of Nuclear Science and Engineering, 2006, 26(3):209-214.
[7]	王鸿雁. 气液两相弹状流在摇摆条件下的运动特性研究[D]. 哈尔滨:哈尔滨工程大学, 2010. WANG H Y. Investigation of flow characteristics for two-phase slug flow under rolling condition[D]. Harbin:Harbin Engineering University, 2010.
[8]	肖秀, 朱庆子, 王冠轶, 等. 振动工况下环管内气液两相流参数分布实验研究[J]. 原子能科学技术, 2017, 51(1):19-25. XIAO X, ZHU Q Z, WANG G Y, et al. Experiment investigation on two-phase flow parameter distribution in annular channel under vibration condition[J]. Atomic Energy Science and Technology, 2017, 51(1):19-25.
[9]	CHEN S W, HIBIKI T, ISHⅡ M, et al. Experimental study of adiabatic two-phase flow in an annular channel under low-frequency vibration[J]. Journal of Engineering for Gas Turbines and Powers, 2014, 136:032501.
[10]	赵盘, 周云龙, 杨宁. 振动状态下水平管内气液两相流流型转变的实验研究[J]. 热能动力工程, 2017, 32(6):17-22. ZHAO P, ZHOU Y L, YANG N. Experimental study on flow pattern transition of gas liquid two-phase flow in horizontal tubes under vibration condition[J]. Journal of Engineering for Thermal Energy and Power, 2017, 32(6):17-22.
[11]	丁浩, 黄志尧, 李海青. 气液两相流差压波动信号的Hilbert-Huang变换特性[J]. 化工学报, 2005, 56(12):2294-2302. DING H, HUANG Z Y, LI H Q. Property of differential pressure fluctuation signal of gas-liquid two-phase flow based on Hilbert-Huang transform[J]. Journal of Chemical Industry and Engineering(China), 2005, 56(12):2294-2302.
[12]	王经.气液两相流动态特性的研究[M].上海:上海交通大学出版社, 2012. WANG J. Research on the Dynamic Behavior of Gas-Liquid Two-phase Flow[J]. Shanghai:Shanghai Jiao Tong University Press, 2012.
[13]	WU H J, ZHOU F D, WU Y Y. Intelligent identification system of flow regime of oil/gas/water[J]. Int. J. Multiphase Flow, 2001, 27:459-475.
[14]	赵贵兵, 阳永荣. 流化床压力波动多尺度多分形特征[J]. 高校化学工程学报, 2003, 17(6):648-653. ZHAO G B, YANG Y R. Characteristics of multi-scale and multi-fractal of pressure signals in a bubbling fluidized bed[J]. Journal of Chemical Engineering of Chinese Universities, 2003, 17(6):648-653.
[15]	樊春玲, 金宁德, 陈秀霆, 等. 两相流流动结构多尺度复杂熵因果关系平面特征[J]. 化工学报, 2015, 66(4):1301-1309. FAN C L, JIN N D, CHEN X T, et al. Two-phase flow structure in multi-scale complexity entropy causality plane[J]. CIESC Journal, 2015, 66(4):1301-1309.
[16]	周云龙, 顾杨杨. 基于独立分量分析和RBF神经网络的气液两相流流型识别[J]. 化工学报, 2012, 63(3):796-799. ZHOU Y L, GU Y Y. Flow regime identification of gas-liquid two-phase flow based ICA and RBF neural networks[J]. CIESC Journal, 2012, 63(3):796-799.
[17]	金宁德, 苗龄予, 李伟波. 气液两相流差压测量波动信号的符号序列统计分析[J].化工学报, 2007, 58(2):327-334. JIN N D, MIAO L Y, LI W B. Symbolic sequence statistical analysis of differential pressure measurement fluctuating signal of gas-liquid two-phase flow[J]. Journal of Chemical Industry and Engineering (China), 2007, 58(2):327-334.
[18]	董芳. 气液两相流流动结构多尺度及非线性特性分析[D]. 天津:天津大学, 2007. DONG F. Multi-scale and nonlinear characteristic analysis of gas-liquid two-phase flow structure[D].Tianjin:Tianjin University, 2007.
[19]	樊春玲, 李浩杰, 孙迎慧. 基于多尺度化基本尺度熵的两相流流型特性分析[J]. 青岛科技大学学报(自然科学版), 2015, 36(6):680-684. FAN C L, LI H J, SUN Y H. Characterization of two-phase flow pattern based on multiscale base-scale entropy[J]. Journal of Qingdao University of Science and Technology(Natural Science Edition), 2015, 36(6):680-684.
[20]	周云龙, 刘旭, 李洪伟. 2种熵测度在分析流型信号复杂度上的应用[J].化学工程, 2011, 39(8):53-56. ZHOU Y L, LIU X, LI H W. Application of two entropy measures to analyzing complexity of multiphase flow signal[J]. Chemical Engineering(China), 2011, 39(8):53-56.
[21]	董芳, 方立德, 李小亭. 功率谱熵在垂直于水平流向的气液两相流压差信号中的应用[J]. 河北大学学报(自然科学版), 2014, 34(5):541-545. DONG F, FANG L D, LI X T. Application of spectral entropy on the differential pressure signals against to the horizontal flow direction in gas-liquid two-phase flow[J]. Journal of Hebei University (Natural Science Edition), 2014, 34(5):541-545.
[22]	杨靖, 郭烈锦. 气液两相流压差信号的非线性分析[J]. 中国电机工程学报, 2002, 22(7):134-139. YANG J, GUO L J. A nonlinear analysis on differential pressure drop signal for gas-liquid two-phase flow[J]. Proceedings of the CSEE, 2002, 22(7):134-139.
[23]	李文升, 郭烈锦, 谢晨. 集输立管内气水两相流压差信号的特征分析[J]. 工程热物理学报, 2015, 36(6):1247-1251. LI W S, GUO L J, XIE C. Analysis on the signal features of differential pressure for air-water two-phase flow in pipeline-riser system[J]. Journal of Engineering Thermophysics, 2015, 36(6):1247-1251.
[24]	RICHMAN J S, MOORMAN J R. Physiological time-series analysis using approximate entropy and sample entropy[J]. American Journal of Physiology-Heart and Circulatory Physiology, 2000, 278(6):H2039-H2049.
[25]	李春峰, Christopher Liner. 基于小波多尺度分析的奇性指数:一种新地震属性[J]. 地球物理学报, 2005, 48(4):882-887. LI C F, CHRISTOPHER L. Singularity exponent from wavelet-based multiscale analysis:a new seismic attribute[J]. Chinese Journal of Geophysics, 2005, 48(4):882-887.
[26]	COSTA M, GOLDBERGER A L, PENG C K. Multiscale entropy analysis of complex physiologic time series[J]. Physical Review Letters, 2002, 89(6):068102.
[27]	郑桂波, 金宁德. 两相流流型多尺度熵及动力学特性分析[J].物理学报, 2009, 58(7):4485-4492. ZHENG G B, JIN N D. Multiscale entropy and dynamic characteristics of two-phase flow patterns[J]. Physical Review Letters, 2009, 58(7):4485-4492.
[28]	ZHOU Y L, HOU Y D, LI H W, et al. Flow pattern map and multi-scale entropy analysis in 3×3 rod bundle channel[J]. Annals of Nuclear Energy, 2015, 80:144-150.
[29]	周云龙, 尹洪梅, 丁会晓. 多尺度熵在棒束通道气液两相流压差信号分析中的应用[J].化工学报, 2016, 67(9):3625-3631. ZHOU Y L, YIN H M, DING H X. Application of multi-scale entropy in analyzing pressure difference signals of gas-liquid two-phase flow in rod bundled channel[J]. CIESC Journal, 2016, 67(9):3625-3631.
[30]	侯延栋. 棒束通道内两相沸腾换热特性及压差波动特性的研究[D]. 吉林:东北电力大学, 2015. HOU Y D. Investigation on the characteristics of two-phase boiling heat transfer and differential pressure fluctuation in rod bundle channel[D]. Jilin:North East Electric Power University, 2015.
[31]	葛家怡, 周鹏, 赵欣, 等. 脑电信号的多尺度熵分析[J].计算机工程与应用, 2009, 45(10):13-19. GE J Y, ZHOU P, ZHAO X, et al. Multiscale entropy analysis of EEG signal[J]. Computer Engineering and Applications, 2009, 45(10):13-15.