低Reynolds数空气来流正庚烷液滴蒸发过程熵产特性

doi:10.3969/j.issn.0438-1157.2014.06.004

化工学报 ›› 2014, Vol. 65 ›› Issue (6): 1971-1977.DOI: 10.3969/j.issn.0438-1157.2014.06.004

低Reynolds数空气来流正庚烷液滴蒸发过程熵产特性

郭洋裕¹, 张昊春¹, 于海燕¹, Jin Yan², 李垚³

1. 哈尔滨工业大学能源科学与工程学院, 黑龙江哈尔滨 150001;
2. Institute of Thermo-Fluid Dynamics, Hamburg University of Technology, Hamburg 21073, Germany;
3. 哈尔滨工业大学复合材料研究所, 黑龙江哈尔滨 150001

收稿日期:2013-04-28 修回日期:2014-03-11 出版日期:2014-06-05 发布日期:2014-06-05
通讯作者: 张昊春
作者简介:郭洋裕（1992- ），男，硕士研究生
基金资助:
国家自然科学基金项目（51006026，91216123）；中央高校基本科研业务费专项资金（HIT.NSRIF.2012.072）。

Entropy production characteristics through n-heptane evaporation in low Reynolds number incoming air flow

GUO Yangyu¹, ZHANG Haochun¹, YU Haiyan¹, JIN Yan², LI Yao³

1. School of Energy Science and Technology, Harbin Institute of Technology, Harbin 150001, Heilongjiang, China;
2. Institute of Thermo-Fluid Dynamics, Hamburg University of Technology, Hamburg 21073, Germany;
3. Institute of Composites, Harbin Institute of Technology, Harbin 150001, Heilongjiang, China

Received:2013-04-28 Revised:2014-03-11 Online:2014-06-05 Published:2014-06-05
Supported by:
supported by the National Natural Science Foundation of China (51006026, 91216123) and the Fundamental Research Funds for the Central Universities (HIT. NSRIF. 2012.072).

摘要/Abstract

摘要： 车用内燃机、航空发动机燃料的主要成分为正庚烷液体。液体燃烧属于扩散型燃烧，燃料先雾化成油雾，然后蒸发，燃油蒸气在气态扩散火焰中燃烧。油雾蒸发是液体燃烧中的重要过程，是决定液体燃烧的燃烧速率的关键步骤。建立了一个二维准稳态的液滴蒸发数值模型，分析了液滴蒸发的熵产，推导出了三维笛卡尔坐标系下的传质熵产公式。基于Fluent软件进行了数值模拟，结果显示低Reynolds数空气来流中的液滴蒸发过程的熵产主要由导热熵产组成，且液滴蒸发越容易，相对总熵产越小，从热力学角度来看其液滴蒸发过程更优。

关键词: 雾化燃烧, 液滴蒸发, 传质, 热力学, 数值模拟, 熵产

Abstract: The main component of vehicle internal combustion engine and aircraft engine fuel is n-heptane. Combustion of liquid fuel belongs to diffusive combustion. The combustion process is composed of atomization, evaporation and diffusive combustion, and the evaporation process is vitally important, which critically determines the combustion speed of fuel droplet. Hence it is essential to optimize this process. In this paper, the evaporation of n-heptane droplet was evaluated from the perspective of second law of thermodynamics. A two-dimensional quasi-steady state model of the evaporation process was proposed, and the entropy production of the process was solved by integration of the volumetric entropy production rate in the whole domain. The viscous, conductive, mass transfer entropy production was investigated and compared, with the help of viscous and conductive entropy production rate equations reported in literatures and mass transfer entropy production rate equation derived in this paper, after numerical simulation of the evaporation process with Fluent software. Also, the relative total entropy production was defined. Conductive entropy production was the main part of the total entropy production of n-heptane evaporation in the low-Re air flow. With increasing Re and temperature of airflow, relative total entropy production decreased. In other words, the evaporation process produced less entropy relatively and it became easier, which from a thermodynamics perspective was optimal.

Key words: atomization combustion, droplet evaporation, mass transfer, thermodynamics, numerical simulation, entropy production

中图分类号:

TK124

郭洋裕, 张昊春, 于海燕, Jin Yan, 李垚. 低Reynolds数空气来流正庚烷液滴蒸发过程熵产特性[J]. 化工学报, 2014, 65(6): 1971-1977.

GUO Yangyu, ZHANG Haochun, YU Haiyan, JIN Yan, LI Yao. Entropy production characteristics through n-heptane evaporation in low Reynolds number incoming air flow[J]. CIESC Journal, 2014, 65(6): 1971-1977.

参考文献 26

[1]	Jin Y, Shaw B D. Computational modeling of n-heptane droplet combustion in air-diluent environments under reduced-gravity [J]. International Journal of Heat and Mass Transfer,2010, 53 (25/26): 5782-5791
[2]	Toshikazu K, Hiroyuki H. Evaporation of a single droplet at elevated pressures and temperatures [J]. Bulletin of the JSME, 1976, 19 (138): 1515-1521
[3]	Wu J S, Liu Y J, Sheen H J. Effects of ambient turbulence and fuel properties on the evaporation rate of single droplets [J]. International Journal of Heat and Mass Transfer, 2001, 44 (24): 4593-4603
[4]	Wu J S, Hsu K H, Kuo P M, Sheen H J. Evaporation model of a single hydrocarbon fuel droplet due to ambient turbulence at intermediate Reynolds numbers [J]. International Journal of Heat and Mass Transfer, 2003, 46 (24): 4741-4745
[5]	Yang J R, Wong S C. On the discrepancies between theoretical and experimental results for microgravity droplet evaporation [J]. International Journal of Heat and Mass Transfer, 2001, 44 (23): 4433-4443
[6]	Zhang H. Numerical research on a vaporizing fuel droplet in a forced convective environment [J]. International Journal of Multiphase Flow, 2004, 30 (2): 181-198
[7]	Birouk M, Gokalp I. Current status of droplet evaporation in turbulent flows [J]. Progress in Energy and Combustion Science, 2006, 32 (4): 408-423
[8]	Birouk M, Maher M A A, Gökalp I. Droplet evaporation in a turbulent environment at elevated pressure and temperature conditions [J]. Combust. Sci. Tech., 2008, 180: 1987-2014
[9]	Maher M A A, Birouk M. A numerical model for calculating the vaporization rate of a fuel droplet exposed to a convective turbulent airflow [J]. International Journal of Numerical Methods for Heat & Fliud Flow, 2008, 18 (2): 146-159
[10]	Maher M A A, Birouk M. Droplet heat and mass transfer in a turbulent hot airstream [J]. International Journal of Heat and Mass Transfer, 2008, 51 (5/6): 1313-1324
[11]	Schlottke J, Weigand B. Direct numerical simulation of evaporating droplets [J]. Journal of Computational Physics, 2008, 227 (10): 5215-5237
[12]	Kirkwood J G, Crawford B. The macroscopic equations of transport [J]. J. Phys. Chem., 1952, 56 (9): 1048-1051
[13]	Dash S K, Sengupta S P, Som S K. Transport processes and associated irreversibilities in droplet evaporation [J]. Journal of Thermophysics and Heat Transfer, 1991, 5 (3): 366-373
[14]	Som S K, Dash S K. Thermodynamics of spray evaporation [J]. Journal of Physics D: Applied Physics, 1993, 26 (4): 574-584
[15]	Hiwase S D, Datta A, Som S K. Entropy balance and exergy analysis of the process of droplet combustion [J]. Journal of Physics D: Applied Physics, 1998, 31 (13): 1601-1610
[16]	Yapici H, Kayatas N, Albayrak B, Basturk G. Numerical calculation of local entropy generation in a methane-air burner [J]. Energy Conversion and Management, 2005, 46 (11/12): 1885-1919
[17]	Herwig H, Wenterodt T. Second law analysis of momentum and heat transfer in unit operations [J]. International Journal of Heat and Mass Transfer, 2011, 54 (7/8): 1323-1330
[18]	Sood M M A, Birouk M. A numerical study of the effect of turbulence on mass transfer from a single fuel droplet evaporating in a hot convective flow [J]. International Journal of Thermal Sciences, 2007, 46 (8): 779-789
[19]	Chu Shuangxia (楚双霞), Liu Linhua (刘林华). Analysis of entropy generation during methane-air diffusion combustion processes [J]. Proceedings of the CSEE (中国电机工程学报), 2008, 28 (29): 34-40
[20]	Chu Shuangxia (楚双霞). Thermodynamic analysis of incoherent radiative transfer process [D]. Harbin: Harbin Institute of Technology, 2009
[21]	Gao Xiang (高翔), Luo Zhongyang (骆仲泱), Zhou Jinsong (周劲松), Ni Mingjiang (倪明江), Cen Kefa (岑可法). Application of unit entropy generation analysis method to enhanced heat transfer [J]. Journal of Chemical Industry and Engineering (China) (化工学报), 1998, 49 (5): 639-643
[22]	Xie Gongnan (谢公南), Wang Qiuwang (王秋旺), Luo Laiqin (罗来勤). Entropy generation analysis and performance evaluation of heat transfer enhancement through internal flow [J]. Journal of Chemical Industry and Engineering (China)(化工学报), 2006, 57 (2): 241-245
[23]	Chen Xi (陈曦), Wang Jianjun (汪建军), Zhu Jiahua (朱家骅), et al. Analysis of entropy generation in falling film evaporation [J]. Journal of Chemical Industry and Engineering (China) (化工学报), 2006, 57 (7): 1518-1524
[24]	Zhang Fengzhen (张峰榛), Wei Wenyun (魏文韫), Yu Hui (余徽), Xia Sulan (夏素兰), Zhu Jiahua (朱家骅). Modeling and simulation of vacuum evaporation from surface of a continuous falling liquid column [J]. CIESC Journal (化工学报), 2011, 62 (12): 3329-3323
[25]	Zhang Xiaobin, Zhang Wei, Zhang Xuejun. Entropy analyses of droplet combustion in convective environment with small Reynolds number [J]. Chinese Journal of Chemical Engineering, 2013, 21 (6): 654-662
[26]	Zhang Lina (张丽娜), Yang Chunxin (杨春信). Heat transfer and thermodynamic analysis of internal flow based on distributed parameter model [J]. Journal of Chemical Industry and Engineering (China)(化工学报), 2008, 59 (12): 0438-1157

低Reynolds数空气来流正庚烷液滴蒸发过程熵产特性

Entropy production characteristics through n-heptane evaporation in low Reynolds number incoming air flow

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 26

相关文章 15

编辑推荐

Metrics

本文评价

[1]	叶展羽, 山訸, 徐震原. 用于太阳能蒸发的折纸式蒸发器性能仿真[J]. 化工学报, 2023, 74(S1): 132-140.
[2]	张义飞, 刘舫辰, 张双星, 杜文静. 超临界二氧化碳用印刷电路板式换热器性能分析[J]. 化工学报, 2023, 74(S1): 183-190.
[3]	王志国, 薛孟, 董芋双, 张田震, 秦晓凯, 韩强. 基于裂隙粗糙性表征方法的地热岩体热流耦合数值模拟与分析[J]. 化工学报, 2023, 74(S1): 223-234.
[4]	杨欣, 王文, 徐凯, 马凡华. 高压氢气加注过程中温度特征仿真分析[J]. 化工学报, 2023, 74(S1): 280-286.
[5]	宋嘉豪, 王文. 斯特林发动机与高温热管耦合运行特性研究[J]. 化工学报, 2023, 74(S1): 287-294.
[6]	张思雨, 殷勇高, 贾鹏琦, 叶威. 双U型地埋管群跨季节蓄热特性研究[J]. 化工学报, 2023, 74(S1): 295-301.
[7]	晁京伟, 许嘉兴, 李廷贤. 基于无管束蒸发换热强化策略的吸附热池的供热性能研究[J]. 化工学报, 2023, 74(S1): 302-310.
[8]	常明慧, 王林, 苑佳佳, 曹艺飞. 盐溶液蓄能型热泵循环特性研究[J]. 化工学报, 2023, 74(S1): 329-337.
[9]	张化福, 童莉葛, 张振涛, 杨俊玲, 王立, 张俊浩. 机械蒸汽压缩蒸发技术研究现状与发展趋势[J]. 化工学报, 2023, 74(S1): 8-24.
[10]	李艺彤, 郭航, 陈浩, 叶芳. 催化剂非均匀分布的质子交换膜燃料电池操作条件研究[J]. 化工学报, 2023, 74(9): 3831-3840.
[11]	何松, 刘乔迈, 谢广烁, 王斯民, 肖娟. 高浓度水煤浆管道气膜减阻两相流模拟及代理辅助优化[J]. 化工学报, 2023, 74(9): 3766-3774.
[12]	胡建波, 刘洪超, 胡齐, 黄美英, 宋先雨, 赵双良. 有机笼跨细胞膜易位行为的分子动力学模拟研究[J]. 化工学报, 2023, 74(9): 3756-3765.
[13]	韩晨, 司徒友珉, 朱斌, 许建良, 郭晓镭, 刘海峰. 协同处理废液的多喷嘴粉煤气化炉内反应流动研究[J]. 化工学报, 2023, 74(8): 3266-3278.
[14]	张曼铮, 肖猛, 闫沛伟, 苗政, 徐进良, 纪献兵. 危废焚烧处理耦合有机朗肯循环系统工质筛选与热力学优化[J]. 化工学报, 2023, 74(8): 3502-3512.
[15]	邢雷, 苗春雨, 蒋明虎, 赵立新, 李新亚. 井下微型气液旋流分离器优化设计与性能分析[J]. 化工学报, 2023, 74(8): 3394-3406.