工业级水平管粉煤气力输送的最小压降速度和稳定性

doi:10.3969/j.issn.0438-1157.2013.06.010

化工学报 ›› 2013, Vol. 64 ›› Issue (6): 1969-1975.DOI: 10.3969/j.issn.0438-1157.2013.06.010

工业级水平管粉煤气力输送的最小压降速度和稳定性

谢锴, 郭晓镭, 丛星亮, 刘剀, 陶顺龙, 陆海峰, 龚欣

华东理工大学煤气化及能源化工教育部重点实验室,上海 200237

收稿日期:2012-09-18 修回日期:2013-01-09 出版日期:2013-06-05 发布日期:2013-06-05
通讯作者: 龚欣
作者简介:谢锴(1988—),男,硕士研究生。
基金资助:
国家重点基础研究发展计划项目(2010CB227002);上海市教育委员会和上海市教育发展基金会"晨光计划";国家自然科学基金项目(21206041)。

Minimum pressure drop velocity and stability analysis in pneumatic conveying of pulverized coal in commercial-scale horizontal pipe

XIE Kai, GUO Xiaolei, CONG Xingliang, LIU Kai, TAO Shunlong, LU Haifeng, GONG Xin

Key Laboratory of Coal Gasification and Energy Chemical Engineering of Ministry of Education, East China University of Science and Technology, Shanghai 200237, China

Received:2012-09-18 Revised:2013-01-09 Online:2013-06-05 Published:2013-06-05
Supported by:
supported by the National Basic Research Program of China(2010CB227002),the"Chen Guang" Project of Shanghai Municipal Education Commission and Shanghai Education Development Foundation and the National Natural Science Foundation of China(21206041).

摘要/Abstract

摘要： 采用压缩空气作为输送介质,在工业级水平管(内径50 mm)上开展了粉煤密相气力输送实验研究。在实验获得最小压降速度基础上,通过电容层析成像系统观察到,随着表观气速降低而存在分层流、沙丘流、移动床流以及栓塞流4种流型。不同流型压力信号的概率密度分布和功率谱密度分析表明,压力信号的波动特征与流型紧密联系;由于流动形态的变化,存在由稳定输送过渡到不稳定输送的临界气速,且该速度小于最小压降速度。

关键词: 密相气力输送, 最小压降速度, 流型, 稳定性

Abstract: Dense-phase pneumatic conveying of pulverized coal was investigated in an commercial-scale horizontal pipe (50 mm I.D.) by using compressed air as carrier gas.Minimum pressure drop velocity was obtained from the Zenz-type phase diagram, which was influenced by solids mass flux significantly.Based on electrical capacitance tomography (ECT) system, the flow in the experimental range was classified into four regimes:stratified flow, dune flow, moving bed flow and slug flow.Using probability density function (PDF) and power spectral density (PSD) function to analyze the pressure signals of typical cases, pressure fluctuations were well correlated with flow patterns.The relative stability characteristics of different operating conditions showed that the critical velocity between stable and unstable conveying was smaller than minimum pressure drop velocity due to the transitions of flow patterns.

Key words: dense-phase pneumatic conveying, minimum pressure drop velocity, flow pattern, stability

中图分类号:

TQ536

谢锴, 郭晓镭, 丛星亮, 刘剀, 陶顺龙, 陆海峰, 龚欣. 工业级水平管粉煤气力输送的最小压降速度和稳定性[J]. 化工学报, 2013, 64(6): 1969-1975.

XIE Kai, GUO Xiaolei, CONG Xingliang, LIU Kai, TAO Shunlong, LU Haifeng, GONG Xin. Minimum pressure drop velocity and stability analysis in pneumatic conveying of pulverized coal in commercial-scale horizontal pipe[J]. CIESC Journal, 2013, 64(6): 1969-1975.

参考文献 18

[1]	Zenz F.Two-phase fluid-solid flow[J].Industrial and Engineering Chemistry, 1949,41(12):2801-2806
[2]	Matsumoto S, Harada S, Saito S, Maeda S.Saltation velocity for horizontal pneumatic conveying[J].Journal of Chemical Engineering of Japan, 1975,8(4):331-333
[3]	Geldart D, Ling S J.Saltation velocity in high pressure conveying of fine coal[J].Powder Technology, 1992,69(2):157-162
[4]	Cabrejos F J, Klinzing G E.Pickup and saltation mechanisms of solid particles in horizontal pneumatic transport[J].Powder Technology, 1994,74(2):173-186
[5]	Herbreteau C, Bouard R.Experimental study of parameters which influence the energy minimum in horizontal gas-solid conveying[J].Powder Technology, 2000,112(3):213-220
[6]	Zheng Y, Rinoshika A, Yan F.Multi-scale analysis on particle fluctuation velocity near the minimum pressure drop in a horizontal pneumatic conveying[J].Chemical Engineering Science, 2012,72:94-107
[7]	Jama G A, Klinzing G E, Rizk F.An investigation of the prevailing flow patterns and pressure fluctuation near the pressure minimum and unstable conveying zone of pneumatic transport systems[J].Powder Technology, 2000,112(1/2):87-93
[8]	Xiao Weiguo(肖为国), Guo Xiaolei(郭晓镭), Dai Zhenghua(代正华), Gong Xin(龚欣), Guo Yunzhou(郭云舟), Zheng Lijiao(郑利娇).Dense phase flow properties of pulverized coal in industrial scale tube[J].Journal of Chemical Industry and Engineering(China)(化工学报), 2007,58(11):2759-2763
[9]	Rabinnovich E, Kalman H.Boundary saltation and minimum pressure velocities in particle-gas systems[J].Powder Technology, 2008,185:67-69
[10]	Zhou Yun(周云), Chen Xiaoping(陈晓平), Liang Cai(梁财), Meng Qingmin(孟庆敏), Lu Peng(鹿鹏), Pu Wenhao(蒲文灏), Xu Pan(许盼).Effect of mean particle size of pulverized coal on dense phase pneumatic conveying at high pressure[J].Proceedings of the CSEE(中国电机工程学报), 2009,29(26):25-29
[11]	Hong J, Shen Y, Tomita Y.Phase diagram in dense phase pneumatic transport[J].Powder Technology, 1995,84(3):213-219
[12]	Xia Kunpeng(夏鲲鹏), Chen Hanping(陈汉平), Wang Xianhua(王贤华), Zhang Shihong(张世红), Gao Bin(高斌), Liu Dechang(刘德昌).Entrained-bed coal gasification technology and its development tendency[J].Coal Conversation(煤炭转化), 2005,28(4):69-73
[13]	Dai Zhenghua, Gong Xin, Guo Xiaolei, Liu Haifeng, Wang Fuchen, Yu Zunhong.Pilot-trial and modeling of a new type of pressurized entrained-flow pulverized coal gasification technology[J].Fuel, 2008,87(10/11):2304-2313
[14]	Pan R.Material properties and flow modes in pneumatic conveying[J].Powder Technology, 1999,104(2):157-163
[15]	Ma Sheng(马胜), Guo Xiaolei(郭晓镭), Gong Xin(龚欣), Huang Wanjie(黄万杰), Lu Haifeng(陆海峰), Liu Kai(刘剀).Flow regime of pulverized coal in dense-phase pneumatic conveying system[J].CIESC Journal(化工学报), 2010,61(6):1415-1421
[16]	Chen Zhenyu(陈振瑜), Zhao Qingjun(赵庆军), He Limin(何利民).Statistical investigation on transient characteristics of gas flowrate increasing under slug flow in horizontal pipeline[J].Journal of Chemical Industry and Engineering(China)(化工学报), 2004,55(8):1274-1279
[17]	Cong Xingliang, Guo Xiaolei, Gong Xin, Lu Haifeng, Dong Weibing.Experimental research of flow patterns and pressure signals in horizontal dense phase pneumatic conveying of pulverized coal[J].Powder Technology, 2011,208(3):600-609
[18]	Tomita Y, Asou H.Low-velocity pneumatic conveying of coarse particles in a horizontal pipe[J].Powder Technology, 2009,196(1):14-21

工业级水平管粉煤气力输送的最小压降速度和稳定性

Minimum pressure drop velocity and stability analysis in pneumatic conveying of pulverized coal in commercial-scale horizontal pipe

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 18

相关文章 15

编辑推荐

Metrics

本文评价

[1]	周绍华, 詹飞龙, 丁国良, 张浩, 邵艳坡, 刘艳涛, 郜哲明. 短管节流阀内流动噪声的实验研究及降噪措施[J]. 化工学报, 2023, 74(S1): 113-121.
[2]	江河, 袁俊飞, 王林, 邢谷雨. 均流腔结构对微细通道内相变流动特性影响的实验研究[J]. 化工学报, 2023, 74(S1): 235-244.
[3]	孟令玎, 崇汝青, 孙菲雪, 孟子晖, 刘文芳. 改性聚乙烯膜和氧化硅固定化碳酸酐酶[J]. 化工学报, 2023, 74(8): 3472-3484.
[4]	郑玉圆, 葛志伟, 韩翔宇, 王亮, 陈海生. 中高温钙基材料热化学储热的研究进展与展望[J]. 化工学报, 2023, 74(8): 3171-3192.
[5]	郭雨莹, 敬加强, 黄婉妮, 张平, 孙杰, 朱宇, 冯君炫, 陆洪江. 稠油管道水润滑减阻及压降预测模型修正[J]. 化工学报, 2023, 74(7): 2898-2907.
[6]	毛磊, 刘冠章, 袁航, 张光亚. 可捕集CO₂的纳米碳酸酐酶粒子的高效制备及性能研究[J]. 化工学报, 2023, 74(6): 2589-2598.
[7]	蔡斌, 张效林, 罗倩, 党江涛, 左栗源, 刘欣梅. 导电薄膜材料的研究进展[J]. 化工学报, 2023, 74(6): 2308-2321.
[8]	徐文超, 孙志高, 李翠敏, 李娟, 黄海峰. 静态条件下表面活性剂E-1310对HCFC-141b水合物生成的影响[J]. 化工学报, 2023, 74(5): 2179-2185.
[9]	王子健, 柯明, 李佳涵, 李舒婷, 孙巾茹, 童燕兵, 赵治平, 刘加英, 任璐. 短b轴ZSM-5分子筛制备方法及应用研究进展[J]. 化工学报, 2023, 74(4): 1457-1473.
[10]	陈向上, 马振杰, 任希华, 贾悦, 吕晓龙, 陈华艳. 三维网络萃取膜的制备及传质效率研究[J]. 化工学报, 2023, 74(3): 1126-1133.
[11]	刘润竹, 储甜甜, 张孝阿, 王成忠, 张军营. α，ω-端羟基亚苯基氟硅聚合物的合成及性能[J]. 化工学报, 2023, 74(3): 1360-1369.
[12]	杨宏欣, 李兴亚, 葛亮, 徐铜文. 含哌啶阳离子侧长链型一/二价阴离子选择性分离膜的制备[J]. 化工学报, 2022, 73(8): 3739-3748.
[13]	张建伟, 高伟峰, 董鑫, 冯颖. 浸没式撞击流反应器流场涡特性的数值研究[J]. 化工学报, 2022, 73(8): 3553-3564.
[14]	朱江伟, 马鹏飞, 杜晓, 杨言言, 郝晓刚, 罗善霞. 基于可变价NiFe-LDH/rGO对磷酸根离子的特异性电控分离[J]. 化工学报, 2022, 73(7): 3057-3067.
[15]	宋健斐, 孙立强, 解明, 魏耀东. 旋风分离器内气相旋转流不稳定性的实验研究[J]. 化工学报, 2022, 73(7): 2858-2864.