隔板塔共沸精馏分离二氯甲烷-乙腈-水-硅醚体系

doi:10.3969/j.issn.0438-1157.2013.03.025

化工学报 ›› 2013, Vol. 64 ›› Issue (3): 963-969.DOI: 10.3969/j.issn.0438-1157.2013.03.025

隔板塔共沸精馏分离二氯甲烷-乙腈-水-硅醚体系

方静, 王宝东, 李春利, 李莉洁, 李艳鹏

河北工业大学化工学院,天津 300130

收稿日期:2012-08-04 修回日期:2012-09-25 出版日期:2013-03-05 发布日期:2013-03-05
通讯作者: 李春利
作者简介:方静(1977—),女,博士,副教授。
基金资助:
河北省高等学校科学技术研究重点项目(ZH2011221);河北省自然科学基金项目(B2012202072)。

Separation of dichloromethane-acetonitrile-water-hexamethyl disiloxane with dividing wall column by azeotropic distillation

FANG Jing, WANG Baodong, LI Chunli, LI Lijie, LI Yanpeng

School of Chemical Engineering, Hebei University of Technology, Tianjin 300130, China

Received:2012-08-04 Revised:2012-09-25 Online:2013-03-05 Published:2013-03-05
Supported by:
supported by the Institution of Higher Education Science and Technology Research Key Project of Hebei Province(ZH2011221)and the Natural Science Foundation of Hebei Province(B2012202072).

摘要/Abstract

摘要： 以二氯甲烷-乙腈-水-硅醚为分离体系,采用自制隔板塔小试装置,研究了共沸剂回流比和液相分配比等操作参数对隔板塔分离效果的影响。实验结果表明,当气相分配比R_v为0.5,共沸剂回流比为3时,液相分配比R_l在[0.12,0.2]范围内,隔板塔分离效果较好。在实验的基础上,采用Aspen Plus软件对隔板塔共沸精馏工艺进行模拟,考察了隔板塔共沸精馏工艺最佳操作区域及节能效果。模拟结果表明,特定分离要求下,隔板塔存在一个使再沸器热负荷最小的最佳操作区域,在此最佳操作区域内,R_l和R_v相互关联,呈一一对应关系;与三塔串联简单精馏工艺相比,完成相同的分离任务,隔板塔共沸精馏工艺再沸器节能32.74%,冷凝器热负荷减少33.70%,乙腈回收率由66.47%提高到96.01%,且大幅降低设备投资。

关键词: 隔板塔, 共沸精馏, 优化, 节能

Abstract: The separation of dichloromethane,acetonitrile,water,and hexamethyl disiloxane mixture with a self-made dividing wall column(DWC)was investigated experimentally.The effects of manipulative parameters,such as azeotropic agent reflux ratio and liquid split,on the separation were discussed.According to the experimental results,the process of azeotropic distillation with DWC was simulated with Aspen Plus.The experimental results demonstrate that the separation effect is better in the range of liquid split(R_l)0.12—0.2 at vapor split(R_v) of 0.5 and entrainer reflux ratio of 3.The simulation results illustrate the optimum operation region and energy saving effect.In the optimum operation region,the thermal load of DWC reboiler is the minimum under specific requirements of separation.In the best operation region,R_l and R_v interrelate with each other.The comparison of energy consumption with that of conventional distillation sequences shows that the reboiler duty is reduced by 32.74%,the condenser duty is reduced by 33.70%,the recovery rate of acetonitrile is increased from 66.47% to 96.01%,and the cost of equipment is decreased substantially.

Key words: dividing wall column, azeotropic distillation, optimization, energy saving

中图分类号:

TQ028.1

方静, 王宝东, 李春利, 李莉洁, 李艳鹏. 隔板塔共沸精馏分离二氯甲烷-乙腈-水-硅醚体系[J]. 化工学报, 2013, 64(3): 963-969.

FANG Jing, WANG Baodong, LI Chunli, LI Lijie, LI Yanpeng. Separation of dichloromethane-acetonitrile-water-hexamethyl disiloxane with dividing wall column by azeotropic distillation[J]. CIESC Journal, 2013, 64(3): 963-969.

参考文献 18

[1]	Repke J U,Kein A,Bogle D,et al.Pressure swing batch distillation for homogeneous azeotropic separation[J].Chem.Eng.Res.Des.,2007,85(4):492-501
[2]	Xu Wenyou(许文友).Measurement and correlation of liquid-liquid equilibrium data for acetonitrile-water-potassium fluoride and acetonitrile-water-potassium carbonate systems[J].Journal of Chemical Industry and Engineering(China)(化工学报),2001,52 (8):742-745
[3]	Takamuku T,Noguchi Y,Yoshikawa E,et al.Alkali chlorides-induced phase separation of acetonitrile-water mixtures studied by small angle neutron scattering[J].J.Mol.Liq.,2007,131/132:131-138
[4]	Cui Xianbao(崔现宝),Li Yang(李杨),Feng Tianyang(冯天扬).Separation of acetonitrile-water by saline extractive distillation[J].Petrochemical Technology(石油化工),2007,36(12):1229-1233
[5]	Eric W Luster.Apparatus for practionating cracked products:US,1915681.1933-06-27
[6]	Yang Youqi(杨友麒).Simulation study of operational performance of thermally coupled distillation[J].Journal of Chemical Industry and Engineering(China)(化工学报),1990,41(4):491-497
[7]	Rong B G,Kraslawski A.Optimal design of distillation flow sheets with a lower number of thermal couplings for multicomponent separations[J].Ind. Eng.Chem.Res.,2002,41(21):5716-5725
[8]	Becker H.Partitioned distillation columns—why,when and how[J].Chem.Eng.,2001,108(1):68-74
[9]	Schultz Michael A.Reduce costs with dividing-wall columns[J].Chemical Engineering Progress,2002,98(5):64-71
[10]	Ennenbach F.Dividing-wall column—a novel distillation concept[J].Petroleum Technology Quarterly,2000(3):97-103
[11]	Kolbe Barbel,Wenzel Sascha.Novel distillation concepts using one shell columns[J].Chemical Engineering and Processing,2004,43(3):339-346
[12]	Parkinson G.Distillation:new wrinkles for an age-old technology[J].Chemical Engineering Progress,2005,101(7):10-12
[13]	Suphanit B,Bischert A,Narataruksa P.Energy loss analysis of heat transfer across the wall of the dividing-wall distillation column[J].Energy,2007,32:2121-2134
[14]	Parkinson G.The divide in distillation[J].Chem.Eng.,1999,106(4):32-35
[15]	Gong Chao(龚超),Yu Aiping(余爱平),Luo Yiqing(罗祎青),Yuan Xigang(袁希钢).Design,simulation and optimization of fully thermally coupled distillation column[J].CIESC Journal(化工学报),2012,63(1):177-184
[16]	Carlberg N A,Westerberg A W.Temperature heat diagrams for complex columns(Ⅱ):Underwood's method for side strippers and enrichers[J].Ind. Eng. Chem. Res.,1989,28:1379-1386
[17]	Zhu Huaigong(朱怀工),Wang Yan(王燕),Zhang Minqing(张敏卿).Influence of feed property on the operation of dividing wall column[J].Chemical Industry and Engineering Progress(化工进展),2009,28(4):579-583
[18]	Ivar J Halvorsen,Sigurd Skogestad.Optimal operation of Petlyuk distillation:steady-state behavior[J].Journal of Process Control,1999,9(5):407-424

隔板塔共沸精馏分离二氯甲烷-乙腈-水-硅醚体系

Separation of dichloromethane-acetonitrile-water-hexamethyl disiloxane with dividing wall column by azeotropic distillation

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 18

相关文章 15

编辑推荐

Metrics

本文评价

[1]	杨欣, 王文, 徐凯, 马凡华. 高压氢气加注过程中温度特征仿真分析[J]. 化工学报, 2023, 74(S1): 280-286.
[2]	高润淼, 宋孟杰, 高恩元, 张龙, 张旋, 邵苛苛, 甄泽康, 江正勇. 冷链装备制冷剂相关温室气体减排研究进展[J]. 化工学报, 2023, 74(S1): 1-7.
[3]	吴延鹏, 刘乾隆, 田东民, 陈凤君. 相变材料与热管耦合的电子器件热管理研究进展[J]. 化工学报, 2023, 74(S1): 25-31.
[4]	何松, 刘乔迈, 谢广烁, 王斯民, 肖娟. 高浓度水煤浆管道气膜减阻两相流模拟及代理辅助优化[J]. 化工学报, 2023, 74(9): 3766-3774.
[5]	陈哲文, 魏俊杰, 张玉明. 超临界水煤气化耦合SOFC发电系统集成及其能量转化机制[J]. 化工学报, 2023, 74(9): 3888-3902.
[6]	齐聪, 丁子, 余杰, 汤茂清, 梁林. 基于选择吸收纳米薄膜的太阳能温差发电特性研究[J]. 化工学报, 2023, 74(9): 3921-3930.
[7]	邢雷, 苗春雨, 蒋明虎, 赵立新, 李新亚. 井下微型气液旋流分离器优化设计与性能分析[J]. 化工学报, 2023, 74(8): 3394-3406.
[8]	张曼铮, 肖猛, 闫沛伟, 苗政, 徐进良, 纪献兵. 危废焚烧处理耦合有机朗肯循环系统工质筛选与热力学优化[J]. 化工学报, 2023, 74(8): 3502-3512.
[9]	诸程瑛, 王振雷. 基于改进深度强化学习的乙烯裂解炉操作优化[J]. 化工学报, 2023, 74(8): 3429-3437.
[10]	陈国泽, 卫东, 郭倩, 向志平. 负载跟踪状态下的铝空气电池堆最优功率点优化方法[J]. 化工学报, 2023, 74(8): 3533-3542.
[11]	刘文竹, 云和明, 王宝雪, 胡明哲, 仲崇龙. 基于场协同和耗散的微通道拓扑优化研究[J]. 化工学报, 2023, 74(8): 3329-3341.
[12]	文兆伦, 李沛睿, 张忠林, 杜晓, 侯起旺, 刘叶刚, 郝晓刚, 官国清. 基于自热再生的隔壁塔深冷空分工艺设计及优化[J]. 化工学报, 2023, 74(7): 2988-2998.
[13]	吴文涛, 褚良永, 张玲洁, 谭伟民, 沈丽明, 暴宁钟. 腰果酚生物基自愈合微胶囊的高效制备工艺研究[J]. 化工学报, 2023, 74(7): 3103-3115.
[14]	汤晓玲, 王嘉瑞, 朱玄烨, 郑仁朝. 基于Pickering乳液的卤醇脱卤酶催化合成手性环氧氯丙烷[J]. 化工学报, 2023, 74(7): 2926-2934.
[15]	江锦波, 彭新, 许文烜, 门日秀, 刘畅, 彭旭东. 泵出型螺旋槽油气密封泄漏特性及参数影响研究[J]. 化工学报, 2023, 74(6): 2538-2554.