液体连续相撞击流反应器中流体混合时间的数值模拟

doi:10.11949/j.issn.0438-1157.20141158

化工学报 ›› 2015, Vol. 66 ›› Issue (6): 2049-2054.DOI: 10.11949/j.issn.0438-1157.20141158

液体连续相撞击流反应器中流体混合时间的数值模拟

罗燕^1,2, 周剑秋^1,2, 郭钊², 余蓓², 熊卉², 杨侠²

1. 南京工业大学机械与动力工程学院, 江苏南京 210009;
2. 武汉工程大学机电工程学院, 湖北武汉 430073

收稿日期:2014-08-01 修回日期:2015-03-01 出版日期:2015-06-05 发布日期:2015-06-05
通讯作者: 周剑秋
基金资助:
湖北省自然科学基金项目(2013CFA025);国家自然科学基金项目(51276131);武汉市科技局晨光计划项目(2013070104010025)。

Numerical simulation of fluid mixing time in liquid impinging streams reactor

LUO Yan^1,2, ZHOU Jianqiu^1,2, GUO Zhao², YU Bei², XIONG Hui², YANG Xia²

1. School of Mechanical and Power Engineering, Nanjing Tech University, Nanjing 210009, Jiangsu, China;
2. School of Mechanical and Electrical Engineering, Wuhan Institute of Technology, Wuhan 430073, Hubei, China

Received:2014-08-01 Revised:2015-03-01 Online:2015-06-05 Published:2015-06-05
Supported by:
supported by the Natural Science Foundation of Hubei Province (2013CFA025), the National Natural Science Foundation of China (51276131), and the Morning Glory Project of Wuhan Science and Technology Bureau (2013070104010025).

摘要/Abstract

摘要：

在混合时间理论计算基础上利用CFD技术模拟连续操作的LISR混合过程, 数值计算与验证混合时间的变化规律。结果表明, 随着输入比有效功率增大, 混合时间先急剧减小后逐渐趋于平稳;LISR撞击区一次撞击局部混合时间在0.25 s以内, 与经验公式或理论公式计算所得结果在数量级上完全一致, 证明数值方法分析一次撞击局部混合时间是可行的, 而且可以弥补实验无法测定中间过程参量的不足;进一步数值分析宏观混合时间与微观混合时间发现, 二者大小相差1个数量级, 但二者变化规律处于一种联动平衡状态, 该结果与前期理论分析结果一致;本研究所得结论可为后续LISR混合强化机理与性能研究提供定量参考。

关键词: 撞击流, 反应器, 混合, 数值模拟

Abstract:

On the basis of theoretical calculation, the mixing process under continuous operation in liquid impinging streams reactor (LISR) was simulated by CFD and the change of mixing time was calculated and verified numerically. With increasing effective specific power, mixing time decreased rapidly at first and then tended to be smooth and steady. The local mixing time in one stroke of impinging mixing was less than 0.25 s, which fully agreed with the order of magnitude figured out by empirical model and theoretical model. It was demonstrated that using the numerical method to analyze local mixing time is feasible. It could also make up for the deficiency of experimental research. To further study macromixing time and micromixing time numerically, it was found that macromixing time was one order of magnitude greater than micromixing time, but both changes were fundamentally consistent and were in a linkage state of equilibrium which was in accordance with our previous theoretical analysis. These conclusions could be used as the mechanism methods and quantitative reference for follow-up study of mixing enhancement mechanism of LISR.

Key words: impinging stream, reactors, blend, numerical simulation

中图分类号:

TQ05

罗燕, 周剑秋, 郭钊, 余蓓, 熊卉, 杨侠. 液体连续相撞击流反应器中流体混合时间的数值模拟[J]. 化工学报, 2015, 66(6): 2049-2054.

LUO Yan, ZHOU Jianqiu, GUO Zhao, YU Bei, XIONG Hui, YANG Xia. Numerical simulation of fluid mixing time in liquid impinging streams reactor[J]. CIESC Journal, 2015, 66(6): 2049-2054.

参考文献 20

[1]	Asghar M Dehkordi, Chiya Savari. Effects of contaminants on the mass-transfer characteristics of a two-impinging-streams gas-liquid reactor [J]. Chemical Engineering & Technology, 2011, 34 (11): 1797-1806.
[2]	Du M, Zhao C, Zhou B. A modified DSMC method for simulating gas-particle two-phase impinging streams [J]. Chemical Engineering Science, 2011, 66 (20): 4922-4931.
[3]	Amir Hossein Harandizadeh, Amir Rahimi, Mohammad Reza Ehsani. Comparison of different modeling strategies for simulation of carbon dioxide absorption in a coaxial impinging streams absorber [J]. Separation Science and Technology, 2011, 46 (1/4): 105-118.
[4]	Wu Yuan (伍沅), Chen Yu (陈煜). Preparation of “ULTRA-FINE” white carbon black in submerged circulative impinging stream reactor [J]. Journal of Chemical Industry and Engineering (China) (化工学报), 2003, 54 (10): 1381-1386.
[5]	Li Weifeng (李伟锋), Sun Zhigang (孙志刚), Liu Haifeng (刘海峰), Wang Fuchen (王辅臣). Flow characteristics of radial jet from two opposed jets [J]. CIESC Journal (化工学报), 2009, 60 (10): 2453-2459.
[6]	Schwertfirm F, Gradl J, Schwarzer H C, Peukert W, Manhart M. The low Reynolds number turbulent flow and mixing in a confined impinging jet reactor [J]. International Journal of Heat and Fluid Flow, 2007, 28: 1429-1442.
[7]	Yang Xia (杨侠), Yu Bei (余蓓), Guo Zhao (郭钊), Luo Yan (罗燕), Chen Xingliang (陈星亮). Numerical simulation of the flow field in multi-nozzle opposed imping stream reactor [J]. Chemical Industry and Engineering Progress (化工进展), 2013, 32 (7): 1480-1483, 1505.
[8]	Yang Xia (杨侠), Liu Fengliang (刘丰良), Mao Zhihui (毛志慧), Xiong Hui (熊卉), Yang Qing (杨清). Mixing performance of a vertical circulative impinging stream reactor with different spacing [J]. Chemical Industry and Engineering Progress (化工进展), 2012, 31 (6): 1210-1214.
[9]	Yang Xia (杨侠), Zhang Tao (张涛), Liang Liyun (梁利云), Wu Yanyang (吴艳阳), Mao Zhihui (毛志慧), Guo Jia (郭嘉). Mixing performance of vertical circulation impinging stream reactor with vertically staggered blades [J]. Chemical Industry and Engineering Progress (化工进展), 2011, 30 (4): 714-719.
[10]	Wu Yuan, Xao Yang, Zhou Yuxin. Micromixing in the submerged circulative impinging stream reactor [J]. Chinese J. Chem. Eng., 2003, 11 (4): 420-425.
[11]	Sun Huaiyu, Wu Yuan, Xu Chenghai. Pressure fluctuation in the submerged circulative impinging stream reactor [J]. Chinese J. Chem. Eng., 2006, 14 (4): 428-434.
[12]	Zhang Jianwei (张建伟), Song Yanfang (宋艳芳). Structural complexity study for the velocity time series in impinging stream mixer [J]. Journal of Mechanical Engineering (机械工程学报), 2011, 47 (22): 174-180.
[13]	Luo Yan, Zhou Jianqiu, Guo Zhao, Yu Bei, Xiong Hui. Theoretical analysis of fluid mixing time in liquid-continuous impinging streams reactor [J]. Journal of Central South University, 2015 (Received).
[14]	Bi Rongshan (毕荣山). Experiment study and multi-scale simulation of turbulent reaction in jet reactors on high schmidt number[D]. Qingdao: Qingdao University of Science and Technology, 2008.
[15]	Wang Haidong, Zhai Zhiqiang. Analyzing grid independency and numerical viscosity of computational fluid dynamics for indoor environment applications [J]. Building and Environment, 2012, 52 (6): 107-118.
[16]	Radhakrishnan S, Bellan J. Explicit filtering to obtain grid-spacing- independent and discretization-order-independent large-eddy simulation of compressible single-phase flow [J]. Journal of Fluid Mechanics, 2012, 697: 399-435.
[17]	Radhakrishnan S, Bellan J. Explicit filtering to obtain grid-spacing- independent and discretization-order-independent large-eddy simulation of two-phase volumetrically dilute flow with evaporation [J]. Journal of Fluid Mechanics, 2013, 719: 230-267.
[18]	Wu Yuan (伍沅). Impinging Streams—Fundamentals, Properties, and Applications (撞击流: 原理·性质·应用) [M]. Beijing: Chemical Industry Press, 2006
[19]	Zhang Heping (张和平). The research of micromixing in submerged circulative impinging stream reactor [D]. Shenyang: Shenyang Institute of Chemical Technology, 2003.
[20]	Robert J Demyanovich, John R Bourne. Rapid micromixing by the impingement of thin liquid sheets (Ⅱ): Mixing study [J]. Ind. Eng. Chem. Res., 1989, 28: 830-839.

液体连续相撞击流反应器中流体混合时间的数值模拟

Numerical simulation of fluid mixing time in liquid impinging streams reactor

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 15

编辑推荐

Metrics

本文评价

[1]	宋嘉豪, 王文. 斯特林发动机与高温热管耦合运行特性研究[J]. 化工学报, 2023, 74(S1): 287-294.
[2]	张思雨, 殷勇高, 贾鹏琦, 叶威. 双U型地埋管群跨季节蓄热特性研究[J]. 化工学报, 2023, 74(S1): 295-301.
[3]	叶展羽, 山訸, 徐震原. 用于太阳能蒸发的折纸式蒸发器性能仿真[J]. 化工学报, 2023, 74(S1): 132-140.
[4]	张义飞, 刘舫辰, 张双星, 杜文静. 超临界二氧化碳用印刷电路板式换热器性能分析[J]. 化工学报, 2023, 74(S1): 183-190.
[5]	陈爱强, 代艳奇, 刘悦, 刘斌, 吴翰铭. 基板温度对HFE7100液滴蒸发过程的影响研究[J]. 化工学报, 2023, 74(S1): 191-197.
[6]	谈莹莹, 刘晓庆, 王林, 黄鲤生, 李修真, 王占伟. R1150/R600a自复叠制冷循环开机动态特性实验研究[J]. 化工学报, 2023, 74(S1): 213-222.
[7]	王志国, 薛孟, 董芋双, 张田震, 秦晓凯, 韩强. 基于裂隙粗糙性表征方法的地热岩体热流耦合数值模拟与分析[J]. 化工学报, 2023, 74(S1): 223-234.
[8]	何松, 刘乔迈, 谢广烁, 王斯民, 肖娟. 高浓度水煤浆管道气膜减阻两相流模拟及代理辅助优化[J]. 化工学报, 2023, 74(9): 3766-3774.
[9]	邢雷, 苗春雨, 蒋明虎, 赵立新, 李新亚. 井下微型气液旋流分离器优化设计与性能分析[J]. 化工学报, 2023, 74(8): 3394-3406.
[10]	韩晨, 司徒友珉, 朱斌, 许建良, 郭晓镭, 刘海峰. 协同处理废液的多喷嘴粉煤气化炉内反应流动研究[J]. 化工学报, 2023, 74(8): 3266-3278.
[11]	郑玉圆, 葛志伟, 韩翔宇, 王亮, 陈海生. 中高温钙基材料热化学储热的研究进展与展望[J]. 化工学报, 2023, 74(8): 3171-3192.
[12]	程小松, 殷勇高, 车春文. 不同工质在溶液除湿真空再生系统中的性能对比[J]. 化工学报, 2023, 74(8): 3494-3501.
[13]	刘文竹, 云和明, 王宝雪, 胡明哲, 仲崇龙. 基于场协同和耗散的微通道拓扑优化研究[J]. 化工学报, 2023, 74(8): 3329-3341.
[14]	汪尔奇, 彭书舟, 杨震, 段远源. 含HFO混合体系气液相平衡的理论模型评价[J]. 化工学报, 2023, 74(8): 3216-3225.
[15]	洪瑞, 袁宝强, 杜文静. 垂直上升管内超临界二氧化碳传热恶化机理分析[J]. 化工学报, 2023, 74(8): 3309-3319.