富氧燃烧烟气冷凝塔钠碱法脱硫过程SO2和CO2共吸收建模与实验研究

doi:10.11949/j.issn.0438-1157.20180417

化工学报 ›› 2018, Vol. 69 ›› Issue (9): 4019-4029.DOI: 10.11949/j.issn.0438-1157.20180417

富氧燃烧烟气冷凝塔钠碱法脱硫过程SO₂和CO₂共吸收建模与实验研究

刘敦禹¹, Terry Wall², Rohan Stanger²

1. 上海理工大学能源与动力工程学院, 上海 200093;
2. Chemical Engineering, University of Newcastle, NSW Newcastle 2308, Australia

收稿日期:2018-04-19 修回日期:2018-06-29 出版日期:2018-09-05 发布日期:2018-09-05
通讯作者: 刘敦禹
基金资助:
上海市浦江人才项目（16PJ1407900）；澳大利亚清洁煤研究和发展项目（6-0710-0061）。

Experimental and modelling study on co-absorption of SO₂ and CO₂ during desulfurization process by flue gas cooler for oxy-fuel combustion flue gas

LIU Dunyu¹, WALL Terry², STANGER Rohan²

1. School of Energy and Power Engineering, University of Shanghai for Science and Technology, Shanghai 200093, China;
2. Chemical Engineering, University of Newcastle, NSW Newcastle 2308, Australia

Received:2018-04-19 Revised:2018-06-29 Online:2018-09-05 Published:2018-09-05
Supported by:
supported by the Shanghai Pujiang Program (16PJ1407900) and ANLEC R&D Project (6-0710-0061).

摘要/Abstract

摘要：

建立SO₂与CO₂共吸收到钠基溶液中的吸收速率模型，假设该模型中SO₂的水解反应为瞬间反应；关于CO₂水解反应存在两种假设：有限动力学假设和瞬间反应假设。由这两种方法计算分别获得SO₂的吸收速率并与完全预混气液反应器中的的动态实验进行对比。采用瞬间反应假设可以预测反应速率的趋势，绝对反应速率误差仍然较大。而采用有限动力学假设的模拟值与实验值在pH>3吻合良好。CO₂对SO₂吸收速率的影响主要通过影响气相传质系数和相同pH下溶液总硫浓度产生。根据CO₂存在与否对SO₂吸收速率的影响，获得五个不同的相互作用pH的区间。pH>11.42时，SO₂/N₂吸收速率大于SO₂/CO₂，主要由于气相传质系数影响；7.8 < pH < 11.42时，SO₂/N₂的吸收速率和SO₂/CO₂吸收速率相似，主要由于气相传质系数和溶液总硫影响抵消；5.41 < pH < 7.8时，SO₂/CO₂的吸收速率相对较高，主要由于溶液总硫影响更大；2.8 < pH < 5.41时，SO₂/CO₂的吸收速率相对较低，主要由于气相传质系数影响；pH < 2.8时，SO₂/N₂和SO₂/CO₂吸收速率相似，主要受液相传质的控制。模拟同时获得不同pH下溶液中碳和硫相关离子的转化规律和SO₂吸收速率的控制步骤，为富氧燃烧冷却塔同时脱硫设备的设计和运行提供参考。

关键词: 富氧燃烧, 冷却塔, 吸收

Abstract:

This paper aims to set up the theoretical model for co-absorption of SO₂ and CO₂ into sodium based solutions. Instantaneous reaction for SO₂ hydrolysis is assumed. For the hydrolysis of CO₂, there are two assumptions:finite kinetics and instantaneous reaction. Based on these two assumptions, the absorption rates of SO₂ were separately calculated and compared with dynamic experiments in the well stirred reactor. The trend for the absorption rate of SO₂ was well predicted by the instantaneous reaction for CO₂. The relative error for the absolute rates of SO₂ is high. The prediction based on the finite kinetics for CO₂ hydrolysis at pH>3 agrees well with experiments. The influences of CO₂ on the SO₂ absorption rate is primarily through gas phase mass transfer coefficient and total sulphur concentration at the same pH. Depending on the existence of CO₂ on SO₂ absorption rate, five pH regimes for interaction were observed. At pH>11.42, the absorption rate of SO₂/N₂ is higher than that of SO₂/CO₂ due to the influence of gas phase mass transfer coefficient. At 7.8 < pH < 11.42, the absorption rate of SO₂/N₂ is similar with that of SO₂/CO₂ due to the counteraction of gas phase mass transfer coefficient and total sulphur in liquid. At 5.41 < pH < 7.8, the absorption rate of SO₂/CO₂ is higher due to the influence of total sulphur in liquid. At 2.8 < pH < 5.41, the absorption rate of SO₂/CO₂ is relative lower primarily due to the influence of gas phase mass transfer coefficient. At pH < 2.8, the absorption rate of SO₂/N₂ is similar with that of SO₂/CO₂ due to liquid phase controlled region. Conversion of carbon and sulphur based ions at different pH and controlling regions for SO₂ absorption rate were obtained. The work provides guidance for the design and operation of flue gas cooler for oxy-fuel combustion flue gas.

Key words: oxy-fuel combustion, flue gas cooler, absorption

中图分类号:

TQ02

刘敦禹, Terry Wall, Rohan Stanger. 富氧燃烧烟气冷凝塔钠碱法脱硫过程SO₂和CO₂共吸收建模与实验研究[J]. 化工学报, 2018, 69(9): 4019-4029.

LIU Dunyu, WALL Terry, STANGER Rohan. Experimental and modelling study on co-absorption of SO₂ and CO₂ during desulfurization process by flue gas cooler for oxy-fuel combustion flue gas[J]. CIESC Journal, 2018, 69(9): 4019-4029.

参考文献 30

[1]	WALL T, STANGER R, LIU Y. Gas cleaning challenges for coal-fired oxy-fuel technology with carbon capture and storage[J]. Fuel, 2013, 108(11):85-90.
[2]	LIU D, JIN J, GAO M, et al. A comparative study on the design of direct contact condenser for air and oxy-fuel combustion flue gas based on callide oxy-fuel project[J]. International Journal of Greenhouse Gas Control, 2018, 75:74-84.
[3]	FABER R, YAN J, STARK F, et al. Flue gas desulphurization for hot recycle oxyfuel combustion:experiences from the 30 MWth oxyfuel pilot plant in Schwarze Pumpe[J]. International Journal of Greenhouse Gas Control, 2011, (5S):S210-S223.
[4]	LUO W, WANG Q, HUANG X, et al. Dynamic simulation and transient analysis of a 3 MWth oxy-fuel combustion system[J]. International Journal of Greenhouse Gas Control, 2015, 35:138-149.
[5]	LIU D, WALL T, STANGER R. CO2 quality control in oxy-fuel technology for CCS:SO2 removal by the caustic scrubber in callide oxy-fuel project[J]. International Journal of Greenhouse Gas Control, 2016, 51:207-217.
[6]	LIU D, LIU Y, WALL T. CO2 quality control in oxy-fuel combustion:a dynamic study on the absorption of SO2 into sodium based aqueous solutions relevant to scrubbing prior to CO2 compression[J]. International Journal of Greenhouse Gas Control, 2013, 12:2-8.
[7]	CHANG C S, ROCHELLE G T. SO2 absorption into aqueous solutions[J]. AIChE Journal, 1981, 27(2):292-298.
[8]	CHANG C S, ROCHELLE G T. SO2 absorption into NaOH and Na2SO3 aqueous solutions[J]. American Chemical Society, 1985, 24(1):7-11.
[9]	HIKITA H, ASAI S, TSUJI T. Absorption of sulfur dioxide into aqueous sodium hydroxide and sodium sulfite solutions[J]. AIChE Journal, 1977, 23(4):538-544.
[10]	HIKITA H, KONISHI Y. Absorption of sulfur dioxide into aqueous sodium carbonate solutions and desorption of carbon dioxide[J]. Bulletin of University of Osaka Prefecture Series A, Engineering and Natural Sciences, 1981, 30(1):29-40.
[11]	HIKITA H, KONISHI Y. The absorption of SO2 into aqueous Na2CO3 solutions accompanied by the desorption of CO2[J]. The Chemical Engineering Journal, 1983, 27(3):167-176.
[12]	SADA E, KUMAZAWA H, HOSHINO T. Absorption of lean SO2 in aqueous solutions of Na2CO3 and desorption of CO2[J]. The Chemical Engineering Journal, 1979, 18(1):125-130.
[13]	EBRAHIMI S, PICIOREANU C, KLEEREBEZEM R, et al. Rate-based modelling of SO2 absorption into aqueous NaHCO3/Na2CO3 solutions accompanied by the desorption of CO2[J]. Chemical Engineering Science, 2003, 58(16):3589-3600.
[14]	SCHULTES M. Absorption of sulphur dioxide with sodium hydroxide solution in packed columns[J]. Chemical Engineering & Technology, 1998, 21(2):201-209.
[15]	EDWARDS T J, MAURER G, NEWMAN J, et al. Vapor-liquid equilibria in multicomponent aqueous solutions of volatile weak electrolytes[J]. AIChE Journal, 1978, 24(6):966-976.
[16]	KAWAZUISHI K, PRAUSNITZ J M. Correlation of vapor-liquid equilibria for the system ammonia-carbon dioxide-water[J]. Industrial & Engineering Chemistry Research, 1987, 26(7):1482-1485.
[17]	MORGAN R S. A thermodynamic study of the system sodium sulfite-sodium bisulfite-water at 25℃[D]. Appleton:Lawrence College, 1960.
[18]	PINSENT B R W, ROUGHTON F J W. The kinetics of combination of carbon dioxide with water and hydroxide ions[J]. Transactions of the Faraday Society, 1951, 47:263-269.
[19]	DANCKWERTS P V, KENNEDY A M. The kinetics of absorption of carbon dioxide into neutral and alkaline solutions[J]. Chemical Engineering Science, 1958, 8(3/4):201-215.
[20]	PINSENT B R W, PEARSON L, ROUGHTON F J W. The kinetics of combination of carbon dioxide with hydroxide ions[J]. Transactions of the Faraday Society, 1956, 52:1512-1520.
[21]	HIKITA H, ASAI S, TAKATSUKA T. Absorption of carbon dioxide into aqueous sodium hydroxide and sodium carbonate-bicarbonate solutions[J]. The Chemical Engineering Journal, 1976, 11(2):131-141.
[22]	ZHOU L, BELLVILLE D J, ZBACNIK E P. Process for simultaneous removal of carbon dioxide and sulfur oxides from flue gas:US 20100135881A1[P]. 2010-6-3.
[23]	HANSEN B B, FOGH F, KNUDSEN N O, et al. Performance of a wet flue gas desulfurization pilot plant under oxy-fuel conditions[J]. Industrial & Engineering Chemistry Research, 2011, 50(8):4238-4244.
[24]	ANHEDEN M, BURCHHARDT U, ECKEA H, et al. Overview of operational experience and results from test activities in Vattenfall's 30 MWth oxyfuel pilot plant in Schwarze Pumpe[J]. Energy Procedia, 2011, 4:941-950.
[25]	LIU D, LIU Y, WALL T, et al. CO2 quality control by scrubbing in oxy-fuel combustion prior to compression:relating pH to the liquid composition from absorption of SO2 into sodium based solutions to identify an operational pH window[J]. International Journal of Greenhouse Gas Control, 2013, 19:462-470.
[26]	LIU D, WALL T, STANGER R. CO2 quality control through scrubbing in oxy-fuel combustion:an evaluation of operational pH impacts, and prediction of SO2 absorption rate at steady state[J]. International Journal of Greenhouse Gas Control, 2015, 32:37-46.
[27]	VYSOCHANSKIJ D F, PETUNIN Y I. Justification of the 3σ rule for unimodal distributions[J]. Theory of Probability & Mathematical Statistics, 1980, 21:25-36.
[28]	PUKELSHEIM F. The three Sigma rule[J]. American Statistician, 1994, 48(2):88-91.
[29]	BERENDSEN H J C. A Student's Guide to Data and Error Analysis[M]. Cambridge:Cambridge University Press, 2011.
[30]	DANCKWERTS P V. Gas-Liquid Reactions[M]. New York:McGraw-Hill, 1970.

富氧燃烧烟气冷凝塔钠碱法脱硫过程SO₂和CO₂共吸收建模与实验研究

Experimental and modelling study on co-absorption of SO₂ and CO₂ during desulfurization process by flue gas cooler for oxy-fuel combustion flue gas

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 30

相关文章 15

编辑推荐

Metrics

本文评价

[1]	黄琮琪, 吴一梅, 陈建业, 邵双全. 碱性电解水制氢装置热管理系统仿真研究[J]. 化工学报, 2023, 74(S1): 320-328.
[2]	金正浩, 封立杰, 李舒宏. 氨水溶液交叉型再吸收式热泵的能量及分析[J]. 化工学报, 2023, 74(S1): 53-63.
[3]	米泽豪, 花儿. 基于DFT和COSMO-RS理论研究多元胺型离子液体吸收SO₂气体[J]. 化工学报, 2023, 74(9): 3681-3696.
[4]	张瑞航, 曹潘, 杨锋, 李昆, 肖朋, 邓春, 刘蓓, 孙长宇, 陈光进. ZIF-8纳米流体天然气乙烷回收工艺的产品纯度关键影响因素分析[J]. 化工学报, 2023, 74(8): 3386-3393.
[5]	胡兴枝, 张皓焱, 庄境坤, 范雨晴, 张开银, 向军. 嵌有超小CeO₂纳米粒子的碳纳米纤维的制备及其吸波性能[J]. 化工学报, 2023, 74(8): 3584-3596.
[6]	杨灿, 孙雪琦, 尚明华, 张建, 张香平, 曾少娟. 相变离子液体体系吸收分离CO₂的研究现状及展望[J]. 化工学报, 2023, 74(4): 1419-1432.
[7]	李木金, 胡松, 施德磐, 赵鹏, 高瑞, 李进龙. 环氧丁烷尾气溶剂吸收及精制工艺[J]. 化工学报, 2023, 74(4): 1607-1618.
[8]	何万媛, 陈一宇, 朱春英, 付涛涛, 高习群, 马友光. 阵列凸起微通道内气液两相传质特性研究[J]. 化工学报, 2023, 74(2): 690-697.
[9]	王煦清, 严圣林, 朱礼涛, 张希宝, 罗正鸿. 填料塔中有机胺吸收CO₂气液传质的研究进展[J]. 化工学报, 2023, 74(1): 237-256.
[10]	张逸伟, 唐海荣, 何勇, 朱燕群, 王智化. 臭氧低温氧化烟气脱硝过程中的氮平衡试验研究[J]. 化工学报, 2022, 73(4): 1732-1742.
[11]	姜焱龙, 张妮, 李淡然, 朱冰冰, 蒋怡晨, 陈海军, 朱跃钊. 基于COSMO-RS方法筛选离子液体用于焦油脱除[J]. 化工学报, 2022, 73(4): 1704-1713.
[12]	霍猛, 彭晓婉, 赵金, 马秋伟, 邓春, 刘蓓, 陈光进. 基于COSMO-RS的离子液体吸收CO的溶剂筛选及H₂/CO分离实验[J]. 化工学报, 2022, 73(12): 5305-5313.
[13]	高帅涛, 刘雪珂, 张丽, 刘芬, 余江, 商剑锋, 欧天雄, 周政, 陈平文. Aspen Plus模拟高浓度H₂S/CO₂酸性气的选择性分离[J]. 化工学报, 2021, 72(S1): 413-420.
[14]	陈尔健, 代彦军. 使用NH₃-LiNO₃工质对的增压型回热吸收循环性能分析[J]. 化工学报, 2021, 72(S1): 445-452.
[15]	徐梦凯, 李舒宏, 金正浩. 氨-水-溴化锂三元工质氨吸收式制冷性能[J]. 化工学报, 2021, 72(S1): 127-133.