分子量分布对低密度聚乙烯光氧老化特性的影响

doi:10.11949/j.issn.0438-1157.20161330

化工学报 ›› 2017, Vol. 68 ›› Issue (1): 408-417.DOI: 10.11949/j.issn.0438-1157.20161330

• 材料化学工程与纳米技术 • 上一篇下一篇

分子量分布对低密度聚乙烯光氧老化特性的影响

代军¹, 晏华¹, 王雪梅¹, 郭骏骏², 胡志德¹, 杨健健¹, 桑练勇¹

1 中国人民解放军后勤工程学院化学与材料工程系, 重庆 401331;
2 73801部队, 江苏无锡 214000

收稿日期:2016-09-21 修回日期:2016-10-20 出版日期:2017-01-05 发布日期:2017-01-05
通讯作者: 晏华
基金资助:
国家科技支撑计划项目（2012BAF06B04）；重庆市研究生科研创新项目（CYS16239）。

Influence of molecular weight distribution on degradation properties of low density polyethylene by photo-oxidation aging

DAI Jun¹, YAN Hua¹, WANG Xuemei¹, GUO Junjun², HU Zhide¹, YANG Jianjian¹, SANG Lianyong¹

1 Department of Chemistry and Material Engineering, Logistical Engineering University, Chongqing 401331, China;
2 Unit 73801, Wuxi 214000, Jiangsu, China

Received:2016-09-21 Revised:2016-10-20 Online:2017-01-05 Published:2017-01-05
Contact: 10.11949/j.issn.0438-1157.20161330
Supported by:
supported by the National Key Technology Research and Development Program of China(2012BAF06B04) and the Graduate Scientific Research and Innovation Foundation of Chongqing(CYS16239).

摘要/Abstract

摘要：

采用衰减全反射红外光谱技术（ATR-FTIR）、热重分析法（TG）、凝胶渗透色谱（GPC）、扫描电子显微镜（SEM）和力学试验比较研究了不同分子量分布指数低密度聚乙烯（LDPE）的光氧老化特性，分析了分子量分布对LDPE化学结构、热稳定性、平均分子量、表面微观形貌和力学性能的影响规律。结果表明分子量分布越宽，LDPE不饱和度增长越剧烈，支化作用增长越显著；分子量分布越窄，羰基指数增长越快；分子量分布对于分子结构的断链行为并无影响。分子量分布指数越大，LDPE起始热分解温度和失重5%对应温度下降更快，热稳定性更容易变差，平均分子量下降更多，表面微观形貌老化现象越严重；弯曲强度和冲击强度受影响更显著，指数为6.0的LDPE老化24 d冲击强度就已丧失。分析认为，分子量越大、分布越窄表明分子链越长、短分子链越少，与氧接触而产生自由基的概率也越小，因此聚乙烯分子量分布越宽，材料越容易老化。

关键词: 分子量, 分子量分布指数, 低密度聚乙烯, 光氧老化, 色谱, 降解, 氧化

Abstract:

In order to analyze the influence of molecular weight distribution(MWD) on photo-oxidation degradation properties of low density polyethylene(LDPE), the materials parameters(chemical structure, thermal stability, average molecular weight, surface morphology and mechanical properties) of LDPE with different MWD index were studied by attenuated total reflection infrared spectroscopy(ATR-FTIR), thermogravimetry analysis(TGA), gel permeation chromatography(GPC), scanning electron microscope(SEM) and mechanical experiments.The results show that the wide MWD of LDPE resulted in an obvious increasing in the degree of unsaturation and chain branching.For the narrow MWD of LDPE, the degree of carbonyl index increased significantly.The MWD had little effect on the behavior of chain breaking.For the high MWD index, the initial thermal decomposition temperature and 5% mass loss corresponding temperature of LDPE decreased faster, and thermal stability was apt to decline.The average molecular weight decreased much intensely and the aging phenomenon of surface microstructure was much severe.The bending strength and impact strength decreased faster, characterized by the loss of the impact strength of LDPE with 6.0 MWD index after 24 d of aging.Analytically, the large average molecular weight and narrow MWD indicated the long molecular chain and less short-molecular chain, and the probability of production of free radical by oxygen contact was also low.So the wider MWD of the PE, the easier of the material aging.

Key words: molecular weight, molecular weight distribution index, LDPE, photo-oxidation aging, chromatography, degradation, oxidation

中图分类号:

O632.1

代军, 晏华, 王雪梅, 郭骏骏, 胡志德, 杨健健, 桑练勇. 分子量分布对低密度聚乙烯光氧老化特性的影响[J]. 化工学报, 2017, 68(1): 408-417.

DAI Jun, YAN Hua, WANG Xuemei, GUO Junjun, HU Zhide, YANG Jianjian, SANG Lianyong. Influence of molecular weight distribution on degradation properties of low density polyethylene by photo-oxidation aging[J]. CIESC Journal, 2017, 68(1): 408-417.

参考文献 31

[1]	AMMALA A, BATEMAN S, DEAN K, et al. An overview of degradable and biodegradable polyolefin[J]. Progress in Polymer Science, 2011, 36(8):1015-1049.
[2]	刘如, 曹金珍, 彭尧. 木粉组分对木塑复合材料性能的影响研究进展[J]. 化工进展, 2014, 32(8):2072-2083. LIU R, CAO J Z, PENG Y. Influences of wood components on the property of wood-plastic composites[J]. Chemical Industry and Engineering Progress, 2014, 32(8):2072-2083.
[3]	LIU G, LIAO S, ZHU D, et al. Innovative photocatalytic degradation of polyethylene film with boron-doped cryptomelane under UV and visible light irradiation[J]. Chemical Engineering Journal, 2012, 213(1):286-294.
[4]	MARIA R, RODE K, BRULL R, et al. Monitoring the influence of different weathering conditions on polyethylene pipes by IR-microscopy[J]. Polymer Degradation and Stability, 2011, 96:1901-1910.
[5]	KUPPER L, GULMINE J, JANISSEK P, et al. Attenuated total reflection infrared spectroscopy for micro-domain analysis of polyethylene samples after accelerated aging within weathering chambers[J]. Vibrational Spectroscopy, 2004, 34(1):63-72.
[6]	SUGIMOTO M, SHIMADA A, KUDOH H, et al. Product analysis for polyethylene degradation by radiation and thermal aging[J]. Radiation Physics and Chemistry, 2013, 82:69-73.
[7]	JIN H, GONZALEZ G, OBLAK P, et al. The effect of extensive mechanical recycling on the properties of low density polyethylene[J]. Polymer Degradation and Stability, 2012, 97(11):2262-2272.
[8]	郭骏骏, 晏华, 包河彬, 等. 衰减全反射红外光谱法的高密度聚乙烯自然老化特性研究[J]. 光谱学与光谱分析, 2015, 35(6):1520-1524. GUO J J, YAN H, BAO H B, et al. Attenuated total reflection infrared spectroscopy for degradation profile of high density polyethylene after weathering aging[J]. Spectroscopy and Spectral Analysis, 2015, 35(6):1520-1524.
[9]	代军, 晏华, 郭骏骏, 等. 结晶度对高密度聚乙烯热氧老化特性的影响[J]. 高分子材料科学与工程, 2016, 32(9):65-71. DAI J, YAN H, GUO J J, et al. Degradation properties of high density polyethylene by thermo-oxidation aging as a function of crystallinity[J]. Polymer Materials Science and Engineering, 2016, 32(9):65-71.
[10]	GAUTHIER E, LAYCOCK B, CUOQ F J J M, et al. Correlation between chain microstructural changes and embrittlement of LLDPE-based films during photo-and thermo-oxidative degradation[J]. Polymer Degradation and Stability, 2013, 98(1):425-435.
[11]	杨姮, 吕亚栋, 赵锦灿, 等. 高密度聚乙烯在中国湿热和寒冷气候中的自然老化行为[J]. 高分子材料科学与工程, 2016, 32(5):69-73. YANG H, LÜ Y D, ZHAO J C, et al. Outdoor weathering aging behavior of high density polyethylene in warm damp and cold climates in China[J]. Polymer Materials Science and Engineering, 2016, 32(5):69-73.
[12]	杨素, 杨苏平, 陈枫, 等. 聚乙烯短支链与其结晶度关系的定量研究[J]. 现代塑料加工应用, 2006, 18(2):33-35. YANG S, YANG S P, CHEN F, et al. Quantitative analysis of the relationship between short branched chain and crystallinity in polyethylene[J]. Modern Plastics Processing and Applications, 2006, 18(2):33-35.
[13]	郭骏骏, 晏华, 胡志德, 等. 基于主成分分析的高密度聚乙烯环境适应性行为研究[J]. 材料工程, 2015, 43(1):96-103. GUO J J, YAN H, HU Z D, et al. Adaptive behavior to environment of HDPE by Principal Component Analysis[J]. Journal of Materials Engineering, 2015, 43(1):96-103.
[14]	PEREZ C J, FAILLA M D, CARELLA J M. SSA study of early polyethylene degradation stages. Effects of attack rate, of average branch length, and of backbone polyethylene sequences length distributions[J]. Polymer Degradation and Stability, 2013, 98:177-183.
[15]	BENITEZ A, SANCHEZ J J, ARMAL ML, et al. Abiotic degradation of LDPE and LLDPE formulated with a pro-oxidant additive[J]. Polymer Degradation and Stability, 2013, 98:490-501.
[16]	YANG R, YU J, LIU Y, et al. Effects of coupling agents on the natural aging behavior and oxidation profile of high-density polyethylene/sericite composites[J]. Journal of Applied Polymer Science, 2008, 107(1):610-617.
[17]	WANG X P, CHEN S B, ZHANG J, et al. Effect of thermal aging on crystallization behavior and mechanical properties of LDPE/POE blends[J]. Polymer Materials Science and Engineering, 2010, 26(2):87-90.
[18]	王俊, 彭坚. 老化试验中PE-HD的结构与力学性能研究[J]. 中国塑料, 2005, 19(1):44-47. WANG J, PENG J. Study on structure and mechanical properties of PE-HD during the aging test[J]. China Plastic, 2005, 19(1):44-47.
[19]	卢琳, 石野宇, 高瑾, 等. 聚乙烯塑料在西沙自然环境中光老化行为研究[J]. 材料工程, 2011, 1(3):45-49. LU L, SHI Y Y, GAO J, et al. Photo degradation behavior of media density polythene under Xisha (paracel) islands environment[J]. Journal of Materials Engineering, 2011, 1(3):45-49.
[20]	GARDETTE M, PERTHUE A, GARDETTE J L, et al. Photo-and thermal-oxidation of polyethylene:comparison of mechanisms and influence of unsaturation content[J]. Polymer Degradation and Stability, 2013, 98:2383-2390.
[21]	DING Y, MCKINNOM M B, STOLIAROY S I, et al. Determination of kinetics and thermodynamics of thermal decomposition for polymers containing reactive flame retardants:application to poly (lactic acid) blended with melamine and ammonium polyphosphate[J]. Polymer Degradation and Stability, 2016, 129:347-362.
[22]	BUM K B, YUN H L, WON J N, et al. A kinetic study on the supercritical decrosslinking reaction of silane-crosslinked polyethylene in a continuous process[J]. Polymer Degradation and Stability, 2016, 126:75-80.
[23]	潘惠. 高密度聚乙烯基木塑复合材料的老化性能研究[D]. 南京:南京林业大学, 2013. PAN H. Study on aging properties of wood fiber reinforced high density polyethylene composites[D]. Nanjing:Nanjing Forestry University, 2013.
[24]	蒋秀亭, 杨旭东, 童军. 高密度聚乙烯土工格栅光氧老化研究进展[J]. 合成材料老化与应用, 2015, 44(1):82-87. JIANG X T, YANG X D, TONG J. Progress of study on photo-oxidation aging of high density polyethylene geogrids[J]. Synthetic Materials Aging and Application, 2015, 44(1):82-87.
[25]	DOUMINGE L, MALLARINO S, FEAUGAS X, et al. Following the first steps of UV degradation of high density polyethylene by fluorescence spectroscopy[J]. Defect and Diffusion Forum, 2009, 289:741-746.
[26]	卢伟. 聚乙烯的老化与防老化研究进展[J]. 塑料助剂, 2015, 110(2):17-21. LU W. Research development of ageing and ageing resistant for PE[J]. Plastics Additives, 2015, 110(2):17-21.
[27]	刘旭东, 蒋永涛, 李大纲. 热氧老化对稻壳粉/高密度聚乙烯复合材料抗弯强度的影响[J]. 林业机械与木工设备, 2015, 43(4):17-18. LIU X D, JIANG Y T, LI D G. Effect of thermo-oxidative aging on bending strength of rice husk powder/HDPE composite[J]. Forestry Machinery & Woodworking Equipment, 2015, 43(4):17-18.
[28]	杨睿, 于建, 汪昆华, 等. 聚乙烯/碳酸钙复合材料的光氧化降解及沿深度的分布[J]. 高等学校化学学报, 2005, 26(11):2135-2139. YANG R, YU J, WANG K H, et al. Photo-oxidation and depth profile of polyethylene-CaCO3 composites[J]. Chemical Journal of Chinese University, 2005, 26(11):2135-2139.
[29]	LARCHE J F, BUSSIERE P O, THERIAS S, et al. Photooxidation of polymers:relating materials properties to chemical changes[J]. Polymer Degradation and Stability, 2012, 97:25-34.
[30]	郭骏骏, 晏华, 包河彬. 聚烯烃老化评价实验方法评述[J]. 中国塑料, 2014, 28(4):14-22. GUO J J, YAN H, BAO H B. An overview of evaluation testing methods on degradation of polyolefins[J]. China Plastics, 2014, 28(4):14-22.
[31]	GULMINE J V, JANISSEK P R, HEISE H M, et al. Degradation profile of polyethylene after artificial accelerated weathering[J]. Polymer Degradation and Stability, 2003, 79:385-397.

分子量分布对低密度聚乙烯光氧老化特性的影响

Influence of molecular weight distribution on degradation properties of low density polyethylene by photo-oxidation aging

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 31

相关文章 15

编辑推荐

Metrics

本文评价

[1]	张义飞, 刘舫辰, 张双星, 杜文静. 超临界二氧化碳用印刷电路板式换热器性能分析[J]. 化工学报, 2023, 74(S1): 183-190.
[2]	胡超, 董玉明, 张伟, 张红玲, 周鹏, 徐红彬. 浓硫酸活化五氧化二钒制备高浓度全钒液流电池正极电解液[J]. 化工学报, 2023, 74(S1): 338-345.
[3]	宋瑞涛, 王派, 王云鹏, 李敏霞, 党超镔, 陈振国, 童欢, 周佳琦. 二氧化碳直接蒸发冰场排管内流动沸腾换热数值模拟分析[J]. 化工学报, 2023, 74(S1): 96-103.
[4]	米泽豪, 花儿. 基于DFT和COSMO-RS理论研究多元胺型离子液体吸收SO₂气体[J]. 化工学报, 2023, 74(9): 3681-3696.
[5]	陈哲文, 魏俊杰, 张玉明. 超临界水煤气化耦合SOFC发电系统集成及其能量转化机制[J]. 化工学报, 2023, 74(9): 3888-3902.
[6]	杨学金, 杨金涛, 宁平, 王访, 宋晓双, 贾丽娟, 冯嘉予. 剧毒气体PH₃的干法净化技术研究进展[J]. 化工学报, 2023, 74(9): 3742-3755.
[7]	范孝雄, 郝丽芳, 范垂钢, 李松庚. LaMnO₃/生物炭催化剂低温NH₃-SCR催化脱硝性能研究[J]. 化工学报, 2023, 74(9): 3821-3830.
[8]	杨百玉, 寇悦, 姜峻韬, 詹亚力, 王庆宏, 陈春茂. 炼化碱渣湿式氧化预处理过程DOM的化学转化特征[J]. 化工学报, 2023, 74(9): 3912-3920.
[9]	陈美思, 陈威达, 李鑫垚, 李尚予, 吴有庭, 张锋, 张志炳. 硅基离子液体微颗粒强化气体捕集与转化的研究进展[J]. 化工学报, 2023, 74(9): 3628-3639.
[10]	程业品, 胡达清, 徐奕莎, 刘华彦, 卢晗锋, 崔国凯. 离子液体基低共熔溶剂在转化CO₂中的应用[J]. 化工学报, 2023, 74(9): 3640-3653.
[11]	李锦潼, 邱顺, 孙文寿. 煤浆法烟气脱硫中草酸和紫外线强化煤砷浸出过程[J]. 化工学报, 2023, 74(8): 3522-3532.
[12]	杨菲菲, 赵世熙, 周维, 倪中海. Sn掺杂的In₂O₃催化CO₂选择性加氢制甲醇[J]. 化工学报, 2023, 74(8): 3366-3374.
[13]	洪瑞, 袁宝强, 杜文静. 垂直上升管内超临界二氧化碳传热恶化机理分析[J]. 化工学报, 2023, 74(8): 3309-3319.
[14]	李凯旋, 谭伟, 张曼玉, 徐志豪, 王旭裕, 纪红兵. 富含零价钴活性位点的钴氮碳/活性炭设计及甲醛催化氧化应用研究[J]. 化工学报, 2023, 74(8): 3342-3352.
[15]	孟令玎, 崇汝青, 孙菲雪, 孟子晖, 刘文芳. 改性聚乙烯膜和氧化硅固定化碳酸酐酶[J]. 化工学报, 2023, 74(8): 3472-3484.