T型圆柱形微通道内CO2碱液吸收数值模拟

doi:10.11949/0438-1157.20240380

摘要/Abstract

摘要：

采用水平集两相流耦合组分传质微分方程对三维T型微通道内的CO₂碱液吸收过程进行了数值模拟。分析了气泡形成及流动过程、相间传递及吸收特性，并重点探讨了进口气速、液速和碱液浓度对CO₂化学吸收传质的影响。结果表明，在气速0.08 m/s、液速0.03 m/s时，单个气泡形成时间约为0.012 s，气泡移动速率几乎等于进口气速，展现气泡和液塞交替的泰勒流特征。CO₂吸收溶解速率在气泡形成初始阶段溶解速率最大，随着气液相相互接触传质推动力逐渐降低，沿出口方向的气液两相界面上逐渐下降。气速0.05 m/s增加到0.1 m/s时，CO₂吸收率从62.6%降低到34.8%，当液速从0.01 m/s增加到0.05 m/s时，CO₂吸收率从18.5%提高48.4%。吸收剂浓度从50 mol/m³增加到250 mol/m³，吸收率由50.8%提高到79.3%。

关键词: 微通道, 吸收, 传质, 二氧化碳捕集, 数值模拟

Abstract:

The Level-set two-phase flow coupled component mass transfer equations were used to simulate the CO₂ absorption by alkali liquor in three-dimensional T-junction cylindrical microchannels. The bubble formation and flow process, the characteristics of interphase transfer and absorption were analyzed, and the effects of inlet gas velocity, liquid velocity and alkali concentration on the CO₂ chemical absorption and mass transfer were mainly discussed. The results show that, for gas velocity of 0.08 m/s and the liquid velocity of 0.03 m/s, the formation time of a single bubble is about 0.012 s, and the bubble moving speed is almost equal to the inlet gas velocity, showing the alternating Taylor flow characteristics of bubbles and liquid plugs. The CO₂ absorption rate reaches its maximum at the initial stage of bubble formation, and gradually decreases along the outlet direction along with the decrease of mass transfer force at gas-liquid interface. When the gas velocity increased from 0.05 m/s to 0.1 m/s, the CO₂ absorptivity decreased from 62.6% to 34.8%. Conversely, when the liquid velocity increased from 0.01 m/s to 0.05 m/s, the CO₂ absorptivity increased from 18.5% to 48.4%. Furthermore, increasing the absorbent concentration from 50 mol/m³ to 250 mol/m³ raises the absorptivity from 50.8% to 79.3%.

Key words: microchannel, absorption, mass transfer, CO₂ capture, numerical simulation

中图分类号:

TQ 021.1

杨勇, 祖子轩, 李煜坤, 王东亮, 范宗良, 周怀荣. T型圆柱形微通道内CO₂碱液吸收数值模拟[J]. 化工学报, 2024, 75(S1): 135-142.

Yong YANG, Zixuan ZU, Yukun LI, Dongliang WANG, Zongliang FAN, Huairong ZHOU. Numerical simulation of CO₂ absorption by alkali liquor in T-junction cylindrical microchannels[J]. CIESC Journal, 2024, 75(S1): 135-142.

图/表 10

图1 T型微通道及网格分布

Fig.1 Geometry and mesh distribution for T-shaped microchannel

图2 微通道内气速0.08 m/s、液速0.03 m/s时的气泡形成和流速流线分布

Fig.2 Bubble formation, velocity profile and stream line in microchannel at Ug=0.08 m/s and Ul =0.03 m/s

图3 微通道内气速0.08 m/s、液速0.03 m/s时CO2吸收速率和气相CO2浓度分布的演变

Fig.3 Evolution of CO2 absorption rate and gas CO2 concentration in microchannel at Ug=0.08 m/s and Ul =0.03 m/s

图4 不同气速下气相体积分数分布

Fig.4 Gas volume fraction at different gas inlet velocities

图5 不同气速下气相CO2浓度分布

Fig.5 Gas CO2 concentration at different gas inlet velocities

图6 气速对CO2吸收率和出口浓度的影响

Fig.6 Effect of gas velocity on CO2 absorptivity and outlet concentration

图7 不同液速下气相体积分数

Fig.7 Vapor phase volume fraction at different liquid velocities

图8 不同液速下CO2吸收效果

Fig.8 CO2 absorption effect at different liquid speeds

图9 液速对CO2吸收率和出口浓度的影响

Fig.9 Effect of liquid velocity on CO2 absorption rate and outlet concentration

图10 浓度对CO2吸收率和出口浓度的影响

Fig.10 Effect of concentration on CO2 absorption rate and outlet concentration

参考文献 31

1	李函珂, 党成雄, 杨光星, 等. 面向二氧化碳捕集的过程强化技术进展[J]. 化工进展, 2020, 39(12): 4919-4939.
	Li H K, Dang C X, Yang G X, et al. Process intensification techniques towards carbon dioxide capture: a review[J]. Chemical Industry and Engineering Progress, 2020, 39(12): 4919-4939.
2	Zhang Q, Liu J F, Wang G, et al. A new optimization model for carbon capture utilization and storage (CCUS) layout based on high-resolution geological variability[J]. Applied Energy, 2024, 363: 123065.
3	Jin B, Wang R Y, Fu D T, et al. Chemical looping CO₂ capture and in situ conversion as a promising platform for green and low-carbon industry transition: review and perspective[J]. Carbon Capture Science & Technology, 2024, 10: 100169.
4	Yusuf N, Almomani F, Qiblawey H. Catalytic CO₂ conversion to C1 value-added products: review on latest catalytic and process developments[J]. Fuel, 2023, 345: 128178.
5	Zanfir M, Gavriilidis A, Wille C, et al. Carbon dioxide absorption in a falling film microstructured reactor: experiments and modeling[J]. Industrial & Engineering Chemistry Research, 2005, 44(6): 1742-1751.
6	范晓丹. 鼓泡反应器中氢氧化钠吸收二氧化碳的数值模拟[D]. 沈阳: 东北大学, 2014.
	Fan X D. Numerical simulation of sodium hydroxide absorbing carbon dioxide gas in bubble column[D]. Shenyang: Northeastern University, 2014.
7	Zhou C Q, Ni J H, Chen H Q, et al. Harnessing electrochemical pH gradient for direct air capture with hydrogen and oxygen by-products in a calcium-based loop[J]. Sustainable Energy & Fuels, 2021, 5(17): 4355-4367.
8	Hu G P, Nicholas N J, Smith K H, et al. Carbon dioxide absorption into promoted potassium carbonate solutions: a review[J]. International Journal of Greenhouse Gas Control, 2016, 53: 28-40.
9	庞子凡, 蒋斌, 朱春英, 等. 微通道内CO₂吸收与传质及资源化利用的研究进展[J]. 化工学报, 2022, 73(1): 122-133.
	Pang Z F, Jiang B, Zhu C Y, et al. Progress of absorption, mass transfer and resource utilization of CO₂ in microchannels[J]. CIESC Journal, 2022, 73(1): 122-133.
10	Zhang Y, Zhu C, Fu T, et al. CO₂ absorption and desorption performance by ChCl-MEA-PZ deep eutectic solvent aqueous solutions[J]. Separation and Purification Technology, 2024, 330: 1252-1275.
11	Makarem M A, Kiani M R, Farsi M, et al. CFD simulation of CO₂ capture in a microchannel by aqueous mixtures of MEA and[Bmim][BF4] modified with TiO₂ nanoparticles[J]. International Journal of Thermophysics, 2021, 42(4): 57.
12	Lin X Y, Yan S, Zhou B Y, et al. Highly efficient synthesis of polyvinyl butyral (PVB) using a membrane dispersion microreactor system and recycling reaction technology[J]. Green Chemistry, 2017, 19(9): 2155-2163.
13	袁谅, 从海峰, 李鑫钢. 微通道内气液流动与传质特性的研究进展[J]. 化工进展, 2024, 43(1): 34-48.
	Yuan L, Cong H F, Li X G. Research progress on gas-liquid flow and mass transfer characteristics in microchannels[J]. Chemical Industry and Engineering Progress, 2024, 43(1): 34-48.
14	钱锦远, 李晓娟, 吴赞, 等. 微通道内液-液两相流流型及传质的研究进展[J]. 化工进展, 2019, 38(4): 1624-1633.
	Qian J Y, Li X J, Wu Z, et al. Research progress on flow regimes and mass transfer of liquid-liquid two-phase flow in microchannels[J]. Chemical Industry and Engineering Progress, 2019, 38(4): 1624-1633.
15	陈彦松, 阮达, 刘渊博, 等. 微通道换热器拓扑结构优化与性能研究[J]. 化工学报, 2024, 75(3): 823-835.
	Chen Y S, Ruan D, Liu Y B, et al. Topology optimization and performance research of microchannel heat exchangers[J]. CIESC Journal, 2024, 75(3): 823-835.
16	王俊男, 何呈祥, 王忠东, 等. T型微混合器内均相混合的数值模拟[J]. 化工学报, 2024, 75(1): 242-254.
	Wang J N, He C X, Wang Z D, et al. Numerical simulation of homogeneous mixing in T-junction micromixers[J]. CIESC Journal, 2024, 75(1): 242-254.
17	马学虎, 梁倩卿, 王凯, 等. 基于微吸收器的CO₂吸收过程研究进展[J]. 化工进展, 2018, 37(4): 1229-1246.
	Ma X H, Liang Q Q, Wang K, et al. Progress of CO₂ absorption process in micro-absorbers[J]. Chemical Industry and Engineering Progress, 2018, 37(4): 1229-1246.
18	张璠玢, 朱春英, 付涛涛, 等. 微通道内离子液体/乙醇混合溶液吸收CO₂的传质特性[J]. 化工学报, 2017, 68(2): 601-611.
	Zhang Fanfen Zhu C Y, Fu T T, et al. Mass transfer performance of CO₂ absorption into ionic liquid/ethanol mixture in microchannel[J]. CIESC Journal, 2017, 68(2): 601-611.
19	Jasour A, Alizadeh R, Ahmadian H. Modeling of carbon dioxide and hydrogen sulfide pollutants absorption in wetted-wire columns with alkanolamines[J]. Chemical Product and Process Modeling, 2023, 18(4): 591-609.
20	Dong R, Chu D, Sun Q, et al. Numerical simulation of the mass transfer process of CO₂ absorption by different solutions in a microchannel[J]. The Canadian Journal of Chemical Engineering, 2020, 98(12): 2648-2664.
21	Makarem M A, Farsi M, Rahimpour M R. CFD simulation of CO₂ removal from hydrogen rich stream in a microchannel[J]. International Journal of Hydrogen Energy, 2021, 46(37): 19749-19757.
22	Makarem M A, Kiani M R, Abbaspour M, et al. Nanoparticle-enhanced hydrogen separation from CO₂ in cylindrical and cubic microchannels: a 3D computational fluid dynamics simulation[J]. International Journal of Hydrogen Energy, 2023, 48(32): 12045-12055.
23	Jiang B, He C, Zhan W, et al. Mass transfer of chemical absorption of CO₂/N₂ mixed gas in a microchannel[J]. Chemical Engineering Science, 2023, 280: 1189-1196.
24	Göppert U, Maurer G. Vapor-liquid equilibria in aqueous solutions of ammonia and carbon dioxide at temperatures between 333 and 393 K and pressures up to 7 MPa[J]. Fluid Phase Equilibria, 1988, 41(1/2): 153-185.
25	Tsonopoulos C, Coulson D M, Inman L B. Ionization constants of water pollutants[J]. Journal of Chemical & Engineering Data, 1976, 21(2): 190-193.
26	Hikita H, Asai S, Ishikawa H, et al. Diffusivities of carbon dioxide in aqueous mixed electrolyte solutions[J]. The Chemical Engineering Journal, 1979, 17(1): 77-80.
27	Versteeg G F, Van Swaaij W P M. Solubility and diffusivity of acid gases (carbon dioxide, nitrous oxide) in aqueous alkanolamine solutions[J]. Journal of Chemical & Engineering Data, 1988, 33(1): 29-34.
28	宋存义, 周向. 捕集低浓度二氧化碳的化学吸收工艺及其综合比较[J]. 环境工程学报, 2012, 6(1): 1-8.
	Song C Y, Zhou X. Chemical absorption processes for low concentration CO₂ and comprehensive comparison[J]. Chinese Journal of Environmental Engineering, 2012, 6(1): 1-8.
29	Sun W C, Liu Y C, He K, et al. The phase distribution of gas-liquid two-phase flow in microimpacting T-junctions with different branch channel diameters[J]. Chemical Engineering Journal, 2018, 333: 34-42.
30	Haase S, Murzin D Y, Salmi T. Review on hydrodynamics and mass transfer in minichannel wall reactors with gas-liquid Taylor flow[J]. Chemical Engineering Research and Design, 2016, 113: 304-329..
31	Yin Y R, Fu T T, Zhu C Y, et al. Dynamics and mass transfer characteristics of CO₂ absorption into MEA/[Bmim][BF4]aqueous solutions in a microchannel[J]. Separation and Purification Technology, 2019, 210: 541-552.

[1]	董新宇, 边龙飞, 杨怡怡, 张宇轩, 刘璐, 王腾. 冷却条件下倾斜上升管S-CO₂流动与传热特性研究[J]. 化工学报, 2024, 75(S1): 195-205.
[2]	郭骐瑞, 任丽媛, 陈康, 黄翔宇, 马卫华, 肖乐勤, 周伟良. 用于HTPB推进剂浆料的静态混合管数值模拟[J]. 化工学报, 2024, 75(S1): 206-216.
[3]	李匡奚, 于佩潜, 王江云, 魏浩然, 郑志刚, 冯留海. 微气泡旋流气浮装置内流动分析与结构优化[J]. 化工学报, 2024, 75(S1): 223-234.
[4]	赵昂然, 韩永强, 王志鹏, 李鹏飞, 许亚伟, 佟会玲. 常温条件下赤泥同时脱硫脱硝实验研究[J]. 化工学报, 2024, 75(S1): 276-282.
[5]	汪张洲, 唐天琪, 夏嘉俊, 何玉荣. 基于复合相变材料的电池热管理性能模拟[J]. 化工学报, 2024, 75(S1): 329-338.
[6]	李雨霜, 王兴成, 温伯尧, 骆政园, 白博峰. 多孔介质中乳状液驱油的两相流动过程及其影响因素[J]. 化工学报, 2024, 75(S1): 56-66.
[7]	刘律, 刘洁茹, 范亮亮, 赵亮. 基于层流效应的被动式颗粒分离微流控方法研究[J]. 化工学报, 2024, 75(S1): 67-75.
[8]	胡俭, 姜静华, 范生军, 刘建浩, 邹海江, 蔡皖龙, 王沣浩. 中深层U型地埋管换热器取热特性研究[J]. 化工学报, 2024, 75(S1): 76-84.
[9]	周文博, 殷姜维, 张丹, 杨越, 于佳豪, 赵冰超. 热辐射加热下NaCl水溶液液滴蒸发过程的实验研究[J]. 化工学报, 2024, 75(S1): 85-94.
[10]	任冠宇, 张义飞, 李新泽, 杜文静. 翼型印刷电路板式换热器流动传热特性数值研究[J]. 化工学报, 2024, 75(S1): 108-117.
[11]	李焱, 郑利军, 张恩勇, 王云飞. 深水海底管道软管内部流体渗透特性模型与试验研究[J]. 化工学报, 2024, 75(S1): 118-125.
[12]	黄俊豪, 庞克亮, 孙方远, 刘福军, 谷致远, 韩龙, 段衍泉, 冯妍卉. 干熄炉料钟结构对焦炭布料粒径均匀度影响的模拟研究[J]. 化工学报, 2024, 75(S1): 158-169.
[13]	王冉, 王焕, 熊晓云, 关慧敏, 郑云锋, 陈彩琳, 秦玉才, 宋丽娟. FCC催化剂传质强化活性位利用效率的可视化分析[J]. 化工学报, 2024, 75(9): 3198-3209.
[14]	罗欣怡, 徐强, 佘永璐, 聂腾飞, 郭烈锦. 光电分解水制氢气泡动力学特性及其传质机理研究[J]. 化工学报, 2024, 75(9): 3083-3093.
[15]	陈巨辉, 苏潼, 李丹, 陈立伟, 吕文生, 孟凡奇. 翅形扰流片作用下的微通道换热特性[J]. 化工学报, 2024, 75(9): 3122-3132.

T型圆柱形微通道内CO₂碱液吸收数值模拟

Numerical simulation of CO₂ absorption by alkali liquor in T-junction cylindrical microchannels

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

图/表 10

参考文献 31

相关文章 15

编辑推荐

Metrics

本文评价