酸性助水溶剂脱除木质素机理分析

doi:10.11949/0438-1157.20211779

化工学报 ›› 2022, Vol. 73 ›› Issue (5): 2206-2221.DOI: 10.11949/0438-1157.20211779

酸性助水溶剂脱除木质素机理分析

王敏¹(),程金兰¹(),李鑫^1,²,陆晶晶¹,尹崇鑫^1,³,戴红旗¹

^1.南京林业大学江苏省制浆造纸科学与技术重点实验室，南京林业大学江苏省林业资源高效加工利用协同创新中心，江苏南京 210037
^2.东北林业大学，黑龙江哈尔滨 150040
^3.山东世纪阳光纸业集团有限公司，山东潍坊 262400

收稿日期:2021-12-17 修回日期:2022-04-01 出版日期:2022-05-05 发布日期:2022-05-24
通讯作者: 程金兰
作者简介:王敏（1996—），女，硕士研究生，miminwang@126.com
基金资助:
十三五国家重点研发计划项目(2019YFC1905903);江苏省制浆造纸科学与技术重点实验室开放基金项目(201523)

Delignification mechanism study of acid hydrotropes

Min WANG¹(),Jinlan CHENG¹(),Xin LI^1,²,Jingjing LU¹,Chongxin YIN^1,³,Hongqi DAI¹

^1.Jiangsu Provincial Key Laboratory of Pulp and Paper Science and Technology, Jiangsu Co-innovation Center for Efficient Processing and Utilization of Forest Resources, Nanjing Forestry University, Nanjing 210037, Jiangsu, China
^2.Northeast Forestry University, Harbin 150040, Heilongjiang, China
^3.Shandong Century Sunshine Paper Group, Weifang 262400, Shandong, China

Received:2021-12-17 Revised:2022-04-01 Online:2022-05-05 Published:2022-05-24
Contact: Jinlan CHENG

摘要/Abstract

摘要：

系统探讨了酸性助水溶剂对甲苯磺酸(p-toluenesulfonic acid，TSA)和马来酸(maleic acid，MA)分离桉木各组分的工艺过程，并对其中木质素脱除机理进行了研究。通过分析对比两种优化后的工艺发现：(1)两种酸性助水溶剂都可以高效脱除木质素，TSA木质素脱除率为67.94%，MA为65.14%；(2)在相同质量分数下，TSA的木质素脱除率比MA更高；(3)在温和条件下，TSA木质素的β-芳醚键含量比MA的高，随着反应条件的加剧，TSA和MA处理后木质素产品中β-芳醚键含量逐渐减少；(4)两种酸性助水溶剂处理后，纤维素保留率都较高，可保持90%以上；但是半纤维素的降解程度随着反应条件的加剧而增加；(5)酸性助水溶剂质量分数越高，在疏水表面的接触角越小，对木质素的助溶作用越明显，脱除木质素效率越高，溶液中木质素聚集体的粒径越小。综上所述，酸性助水溶剂对木质素的脱除基于润湿溶解、木质素芳醚键断裂、半纤维素降解等的综合作用。相关研究可为后续实现温和条件脱木质素工艺优化及机理提供参考。

关键词: 酸性助水溶剂, 脱木质素, 反应动力学, 生物质, 聚集(作用), 接触角

Abstract:

p-Toluenesulfonic acid (TSA) and maleic acid (MA) are important acid hydrotropes for lignocellulose fractionation in recent years. The delignification mechanism of TSA and MA fractionation of eucalyptus wood chips was studied. The results were as follows: (1) Both acid hydrotropes have high delignification efficiency. The delignification rate of TSA was 67.94% and that of MA was 65.14%; (2) The delignification rate of TSA was higher than that of MA at the same hydrotrope concentration; (3) TSA hydrotropic lignin has higher β-aryl ether linkage content than that of MA lignin under mild condition, the β-aryl ether linkage content of acid hydrotrope dissolved lignin was reduced with the increasing fractionation severity; (4) More than 90% cellulose was well retained after fractionation, but the hemicellulose degradation rate increased with the reaction severity; (5) The contact angle decreased with the increasing hydrotrope concentration, so the wetting ability of lignin increased, and delignification rate increased also, the size of lignin aggregate in acid hydrotropes decreased. In conclusion, delignification of hydrotropes is a combined effect of wetting dissolution, aryl-ether linkages cleavage and hemicellulose degradation etc. The research can provide a reference for the process optimization and mechanism of delignification under mild conditions.

Key words: acid hydrotrope, delignification, reaction kinetics, biomass, aggregation, contact angle

中图分类号:

TQ 352.62

王敏, 程金兰, 李鑫, 陆晶晶, 尹崇鑫, 戴红旗. 酸性助水溶剂脱除木质素机理分析[J]. 化工学报, 2022, 73(5): 2206-2221.

Min WANG, Jinlan CHENG, Xin LI, Jingjing LU, Chongxin YIN, Hongqi DAI. Delignification mechanism study of acid hydrotropes[J]. CIESC Journal, 2022, 73(5): 2206-2221.

图/表 20

表1 TSA实验因素设计

Table 1 TSA experiment factors design

水平	质量分数/%	反应温度/℃	反应时间/min
1	25	70	30
2	25	80	60
3	25	90	90
4	40	70	60
5	40	80	90
6	40	90	30
7	55	70	90
8	55	80	30
9	55	90	60

表2 MA实验因素设计

Table 2 MA experiment factors design

水平	质量分数/%	反应温度/℃	反应时间/min
1	40	100	60
2	40	120	120
3	40	140	180
4	55	100	120
5	55	120	180
6	55	140	60
7	70	100	180
8	70	120	60
9	70	140	120

表3 桉木片原料化学成分

Table 3 Chemical composition of eucalyptus chip material

化学成分	含量/%
灰分	0.3±0.01
苯醇抽提物	0.57±0.03
酸溶木质素	4.09±0.02
酸不溶木质素	22.89±0.1
葡聚糖	36.54±1.1
木聚糖	14.55±0.8

表4 分离组分的化学成分

Table 4 Chemical composition of fractions

样品编号	固体组分							液体组分
样品编号	灰分/%	得率/%	酸溶木质素/%	酸不溶木质素/%	木质素脱除率/%	葡聚糖/%	木聚糖/%	木糖/（g/L)
P25T70t30	0.34±0.02	93.59±0.20	4.72（96.08）±0.02	22.15（90.57）±0.27	9.43±1.22	41.42（99.17）±1.00	13.47（86.62）±0.33	1.70±0.05
P40T70t60	0.25±0.00	72.56±0.18	4.47（83.09）±0.00	19.05（68.90）±0.59	31.30±0.20	43.78（96.50）±0.97	12.57（71.34）±0.99	2.68±0.04
P25T80t60	0.24±0.04	80.02±0.20	3.56（78.35）±0.02	18.94（65.21）±0.30	33.79±0.39	42.42（98.86）±0.30	10.56（58.07）±0.78	4.67±0.02
P55T80t30	0.17±0.00	75.49±0.04	3.08（54.94）±0.05	16.29（53.20）±0.68	47.80±1.03	46.59（99.54）±0.78	8.52（42.94）±0.88	5.45±0.03
P55T70t90	0.09±0.00	73.36±0.15	2.55（45.89）±0.01	15.14（50.57）±0.79	47.43±1.08	56.49（102.89）±0.39	6.78（37.05）±0.90	6.78±0.02
P40T90t30	0.06±0.00	70.97±0.13	2.08（29.76）±0.03	13.54（46.95）±0.20	55.05±1.09	58.39（100.90）±0.65	6.88（35.95）±0.20	10.07±0.03
P40T80t90	0.08±0.1	69.38±0.07	1.56（18.92）±0.00	13.48（42.80）±0.01	57.37±0.98	60.30（105.48）±0.76	5.15（25.60）±0.44	13.92±0.06
P25T90t90	0.09±0.03	63.73±0.07	1.01（8.58）±0.04	12.95（37.29）±0.30	62.91±0.79	59.61（102.34）±0.89	5.25（24.81）±0.77	14.78±0.08
P55T90t60	0.06±0.02	58.50±0.20	0.53（7.59）±0.01	12.54（32.06）±1.49	67.94±0.90	72.14（98.73）±0.45	4.08（16.42）±0.02	15.08±0.10
M40T100t60	0.31±0.01	91.63±0.19	4.89（96.28）±0.10	22.17（88.76）±0.67	11.24±0.76	46.77（94.49）±1.29	12.33（77.65）±1.08	1.89±0.01
M55T100t120	0.28±0.04	74.50±0.03	4.38（83.56）±0.03	20.58（75.99）±0.40	24.01±1.02	56.59（95.59）±0.45	9.52（58.73）±0.99	7.50±0.02
M70T120t60	0.23±0.00	72.24±0.16	3.68（59.27）±0.02	19.05（56.33）±0.30	43.67±1.07	59.00（93.72）±0.64	8.51（45.07）±0.97	12.03±0.01
M40T120t120	0.18±0.05	71.01±0.16	3.04（51.57）±0.04	18.16（53.46）±0.99	46.54±1.11	49.10（95.43）±0.82	9.24（37.56）±0.76	13.92±0.04
M55T140t60	0.19±0.00	67.98±0.18	2.74（49.04）±0.03	17.80（49.90）±0.39	50.10±0.20	62.52（95.61）±0.84	7.65（35.74）±0.56	15.20±0.02
M70T100t180	0.02±0.01	65.60±0.09	2.03（47.22）±0.01	16.06（47.80）±1.01	52.20±0.49	56.66（93.97）±0.39	6.54（32.25）±0.88	15.98±0.07
M55T120t180	0.05±0.01	63.81±0.19	1.78（35.07）±0.04	15.68（45.04）±0.20	54.96±0.59	66.73（94.71）±0.59	6.57（28.38）±0.99	16.06±0.03
M40T140t180	0.03±0.01	62.11±0.11	1.34（28.42）±0.02	13.21（36.33）±0.30	63.67±0.50	59.66（91.28）±0.58	6.44（26.17）±0.30	16.60±0.80
M70T140t120	0.06±0.03	60.58±0.13	0.67（13.68）±0.01	12.75（34.86）±0.22	65.14±1.02	66.72（90.13）±0.67	4.10（17.63）±0.20	17.06±0.13

表4 分离组分的化学成分

Table 4 Chemical composition of fractions

样品编号	固体组分							液体组分
样品编号	灰分/%	得率/%	酸溶木质素/%	酸不溶木质素/%	木质素脱除率/%	葡聚糖/%	木聚糖/%	木糖/（g/L)
P25T70t30	0.34±0.02	93.59±0.20	4.72（96.08）±0.02	22.15（90.57）±0.27	9.43±1.22	41.42（99.17）±1.00	13.47（86.62）±0.33	1.70±0.05
P40T70t60	0.25±0.00	72.56±0.18	4.47（83.09）±0.00	19.05（68.90）±0.59	31.30±0.20	43.78（96.50）±0.97	12.57（71.34）±0.99	2.68±0.04
P25T80t60	0.24±0.04	80.02±0.20	3.56（78.35）±0.02	18.94（65.21）±0.30	33.79±0.39	42.42（98.86）±0.30	10.56（58.07）±0.78	4.67±0.02
P55T80t30	0.17±0.00	75.49±0.04	3.08（54.94）±0.05	16.29（53.20）±0.68	47.80±1.03	46.59（99.54）±0.78	8.52（42.94）±0.88	5.45±0.03
P55T70t90	0.09±0.00	73.36±0.15	2.55（45.89）±0.01	15.14（50.57）±0.79	47.43±1.08	56.49（102.89）±0.39	6.78（37.05）±0.90	6.78±0.02
P40T90t30	0.06±0.00	70.97±0.13	2.08（29.76）±0.03	13.54（46.95）±0.20	55.05±1.09	58.39（100.90）±0.65	6.88（35.95）±0.20	10.07±0.03
P40T80t90	0.08±0.1	69.38±0.07	1.56（18.92）±0.00	13.48（42.80）±0.01	57.37±0.98	60.30（105.48）±0.76	5.15（25.60）±0.44	13.92±0.06
P25T90t90	0.09±0.03	63.73±0.07	1.01（8.58）±0.04	12.95（37.29）±0.30	62.91±0.79	59.61（102.34）±0.89	5.25（24.81）±0.77	14.78±0.08
P55T90t60	0.06±0.02	58.50±0.20	0.53（7.59）±0.01	12.54（32.06）±1.49	67.94±0.90	72.14（98.73）±0.45	4.08（16.42）±0.02	15.08±0.10
M40T100t60	0.31±0.01	91.63±0.19	4.89（96.28）±0.10	22.17（88.76）±0.67	11.24±0.76	46.77（94.49）±1.29	12.33（77.65）±1.08	1.89±0.01
M55T100t120	0.28±0.04	74.50±0.03	4.38（83.56）±0.03	20.58（75.99）±0.40	24.01±1.02	56.59（95.59）±0.45	9.52（58.73）±0.99	7.50±0.02
M70T120t60	0.23±0.00	72.24±0.16	3.68（59.27）±0.02	19.05（56.33）±0.30	43.67±1.07	59.00（93.72）±0.64	8.51（45.07）±0.97	12.03±0.01
M40T120t120	0.18±0.05	71.01±0.16	3.04（51.57）±0.04	18.16（53.46）±0.99	46.54±1.11	49.10（95.43）±0.82	9.24（37.56）±0.76	13.92±0.04
M55T140t60	0.19±0.00	67.98±0.18	2.74（49.04）±0.03	17.80（49.90）±0.39	50.10±0.20	62.52（95.61）±0.84	7.65（35.74）±0.56	15.20±0.02
M70T100t180	0.02±0.01	65.60±0.09	2.03（47.22）±0.01	16.06（47.80）±1.01	52.20±0.49	56.66（93.97）±0.39	6.54（32.25）±0.88	15.98±0.07
M55T120t180	0.05±0.01	63.81±0.19	1.78（35.07）±0.04	15.68（45.04）±0.20	54.96±0.59	66.73（94.71）±0.59	6.57（28.38）±0.99	16.06±0.03
M40T140t180	0.03±0.01	62.11±0.11	1.34（28.42）±0.02	13.21（36.33）±0.30	63.67±0.50	59.66（91.28）±0.58	6.44（26.17）±0.30	16.60±0.80
M70T140t120	0.06±0.03	60.58±0.13	0.67（13.68）±0.01	12.75（34.86）±0.22	65.14±1.02	66.72（90.13）±0.67	4.10（17.63）±0.20	17.06±0.13

表5 TSA正交实验与极差分析

Table 5 TSA orthogonal experiment and range analysis

水平	因素			木质素脱除率/%
水平	A质量分数/%	B反应温度/℃	C反应时间/min	木质素脱除率/%
1	25	70	30	9.43
2	25	80	60	34.79
3	25	90	90	62.71
4	40	70	60	31.10
5	40	80	90	57.20
6	40	90	30	53.05
7	55	70	90	49.43
8	55	80	30	46.80
9	55	90	60	67.94
K₁	107	0.90	190
K₂	141	139	134
K₃	164	184	169
k₁	36	30	36
k₂	47	46	45
k₃	55	61	56
极差R	19	31	20
最优方案	A3	B3	C3
极差R排序		BCA

表6 MA正交实验与极差分析

Table 6 MA orthogonal experiment and range analysis

水平	因素			木质素脱除率/%
水平	A质量分数/%	B反应温度/℃	C反应时间/min	木质素脱除率/%
1	40	100	60	11.24
2	40	120	120	43.67
3	40	140	180	63.67
4	55	100	120	24.01
5	55	120	180	54.96
6	55	140	60	50.10
7	70	100	180	52.20
8	70	120	60	46.54
9	70	140	120	65.14
K₁	119	96	108
K₂	140	147	142
K₃	164	179	173
k₁	40	32	36
k₂	47	49	47
k₃	55	60	58
极差R	15	11	22
最优方案	A3	B3	C3
极差R排序		CAB

表7 式（4）~式（7）拟合参数

Table 7 Fitting parameters for Eqs. （4）—（7）

参数	单位	CDF		CHF
参数	单位	TSA	MA	TSA	MA
α，α′	—	35.46	11.75	26.79	9.01
β，β′	—	0.14	9.9E-05	0.10	0.10
E，E′	J/mol	95800	44187	78958	49852
f，f′	—	0.00036	0.015	0.0072	0.08
θ，θ′	—	0.64	0.73	0.88	0.37
θ_Re，θ $R e'$	—	0.33	0.35	0.14	0.00042

表7 式（4）~式（7）拟合参数

Table 7 Fitting parameters for Eqs. （4）—（7）

参数	单位	CDF		CHF
参数	单位	TSA	MA	TSA	MA
α，α′	—	35.46	11.75	26.79	9.01
β，β′	—	0.14	9.9E-05	0.10	0.10
E，E′	J/mol	95800	44187	78958	49852
f，f′	—	0.00036	0.015	0.0072	0.08
θ，θ′	—	0.64	0.73	0.88	0.37
θ_Re，θ $R e'$	—	0.33	0.35	0.14	0.00042

图1 TSA [(a), (c)]、MA [(b), (d)]组分分离的CDF、CHF曲线

Fig.1 CDF and CHF curves of TSA [(a), (c)] and MA [(b), (d)]

表8 TSA、MA组分分离的CDF和 CHF值

Table 8 CDF and CHF values of TSA and MA fractionation

处理条件	CDF/（min·mol/L）	CHF/（min·mol/L）
P25T70t30	363.2	21.0
P40T70t60	1419.4	78.6
P25T80t60	1881.2	91.8
P55T80t30	3121.8	139.7
P55T70t90	3615.9	180.6
P40T90t30	4517.6	191.3
P40T80t90	5514.3	258.2
P25T90t90	6935.4	289.1
P55T90t60	15344.9	586.3
P55T90t90	23017.3	879.4
M40T100t60	21.4	0.3
M55T100t120	57.5	1.1
M70T120t60	82.5	1.6
M40T120t120	88.2	2.1
M55T140t60	114.2	2.5
M70T100t180	119.8	2.8
M55T120t180	178.0	3.7
M40T140t180	254.7	4.9
M70T140t120	317.5	8.9
M70T140t180	476.2	13.4

图2 TSA（a）、MA（b）固体组分光学显微镜图（100倍）

Fig.2 Microscope images of the solid fraction of TSA(a) and MA(b)（100倍）

表9 TSA和MA固体组分纤维质量分析

Table 9 Fiber quality analysis of TSA and MA solid fraction

处理条件	数均长度/mm	重均长度/mm	宽度/μm	扭结指数/%	卷曲指数/%	细小纤维含量/%	长宽比
P25T70t30	0.596	0.578	21.5	15.0	5.0	30.2	26.9
P40T70t60	0.509	0.540	20.6	14.9	4.9	31.9	26.2
P25T80t60	0.479	0.532	19.2	14.2	4.8	32.9	27.7
P55T80t30	0.403	0.468	19.0	14.0	5.2	33.8	24.6
P55T70t90	0.379	0.457	19.0	14.3	5.8	35.8	24.1
P40T90t30	0.309	0.456	18.7	14.6	6.0	37.0	24.4
P40T80t90	0.380	0.489	19.3	14.9	6.4	45.9	25.3
P25T90t90	0.346	0.410	19.2	14.2	6.2	50.3	21.4
P55T90t60	0.301	0.335	19.2	12.7	5.7	56.1	17.4
M40T100t60	0.568	0.599	21.8	12.2	4.9	33.1	27.5
M55T100t120	0.485	0.556	19.2	11.8	5.3	39.5	28.6
M70T120t60	0.437	0.536	19.4	10.3	5.4	39.9	27.6
M40T120t120	0.425	0.474	19.1	9.3	5.4	46.1	24.8
M55T140t60	0.402	0.456	18.3	9.0	5.5	48.3	24.9
M70T100t180	0.304	0.448	18.6	8.9	5.7	50.9	24.1
M55T120t180	0.317	0.467	19.2	9.2	5.8	55.3	24.3
M40T140t180	0.302	0.407	19.0	8.1	5.1	58.6	21.4
M70T140t120	0.299	0.324	18.9	7.2	4.4	60.0	17.1

图3 TSA（a）、MA（b）处理后固体组分的红外光谱图

Fig.3 FTIR spectrum of the solid fraction of TSA (a) and MA (b)

图4 TSA（a）、MA（b）处理后木质素的红外光谱图

Fig.4 FTIR spectrum of lignin of TSA (a) and MA (b)

图5 木质素脂肪族和芳香族区域的2D-HSQC谱图A—β-O-4醚键结构,γ位为羟基;A′—β-O-4醚键结构,γ位为乙酰基;A″—β-O-4醚键结构,γ位为酯化对香豆酸酯;B—苯基香豆满结构,由β-5和α-O-4联接而成;C—树脂醇结构,由β-β、α-O-γ和γ-O-α联接而成;HKγ—希伯特酮;Eγ(MA)—S或G木质素结构单元含有γ-OH[28];S—紫丁香基结构;S′—氧化紫丁香基结构,α位为酮基;G—愈创木基结构;G′—氧化愈创木基结构

Fig.5 The aromatic regions (δC/δH 90—150/6.0—8.0) and aliphatic region (δC/δH 50—90/2.0—6.0) of lignin in 2D-HSQC NMR spectra

表10 木质素2D-HSQC信号归属

Table 10 Assignments of the lignin 13C-1H correlation peaks in the 2D-HSQC spectra of lignin

信号	δC/δH	信号归属
S_2/6	103.9/6.84	C_2/6-H_2/6 in syringyl units (S)
S $2 / 6'$	106.2/7.35	C_2/6-H_2/6 in oxidized S units (S′)
S_con	106.5/6.48	condensed C_2/6-H_2/6in syringyl units
G₂	110.9/7.05	C₂-H₂ in guaiacyl units (G)
G $2'$	110.9/7.34	C₂-H₂ in oxidized(C_α-O)guaiacyl units (G′)
G₅	114.5/6.71	C₅-H₅ in guaiacyl units (G)
G₆	118.9/6.77	C₆-H₆in guaiacyl units (G)
A_γ	59.9/3.63	C_γ-H_γ in γ-hydroxylated β-O-4′ substructures (A)
B_γ	62.6/3.72	C_γ-H_γ in β-β resinol (B)
C_γ	62.4/3.43	C_γ-H_γ in phenylcoumaran (C)
A $γ'$	64.8/4.31	C_γ-H_γ in γ-acylated β-O-4(A′ )
(A,A′)_ɑ	71.5/5.00	C_α-H_α in β-O-4′ substructures (A)
B_ɑ	86.9/5.55	C_α-H_α in phenylcoumaran substructures(B)
C_ɑ	86.8/5.47	C_α-H_α in β-β′ resinol substructures (C)
A_β(G)	83.8/4.48	C_β-H_β in β-O-4′ substructures (A) linked to a G-unit
A_β(S)	86.0/4.25	C_β-H_β in β-O-4′ substructures (A) linked to a S-unit
B_β	53.5/3.46	C_β-H_βin phenylcoumaran substructures(B)
C_β	53.1/3.06	C_β-H_β in β-β′resinol substructures (C)
methoxyl	55.6/3.58	methoxyl
HK_γ	67.1/4.19	C_γ-H_γ in Hibbert’s ketone (HK)
E_γ(MA)	128.0/6.2, 132.9/6.4, 68.3/4.37	C_γ-esterified by maleic acid

表10 木质素2D-HSQC信号归属

Table 10 Assignments of the lignin 13C-1H correlation peaks in the 2D-HSQC spectra of lignin

信号	δC/δH	信号归属
S_2/6	103.9/6.84	C_2/6-H_2/6 in syringyl units (S)
S $2 / 6'$	106.2/7.35	C_2/6-H_2/6 in oxidized S units (S′)
S_con	106.5/6.48	condensed C_2/6-H_2/6in syringyl units
G₂	110.9/7.05	C₂-H₂ in guaiacyl units (G)
G $2'$	110.9/7.34	C₂-H₂ in oxidized(C_α-O)guaiacyl units (G′)
G₅	114.5/6.71	C₅-H₅ in guaiacyl units (G)
G₆	118.9/6.77	C₆-H₆in guaiacyl units (G)
A_γ	59.9/3.63	C_γ-H_γ in γ-hydroxylated β-O-4′ substructures (A)
B_γ	62.6/3.72	C_γ-H_γ in β-β resinol (B)
C_γ	62.4/3.43	C_γ-H_γ in phenylcoumaran (C)
A $γ'$	64.8/4.31	C_γ-H_γ in γ-acylated β-O-4(A′ )
(A,A′)_ɑ	71.5/5.00	C_α-H_α in β-O-4′ substructures (A)
B_ɑ	86.9/5.55	C_α-H_α in phenylcoumaran substructures(B)
C_ɑ	86.8/5.47	C_α-H_α in β-β′ resinol substructures (C)
A_β(G)	83.8/4.48	C_β-H_β in β-O-4′ substructures (A) linked to a G-unit
A_β(S)	86.0/4.25	C_β-H_β in β-O-4′ substructures (A) linked to a S-unit
B_β	53.5/3.46	C_β-H_βin phenylcoumaran substructures(B)
C_β	53.1/3.06	C_β-H_β in β-β′resinol substructures (C)
methoxyl	55.6/3.58	methoxyl
HK_γ	67.1/4.19	C_γ-H_γ in Hibbert’s ketone (HK)
E_γ(MA)	128.0/6.2, 132.9/6.4, 68.3/4.37	C_γ-esterified by maleic acid

表11 木质素结构单元及其比例和连接方式的2D-HSQC半定量分析

Table 11 Semi-quantitative analysis of lignin units and ratio and linkages based on 2D-HSQC spectra

样品编号	CDF/(min·mol/L)	S_2/6	S′_2/6	S_con	S	G	S/G	β-O-4/%	β-5/%	β-β/%
MWL	0	55.56	5.98	0	61.54	42.79	1.44	52.31	2.04	6.67
P40T70t60	1419.4	72.44	2.87	10.55	85.86	14.14	6.07	50.72	0.92	5.23
P40T80t90	5514.3	71.65	2.23	22.18	96.06	3.94	24.40	31.23	0.79	4.20
P55T90t60	15344.9	24.98	2.13	71.74	98.85	1.15	86.21	0	0	1.84
M55T100t120	57.5	58.56	4.10	31.15	93.81	6.19	15.15	31.33	1.00	3.87
M55T120t180	178.0	23.14	2.77	71.42	97.33	2.67	36.49	1.53	0.40	1.03
M70T140t120	317.5	16.13	1.30	81.62	99.05	0.95	104.67	0	0	0.39

图6 酸性助水溶剂质量分数对木质素聚集体的平均粒径影响

Fig.6 The effect of acid hydrotrope concentration on the average particle size of lignin aggregates

表12 酸性助水溶剂接触角

Table 12 The contact angle of acid hydrotropes

质量分数/%	TSA溶液接触角/（°）	MA溶液接触角/（°）
10	107.94±1.90	103.36±0.40
20	94.70±1.70	103.10±1.80
30	89.98±0.70	102.71±0.02
40	84.14±0.02	98.27±0.04
50	83.84±0.04	96.14±0.01

图7 酸性助水溶剂接触角照片

Fig.7 The contact angle images of acid hydrotropes

图8 酸性助水溶剂脱除木质素机理图

Fig.8 Schematic diagram of delignification of acid hydrotropes

参考文献 53

1	亓伟, 王闻, 王琼, 等. 木质纤维素预处理技术及其机理研究进展[J]. 新能源进展, 2013, 1(2): 150-158.
	Qi W, Wang W, Wang Q, et al. Review on the pretreatment method and mechanism of lignocellulose[J]. Advances in New and Renewable Energy, 2013, 1(2): 150-158.
2	祝其丽, 何明雄, 谭芙蓉, 等. 木质纤维素生物质预处理研究现状[J]. 生物技术进展, 2015, 5(6): 414-419.
	Zhu Q L, He M X, Tan F R, et al. Progress on pretreatment technologies of lignocellulosic biomass[J]. Current Biotechnology, 2015, 5(6): 414-419.
3	路鹏, 江滔, 李国学. 木质纤维素乙醇发酵研究中的关键点及解决方案[J]. 农业工程学报, 2006, 22(9): 237-240.
	Lu P, Jiang T, Li G X. Key points of ethanol fermentation of lignocellulose and resolving methods[J]. Transactions of the Chinese Society of Agricultural Engineering, 2006, 22(9): 237-240.
4	Tian S, Zhu W, Gleisner R, et al. Comparisons of SPORL and dilute acid pretreatments for sugar and ethanol productions from Aspen[J]. Biotechnology Progress, 2011, 27(2): 419-427.
5	Zhao Y L, Wang Y, Zhu J Y, et al. Enhanced enzymatic hydrolysis of spruce by alkaline pretreatment at low temperature[J]. Biotechnology and Bioengineering, 2008, 99(6): 1320-1328.
6	Zhang K, Pei Z J, Wang D H. Organic solvent pretreatment of lignocellulosic biomass for biofuels and biochemicals: a review[J]. Bioresource Technology, 2016, 199: 21-33.
7	Brandt A, Ray M J, To T Q, et al. Ionic liquid pretreatment of lignocellulosic biomass with ionic liquid-water mixtures[J]. Green Chemistry, 2011, 13(9): 2489.
8	周静. 预处理对麦草化学组分分离及酶解性能的影响研究[D]. 北京: 中国林业科学研究院, 2018.
	Zhou J. Investigation on effects of different pretreatment methods on chemical composition of wheat straw and enzymatic hydrolysis[D]. Beijing: Chinese Academy of Forestry, 2018.
9	Lee J, Lee S C, Acharya G, et al. Hydrotropic solubilization of paclitaxel: analysis of chemical structures for hydrotropic property[J]. Pharmaceutical Research, 2003, 20(7): 1022-1030.
10	Hodgdon T K, Kaler E W. Hydrotropic solutions[J]. Current Opinion in Colloid & Interface Science, 2007, 12(3): 121-128.
11	Rinaldi R, Jastrzebski R, Clough M T, et al. Paving the way for lignin valorisation: recent advances in bioengineering, biorefining and catalysis[J]. Angewandte Chemie International Edition, 2016, 55(29): 8164-8215.
12	尹崇鑫, 王敏, 程金兰, 等. 助水溶剂应用在生物质精炼领域的研究进展[J]. 林产化学与工业, 2021, 41(3): 134-140.
	Yin C X, Wang M, Cheng J L, et al. Research progress of application of hydrotropes in biorefinery[J]. Chemistry and Industry of Forest Products, 2021, 41(3): 134-140.
13	程金兰, 尹崇鑫, 王敏, 等. p-TsOH对稻草的组分分离动力学及分离产物性质[J]. 林业工程学报, 2022, 7(1): 122-129.
	Cheng J L, Yin C X, Wang M, et al. p-TsOH fractionation kinetics of rice straw and its effect on properties of fraction products[J]. Journal of Forestry Engineering, 2022, 7(1): 122-129.
14	Wang H H, Hirth K, Zhu J J, et al. Dissolution of less-processed wood fibers without bleaching in an ionic liquid: effect of lignin condensation on wood component dissolution[J]. International Journal of Biological Macromolecules, 2019, 134: 740-748.
15	Cheng J L, Hirth K, Ma Q L, et al. Toward sustainable and complete wood valorization by fractionating lignin with low condensation using an acid hydrotrope at low temperatures (≤80℃)[J]. Industrial & Engineering Chemistry Research, 2019, 58(17): 7063-7073.
16	Mou H Y, Wu S B. Comparison of organosolv and hydrotropic pretreatments of eucalyptus for enhancing enzymatic saccharification[J]. Bioresource Technology, 2016, 220: 637-640.
17	Ansari K B, Gaikar V G. Green hydrotropic extraction technology for delignification of sugarcane bagasse by using alkybenzene sulfonates as hydrotropes[J]. Chemical Engineering Science, 2014, 115: 157-166.
18	Chen L H, Dou J Z, Ma Q L, et al. Rapid and near-complete dissolution of wood lignin at ≤80℃ by a recyclable acid hydrotrope[J]. Science Advances, 2017, 3(9): e1701735.
19	Wang Z J, Qiu S, Hirth K, et al. Preserving both lignin and cellulose chemical structures: flow-through acid hydrotropic fractionation at atmospheric pressure for complete wood valorization[J]. ACS Sustainable Chemistry & Engineering, 2019, 7(12): 10808-10820.
20	Cai C, Hirth K, Gleisner R, et al. Maleic acid as a dicarboxylic acid hydrotrope for sustainable fractionation of wood at atmospheric pressure and ≤100℃: mode and utility of lignin esterification[J]. Green Chemistry, 2020, 22(5): 1605-1617.
21	Zhai Q L, Han S M, Hse C Y, et al. 5-Sulfosalicylic acid as an acid hydrotrope for the rapid and green fractionation of woody biomass[J]. Industrial Crops and Products, 2022, 177: 114435.
22	Su C, Hirth K, Liu Z L, et al. Acid hydrotropic fractionation of switchgrass at atmospheric pressure using maleic acid in comparison with p-TsOH: advantages of lignin esterification[J]. Industrial Crops and Products, 2021, 159: 113017.
23	Das S, Paul S. Exploring molecular insights into aggregation of hydrotrope sodium cumene sulfonate in aqueous solution: a molecular dynamics simulation study[J]. Journal of Physical Chemistry B, 2015, 119(7): 3142-3154.
24	尉慰奇. 桉木原料的预处理及其酶解糖化的研究[D]. 广州: 华南理工大学, 2012.
	Yu W Q. The study of pretreatment and enzymatic hydrolysis of eucalyptus raw materials[D]. Guangzhou: South China University of Technology, 2012.
25	李有海, 林奕, 杨丽仙, 等. 正交实验在水质硫化物分析中的应用[J]. 黑龙江科学, 2021, 12(6): 23-25.
	Li Y H, Lin Y, Yang L X, et al. Application of orthogonal experiment in water quality sulfide analysis[J]. Heilongjiang Science, 2021, 12(6): 23-25.
26	文甲龙. 生物质木质素结构解析及其预处理解离机制研究[D]. 北京: 北京林业大学, 2014.
	Wen J L. Structural elucidation of lignin from biomass and its dissociative mechanism during pretreatment process[D]. Beijing: Beijing Forestry University, 2014.
27	Yin C X, Wang M, Ma Q Z, et al. Valorization of rice straw via hydrotropic lignin extraction and its characterization[J]. Molecules (Basel, Switzerland), 2021, 26(14): 4123.
28	Cai C, Li J, Hirth K, et al. Comparison of two acid hydrotropes for sustainable fractionation of birch wood[J]. ChemSusChem, 2020, 13(17): 4649-4659.
29	Zhu W, Houtman C J, Zhu J Y, et al. Quantitative predictions of bioconversion of aspen by dilute acid and SPORL pretreatments using a unified combined hydrolysis factor (CHF)[J]. Process Biochemistry, 2012, 47(5): 785-791.
30	Ma Q L, Zhu J J, Gleisner R, et al. Valorization of wheat straw using a recyclable hydrotrope at low temperatures (≤90℃)[J]. ACS Sustainable Chemistry & Engineering, 2018, 6(11): 14480-14489.
31	Zhou H F, Leu S Y, Wu X L, et al. Comparisons of high titer ethanol production and lignosulfonate properties by SPORL pretreatment of lodgepole pine at two temperatures[J]. RSC Adv., 2014, 4(51): 27030-27038.
32	Zhu J Y, Chen L H, Cai C. Acid hydrotropic fractionation of lignocelluloses for sustainable biorefinery: advantages, opportunities, and research needs[J]. ChemSusChem, 2021, 14(15): 3031-3046.
33	Yang B, Wyman C E. Effect of xylan and lignin removal by batch and flowthrough pretreatment on the enzymatic digestibility of corn stover cellulose[J]. Biotechnology and Bioengineering, 2004, 86(1): 88-98.
34	李忠正. 植物纤维资源化学[M]. 北京: 中国轻工业出版社, 2012.
	Li Z Z. Chemistry of Plant Fiber Resources[M]. Beijing: China Light Industry Press, 2012.
35	蒋侃侃. 马来酸预处理麦秸的研究[D]. 南京: 南京林业大学, 2011.
	Jiang K K. Pretreatment of wheat straw using maleic acid[D]. Nanjing: Nanjing Forestry University, 2011.
36	李猛, 张亚茹, 高梦亚, 等. 玉米秸秆苞叶与茎皮中磨木木质素和木素-碳水化合物复合体的傅里叶红外光谱分析[J]. 玉米科学, 2020, 28(3): 87-91, 98.
	Li M, Zhang Y R, Gao M Y, et al. FT-IR analysis of MWL and LCC in different parts of corn stalk[J]. Journal of Maize Sciences, 2020, 28(3): 87-91, 98.
37	Del Río J C, Rencoret J, Prinsen P, et al. Structural characterization of wheat straw lignin as revealed by analytical pyrolysis, 2D-NMR, and reductive cleavage methods[J]. Journal of Agricultural and Food Chemistry, 2012, 60(23): 5922-5935.
38	Yelle D J, Ralph J, Frihart C R. Characterization of nonderivatized plant cell walls using high-resolution solution-state NMR spectroscopy[J]. Magnetic Resonance in Chemistry, 2008, 46(6): 508-517.
39	Zeng J J, Helms G L, Gao X, et al. Quantification of wheat straw lignin structure by comprehensive NMR analysis[J]. Journal of Agricultural and Food Chemistry, 2013, 61(46): 10848-10857.
40	Li N, Li Y D, Yoo C G, et al. An uncondensed lignin depolymerized in the solid state and isolated from lignocellulosic biomass: a mechanistic study[J]. Green Chemistry, 2018, 20(18): 4224-4235.
41	Shuai L, Amiri M T, Questell-Santiago Y M, et al. Formaldehyde stabilization facilitates lignin monomer production during biomass depolymerization[J]. Science, 2016, 354(6310): 329-333.
42	姚敏. 磷酸-超声法分离桉木木质素及其结构的表征[D]. 南宁: 广西大学, 2020.
	Yao M. Phosphoric acid-ultrasonic separation eucalyptus lignin and characterization its structure[D]. Nanning: Guangxi University, 2020.
43	Zhang C F, Wang F. Catalytic lignin depolymerization to aromatic chemicals[J]. Accounts of Chemical Research, 2020, 53(2): 470-484.
44	Yang L F, Cao J, Jin Y C, et al. Effects of sodium carbonate pretreatment on the chemical compositions and enzymatic saccharification of rice straw[J]. Bioresource Technology, 2012, 124: 283-291.
45	曹婷月. 利用QCM研究木质素结构对纤维素酶吸附和酶水解的影响[D]. 南京: 南京林业大学, 2018.
	Cao T Y. The effect of lignin structure on cellulase adsorption and enzymatic hydrolysis by using QCM[D]. Nanjing: Nanjing Forestry University, 2018.
46	张颖, 翟勇祥. 木质素的催化加氢转化[J]. 化工学报, 2017, 68(3): 821-830.
	Zhang Y, Zhai Y X. Catalytic hydroprocessing of lignin[J]. CIESC Journal, 2017, 68(3): 821-830.
47	Subramanian D, Anisimov M A. Phase behavior and mesoscale solubilization in aqueous solutions of hydrotropes[J]. Fluid Phase Equilibria, 2014, 362: 170-176.
48	Robertson A E, Phan D H, Macaluso J E, et al. Mesoscale solubilization and critical phenomena in binary and quasi-binary solutions of hydrotropes[J]. Fluid Phase Equilibria, 2016, 407: 243-254.
49	Enami S, Ishizuka S, Colussi A J. Chemical signatures of surface microheterogeneity on liquid mixtures[J]. The Journal of Chemical Physics, 2019, 150(2): 024702.
50	Blanco D, Rivera N, Oulego P, et al. Novel fatty acid anion-based ionic liquids: contact angle, surface tension, polarity fraction and spreading parameter[J]. Journal of Molecular Liquids, 2019, 288: 110995.
51	Szumala P, Mowinska A. Perfectly wetting mixtures of surfactants from renewable resources: the interaction and synergistic effects on adsorption and micellization[J]. Journal of Surfactants and Detergents, 2016, 19(3): 437-445.
52	陈杰, 史素青, 宫永宽, 等. 特殊润湿表面制备方法及表面形貌研究进展[J]. 涂料工业, 2021, 51(8): 75-82.
	Chen J, Shi S Q, Gong Y K, et al. Research progress of preparation methods and surface morphology of specially designed wetting surfaces[J]. Paint & Coatings Industry, 2021, 51(8): 75-82.
53	Koparkar Y P, Gaikar V G. Solubility of o-/p-hydroxyacetophenones in aqueous solutions of sodium alkyl benzene sulfonate hydrotropes[J]. Journal of Chemical & Engineering Data, 2004, 49(4): 800-803.

[1]	程成, 段钟弟, 孙浩然, 胡海涛, 薛鸿祥. 表面微结构对析晶沉积特性影响的格子Boltzmann模拟[J]. 化工学报, 2023, 74(S1): 74-86.
[2]	郑佳丽, 李志会, 赵新强, 王延吉. 离子液体催化合成2-氰基呋喃反应动力学研究[J]. 化工学报, 2023, 74(9): 3708-3715.
[3]	汪林正, 陆俞冰, 张睿智, 罗永浩. 基于分子动力学模拟的VOCs热氧化特性分析[J]. 化工学报, 2023, 74(8): 3242-3255.
[4]	陈佳起, 赵万玉, 姚睿充, 侯道林, 董社英. 开心果壳基碳点的合成及其对Q235碳钢的缓蚀行为研究[J]. 化工学报, 2023, 74(8): 3446-3456.
[5]	张蒙蒙, 颜冬, 沈永峰, 李文翠. 电解液类型对双离子电池阴阳离子储存行为的影响[J]. 化工学报, 2023, 74(7): 3116-3126.
[6]	吴文涛, 褚良永, 张玲洁, 谭伟民, 沈丽明, 暴宁钟. 腰果酚生物基自愈合微胶囊的高效制备工艺研究[J]. 化工学报, 2023, 74(7): 3103-3115.
[7]	杨峥豪, 何臻, 常玉龙, 靳紫恒, 江霞. 生物质快速热解下行式流化床反应器研究进展[J]. 化工学报, 2023, 74(6): 2249-2263.
[8]	董茂林, 陈李栋, 黄六莲, 吴伟兵, 戴红旗, 卞辉洋. 酸性助水溶剂制备木质纳米纤维素及功能应用研究进展[J]. 化工学报, 2023, 74(6): 2281-2295.
[9]	葛泽峰, 吴雨青, 曾名迅, 查振婷, 马宇娜, 侯增辉, 张会岩. 灰化学成分对生物质气化特性的影响规律[J]. 化工学报, 2023, 74(5): 2136-2146.
[10]	禹进, 余彬彬, 蒋新生. 一种基于虚拟组分的燃烧调控化学作用量化及分析方法研究[J]. 化工学报, 2023, 74(3): 1303-1312.
[11]	刘海芹, 李博文, 凌喆, 刘亮, 俞娟, 范一民, 勇强. 羟基-炔点击化学改性半乳甘露聚糖薄膜的制备及性能研究[J]. 化工学报, 2023, 74(3): 1370-1378.
[12]	祖凌鑫, 胡荣庭, 李鑫, 陈余道, 陈广林. 木质生物质化学组分的碳释放产物特征和反硝化利用程度[J]. 化工学报, 2023, 74(3): 1332-1342.
[13]	郑杰元, 张先伟, 万金涛, 范宏. 丁香酚环氧有机硅树脂的制备及其固化动力学研究[J]. 化工学报, 2023, 74(2): 924-932.
[14]	陈晨, 杨倩, 陈云, 张睿, 刘冬. 不同氧浓度下煤挥发分燃烧的化学动力学研究[J]. 化工学报, 2022, 73(9): 4133-4146.
[15]	陈健鑫, 朱瑞杰, 盛楠, 朱春宇, 饶中浩. 纤维素基生物质多孔炭的制备及其超级电容器性能研究[J]. 化工学报, 2022, 73(9): 4194-4206.

酸性助水溶剂脱除木质素机理分析

Delignification mechanism study of acid hydrotropes

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

图/表 20

参考文献 53

相关文章 15

编辑推荐

Metrics

本文评价

水平	质量分数/%	反应温度/℃	反应时间/min
1	25	70	30
2	25	80	60
3	25	90	90
4	40	70	60
5	40	80	90
6	40	90	30
7	55	70	90
8	55	80	30
9	55	90	60

水平	质量分数/%	反应温度/℃	反应时间/min
1	25	70	30
2	25	80	60
3	25	90	90
4	40	70	60
5	40	80	90
6	40	90	30
7	55	70	90
8	55	80	30
9	55	90	60

水平	质量分数/%	反应温度/℃	反应时间/min
1	40	100	60
2	40	120	120
3	40	140	180
4	55	100	120
5	55	120	180
6	55	140	60
7	70	100	180
8	70	120	60
9	70	140	120

水平	质量分数/%	反应温度/℃	反应时间/min
1	40	100	60
2	40	120	120
3	40	140	180
4	55	100	120
5	55	120	180
6	55	140	60
7	70	100	180
8	70	120	60
9	70	140	120

水平	质量分数/%	反应温度/℃	反应时间/min
1	25	70	30
2	25	80	60
3	25	90	90
4	40	70	60
5	40	80	90
6	40	90	30
7	55	70	90
8	55	80	30
9	55	90	60

水平	质量分数/%	反应温度/℃	反应时间/min
1	25	70	30
2	25	80	60
3	25	90	90
4	40	70	60
5	40	80	90
6	40	90	30
7	55	70	90
8	55	80	30
9	55	90	60

水平	质量分数/%	反应温度/℃	反应时间/min
1	40	100	60
2	40	120	120
3	40	140	180
4	55	100	120
5	55	120	180
6	55	140	60
7	70	100	180
8	70	120	60
9	70	140	120

水平	质量分数/%	反应温度/℃	反应时间/min
1	40	100	60
2	40	120	120
3	40	140	180
4	55	100	120
5	55	120	180
6	55	140	60
7	70	100	180
8	70	120	60
9	70	140	120

水平	质量分数/%	反应温度/℃	反应时间/min
1	25	70	30
2	25	80	60
3	25	90	90
4	40	70	60
5	40	80	90
6	40	90	30
7	55	70	90
8	55	80	30
9	55	90	60

水平	质量分数/%	反应温度/℃	反应时间/min
1	25	70	30
2	25	80	60
3	25	90	90
4	40	70	60
5	40	80	90
6	40	90	30
7	55	70	90
8	55	80	30
9	55	90	60

水平	质量分数/%	反应温度/℃	反应时间/min
1	40	100	60
2	40	120	120
3	40	140	180
4	55	100	120
5	55	120	180
6	55	140	60
7	70	100	180
8	70	120	60
9	70	140	120

水平	质量分数/%	反应温度/℃	反应时间/min
1	40	100	60
2	40	120	120
3	40	140	180
4	55	100	120
5	55	120	180
6	55	140	60
7	70	100	180
8	70	120	60
9	70	140	120