Zn(OAc)2/AC催化固定床上CO2与1,2-丙二醇合成碳酸丙烯酯及其反应机理

doi:10.11949/j.issn.0438-1157.20141163

化工学报 ›› 2015, Vol. 66 ›› Issue (2): 567-575.DOI: 10.11949/j.issn.0438-1157.20141163

• 催化、动力学与反应器 • 上一篇下一篇

Zn(OAc)₂/AC催化固定床上CO₂与1,2-丙二醇合成碳酸丙烯酯及其反应机理

张光洁, 耿艳楼, 安华良, 赵新强, 王延吉

河北工业大学化工学院, 绿色化工与高效节能河北省重点实验室, 天津 300130

收稿日期:2014-08-01 修回日期:2014-11-20 出版日期:2015-02-05 发布日期:2015-02-05
通讯作者: 赵新强
基金资助:
国家自然科学基金项目(21076059,21476058,21236001);天津市自然科学基金项目(12JCYBJC12800);河北省应用基础研究计划重点基础研究项目(12965642D)。

Synthesis of propylene carbonate from CO₂ and 1,2-propylene glycol on fixed-bed reactor and its reaction mechanism catalyzed by Zn(OAc)₂/AC

ZHANG Guangjie, GENG Yanlou, AN Hualiang, ZHAO Xinqiang, WANG Yanji

Hebei Provincial Key Laboratory of Green Chemical Technology and Efficient Energy Saving, Hebei University of Technology, Tianjin 300130, China

Received:2014-08-01 Revised:2014-11-20 Online:2015-02-05 Published:2015-02-05
Supported by:
supported by the National Natural Science Foundation of China (21076059, 21476058, 21236001), the Natural Science Foundation of Tianjin City (12JCYBJC12800) and the Key Basic Research Project of Applied Basic Research Plan of Hebei Province (12965642D).

摘要/Abstract

摘要：

以负载型乙酸锌为催化剂,在固定床上实现了CO₂和1,2-丙二醇(PG)合成碳酸丙烯酯(PC)反应。考察了不同载体和负载量对负载型乙酸锌催化性能的影响以及反应条件对PC合成反应的影响。结果表明:负载量为40% (质量分数)的Zn(OAc)₂/AC催化性能最好。CO₂与PG合成PC适宜的反应条件为:PG、乙腈和CO₂的摩尔比为1:1.8:11,CO₂ 压力 4.0 MPa,反应温度160 ℃和液空速0.9 h^-1。在此条件下,PC收率和选择性分别为6.3%和49.0%。采用原位红外结合设计实验研究了无水乙酸锌分别与CO₂和PG之间的相互作用,发现CO₂与乙酸锌之间的化学吸附比较弱,而PG与乙酸锌之间的化学吸附较强,能够活化PG。据此推测了乙酸锌催化CO₂与PG合成PC的反应机理。

关键词: 1,2-丙二醇, 二氧化碳, 碳酸丙烯酯, 固定床, 催化剂, 反应机理

Abstract:

Propylene carbonate (PC) was synthesized on a fixed-bed reactor from CO₂ and propylene glycol (PG) catalyzed by supported Zn(OAc)₂ catalyst. Then the effect of the kind of carrier and its loading on the catalytic performance and the influence of reaction conditions on PC synthesis reaction were investigated. The results indicates that Zn(OAc)₂/AC with loading of 40% (mass) shows better catalytic performance. The suitable reaction conditions are obtained as follows: molar ratio of PG to acetonitrile(solvent) to CO₂ is 1:1.8:11, reaction temperature 160℃, CO₂ pressure 4.0 MPa and LHSV 0.9 h^-1. Under the above conditions, the yield and selectivity of PC were 6.3% and 49.0%, respectively. The interaction between Zn(OAc)₂and CO₂ or PG was investigated by in-situ IR technique combined with some designed experiments. It was found that the chemical adsorption of CO₂ on Zn(OAc)₂is weaker while it is much stronger between PG and Zn(OAc)₂. Chemical bond between PG and Zn(OAc)₂ is found, indicating that Zn(OAc)₂ can activate PG in this reaction. Accordingly, the role of Zn(OAc)₂ in the catalytic reaction of CO₂ and PG to PC is elucidated.

Key words: 1,2-propylene glycol, carbon dioxide, propylene carbonate, fixed-bed, catalyst, reaction mechanism

中图分类号:

张光洁, 耿艳楼, 安华良, 赵新强, 王延吉. Zn(OAc)₂/AC催化固定床上CO₂与1,2-丙二醇合成碳酸丙烯酯及其反应机理[J]. 化工学报, 2015, 66(2): 567-575.

ZHANG Guangjie, GENG Yanlou, AN Hualiang, ZHAO Xinqiang, WANG Yanji. Synthesis of propylene carbonate from CO₂ and 1,2-propylene glycol on fixed-bed reactor and its reaction mechanism catalyzed by Zn(OAc)₂/AC[J]. CIESC Journal, 2015, 66(2): 567-575.

参考文献 16

[1]	Tomishige K, Yasuda H, Yoshida Y, Nurunnabi M, Li B, Kunimori K. Novel route to propylene carbonate: selective synthesis from propylene glycol and carbon dioxide [J]. Catalysis Letters, 2004, 95 (1/2): 45-49
[2]	Tomishige K, Yasuda H, Yoshida Y, Nurunnabi M, Li B, Kunimori K. Catalytic performance and properties of ceria based catalysts for cyclic carbonate synthesis from glycol and carbon dioxide [J]. Green Chemistry, 2004, 6 (4): 206-214
[3]	Du Y, Kong D L, Wang H Y, Cai F, Tian J S, Wang J Q, He L N. Sn-catalyzed synthesis of propylene carbonate from propylene glycol and CO2 under supercritical conditions [J]. Journal of Molecular Catalysis A: Chemical, 2005, 241 (1): 233-237
[4]	Du Y, He L N, Kong D L. Magnesium-catalyzed synthesis of organic carbonate from 1,2-diol/alcohol and carbon dioxide [J]. Catalysis Communications, 2008, 9: 1754-1758
[5]	Chen Hong (陈鸿), Zhao Xinqiang (赵新强), Wang Yanji (王延吉). Synthesis of propylene carbonate from carbon dioxide and 1,2-propylene glycol over potassium carbonate catalyst [J]. Petrochemical Technology (石油化工), 2005, 34 (11): 1037-1040
[6]	Chen Hong (陈鸿), Zhao Xinqiang (赵新强), Wang Yanji (王延吉). Synthesis of propylene carbonate from carbon dioxide and 1,2-propylene glycol over supported potassium carbonate catalyst [J]. Journal of Chemical Engineering of Chinese Universities (高校化学工程学报), 2006, 20 (5): 734-739
[7]	Zhao Xinqiang, Sun Na, Wang Shufang, Li Fang, Wang Yanji. Synthesis of propylene carbonate from carbon dioxide and 1,2-propylene glycol over zinc acetate catalyst [J]. Industrial & Engineering Chemistry Research, 2008, 47 (5): 1365-1369
[8]	Huang Shiyong (黄世勇), Zhao Ning (赵宁), Guo Qiwen (郭启文), Li Junping (李军平), Wei Wei (魏伟), Sun Yuhan (孙予罕). Synthesis of propylene carbonate from carbon dioxide and 1,2-propylene glycol with organic base catalyst [J]. Petrochemical Technology (石油化工), 2007, 36 (6): 601-604
[9]	Huang S Y, Ma J, Li J P, Zhao N, Wei W, Sun Y H. Efficient propylene carbonate synthesis from propylene glycol and carbon dioxide via organic bases [J]. Catalysis Communications, 2008, 9 (2): 276-280
[10]	Huang Shiyong (黄世勇), Ma Jun (马珺), Zhao Ning (赵宁), Dong Manxiang (董满祥), Wei Wei (魏伟), Sun Yuhan (孙予罕). Synthesis of propylene carbonate from carbon dioxide and 1,2-propylene glycol with ferric chloride catalyst [J] Petrochemical Technology (石油化工), 2007, 36 (3): 248-251
[11]	Huang S Y, Liu S G, Li J P, Zhao N, Wei W, Sun Y H. Modified zinc oxide for the direct synthesis of propylene carbonate from propylene glycol and carbon dioxide [J]. Catalysis Letters, 2007, 118 (3/4): 290-294
[12]	Li Guoying (李国英), Chen Shu (陈曙), Wang Yuqing (王玉庆), Yu Boling (于伯龄). Relation between the activity and structure of zinc acetate/activated carbon catalyst [J]. Petrochemical Technology (石油化工), 1984, 13 (10): 649-654
[13]	Mei Yan (梅燕), Nie Zuoren (聂祚仁), Wang Wei (王为). Application of IR spectrum to the research on coordination mechanisms of organic carboxylic acid during homogeneous precipitation [J]. Spectroscopy and Spectral Analysis (光谱学与光谱分析), 2007, 27 (2): 254-258
[14]	Weng Shifu (翁诗甫). Fourier Transform Infrared Spectrometer (傅里叶变换红外光谱仪)[M]. Beijing: Chemical Industry Press, 2005
[15]	Ma Dan (马丹), Wang Guirong (王桂荣), Wang Yanji (王延吉), Zhao Xinqiang (赵新强). Application of IR spectrum to the research on mechanism of synthesis of 2,4-toluene dicarbamate catalyzed by zinc acetate [J]. Spectroscopy and Spectral Analysis (光谱学与光谱分析), 2009, 29 (2): 331-335
[16]	Baba T, Kobayashi A, Kawanami Y, Inazu K, Ishikawa A, Echizenn T, Murai K, Aso S, Inomata M. Characteristics of methoxycarbonylation of aromatic diamine with dimethyl carbonate to dicarbamate using a zinc acetate catalyst [J]. Green Chemistry, 2005, 7 (3): 159-165

Zn(OAc)₂/AC催化固定床上CO₂与1,2-丙二醇合成碳酸丙烯酯及其反应机理

Synthesis of propylene carbonate from CO₂ and 1,2-propylene glycol on fixed-bed reactor and its reaction mechanism catalyzed by Zn(OAc)₂/AC

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 16

相关文章 15

编辑推荐

Metrics

本文评价

[1]	张义飞, 刘舫辰, 张双星, 杜文静. 超临界二氧化碳用印刷电路板式换热器性能分析[J]. 化工学报, 2023, 74(S1): 183-190.
[2]	宋瑞涛, 王派, 王云鹏, 李敏霞, 党超镔, 陈振国, 童欢, 周佳琦. 二氧化碳直接蒸发冰场排管内流动沸腾换热数值模拟分析[J]. 化工学报, 2023, 74(S1): 96-103.
[3]	李艺彤, 郭航, 陈浩, 叶芳. 催化剂非均匀分布的质子交换膜燃料电池操作条件研究[J]. 化工学报, 2023, 74(9): 3831-3840.
[4]	杨学金, 杨金涛, 宁平, 王访, 宋晓双, 贾丽娟, 冯嘉予. 剧毒气体PH₃的干法净化技术研究进展[J]. 化工学报, 2023, 74(9): 3742-3755.
[5]	程业品, 胡达清, 徐奕莎, 刘华彦, 卢晗锋, 崔国凯. 离子液体基低共熔溶剂在转化CO₂中的应用[J]. 化工学报, 2023, 74(9): 3640-3653.
[6]	陈杰, 林永胜, 肖恺, 杨臣, 邱挺. 胆碱基碱性离子液体催化合成仲丁醇性能研究[J]. 化工学报, 2023, 74(9): 3716-3730.
[7]	盛冰纯, 于建国, 林森. 铝基锂吸附剂分离高钠型地下卤水锂资源过程研究[J]. 化工学报, 2023, 74(8): 3375-3385.
[8]	杨菲菲, 赵世熙, 周维, 倪中海. Sn掺杂的In₂O₃催化CO₂选择性加氢制甲醇[J]. 化工学报, 2023, 74(8): 3366-3374.
[9]	洪瑞, 袁宝强, 杜文静. 垂直上升管内超临界二氧化碳传热恶化机理分析[J]. 化工学报, 2023, 74(8): 3309-3319.
[10]	李凯旋, 谭伟, 张曼玉, 徐志豪, 王旭裕, 纪红兵. 富含零价钴活性位点的钴氮碳/活性炭设计及甲醛催化氧化应用研究[J]. 化工学报, 2023, 74(8): 3342-3352.
[11]	杨欣, 彭啸, 薛凯茹, 苏梦威, 吴燕. 分子印迹-TiO₂光电催化降解增溶PHE废水性能研究[J]. 化工学报, 2023, 74(8): 3564-3571.
[12]	余娅洁, 李静茹, 周树锋, 李清彪, 詹国武. 基于天然生物模板构建纳米材料及集成催化剂研究进展[J]. 化工学报, 2023, 74(7): 2735-2752.
[13]	涂玉明, 邵高燕, 陈健杰, 刘凤, 田世超, 周智勇, 任钟旗. 钙基催化剂的设计合成及应用研究进展[J]. 化工学报, 2023, 74(7): 2717-2734.
[14]	张琦钰, 高利军, 苏宇航, 马晓博, 王翊丞, 张亚婷, 胡超. 碳基催化材料在电化学还原二氧化碳中的研究进展[J]. 化工学报, 2023, 74(7): 2753-2772.
[15]	李盼, 马俊洋, 陈志豪, 王丽, 郭耘. Ru/α-MnO₂催化剂形貌对NH₃-SCO反应性能的影响[J]. 化工学报, 2023, 74(7): 2908-2918.