外加电场下气固流化床的数值模拟

doi:10.3969/j.issn.0438-1157.2013.02.012

化工学报 ›› 2013, Vol. 64 ›› Issue (2): 490-497.DOI: 10.3969/j.issn.0438-1157.2013.02.012

外加电场下气固流化床的数值模拟

朱子川, 孙婧元, 黄正梁, 王靖岱, 阳永荣

浙江大学化学工程与生物工程学系,化学工程联合国家重点实验室,浙江杭州 310027

收稿日期:2012-07-31 修回日期:2012-08-29 出版日期:2013-02-05 发布日期:2013-02-05
通讯作者: 黄正梁
作者简介:朱子川(1989—),男,硕士研究生。
基金资助:
国家自然科学基金项目(21176207);国家重点基础研究发展计划项目(2012CB720500);中央高校基本科研业务费专项资金项目(2011QNA4032);2011年度高等学校博士学科点专项科研基金项目(20110101120020)。

Numerical simulation of gas-solids fluidized bed with applied electric field

ZHU Zichuan, SUN Jingyuan, HUANG Zhengliang, WANG Jingdai, YANG Yongrong

State Key Laboratory of Chemical Engineering, Department of Chemical and Biochemical Engineering, Zhejiang University, Hangzhou 310027, Zhejiang, China

Received:2012-07-31 Revised:2012-08-29 Online:2013-02-05 Published:2013-02-05
Supported by:
supported by the National Natural Science Foundation of China(21176207),the National Basic Research Program of China(2012CB720500) and RFDP(20110101120020).

摘要/Abstract

摘要： 工业流化床中通常存在显著的静电效应,会影响流化床的流体力学特性,并常常带来一定的安全隐患,而引入外加电场可以达到"化害为利"的作用。为了获知外加电场下流化床内的流体力学特性,本文采用CFD耦合静电模型及解耦求解的方式,研究了外加电场下气固流化床内的轴向电势分布和颗粒的运动规律。研究结果表明,传统流化床的轴向电势分布呈Z形,与实验结果一致,引入直流电场后,颗粒自身产生的电场正电势区域明显增大,而负电势区域也有小幅增大。直流电场可以使得壁面处小颗粒的聚集减少,但在床中心出现明显的颗粒聚集。在交流电场下,小颗粒在壁面处的分布比正常流化床时的稀疏。通过对颗粒自身产生电场的分析,发现近分布板区和料位区的电场方向不同,近分布板区的电场指向床中心,而料位区的电场指向壁面。

关键词: 气固流化床, 计算流体力学, 静电, 外加电场

Abstract: Obvious electrostatic effects are commonly found in industrial fluidized bed, which influences the hydrodynamics of fluidized bed and causes security risks constantly.However, the application of external electric field can 'turn harm into benefit'.In order to investigate the hydrodynamics of gas-solids fluidized bed with applied electric field, CFD simulation coupled with the electrostatic model was carried out.Through a decoupling method, the axial electrostatic potentials profiles and particle movements in the fluidized bed were investigated.The simulations presented a Z-shaped axial profile of potential in traditional fluidized bed, which was in good agreement with the experimental data.With the application of direct current (DC) electric field, the simulations showed that the region of positive potential expanded obviously, whilst the region of negative potential was also spread.Under DC electric field, the assembling of small particles was weakened near the wall, but aggregation of small particles appeared near the central electrode.By using AC electric field, the concentration of small particles near the wall was slightly lower than that in the normal fluidized bed.According to the mean electric field distribution produced by charged particles in AC field, it was observed that the electrostatic field had different directions.In the region near the distribution plate, the electrostatic field directed towards the center, while in the region near the bed level, the direction of electrostatic field headed towards the wall.

Key words: gas-solids fluidized bed, CFD, electrostatic, applied electric field

中图分类号:

TQ021.1

朱子川, 孙婧元, 黄正梁, 王靖岱, 阳永荣. 外加电场下气固流化床的数值模拟[J]. 化工学报, 2013, 64(2): 490-497.

ZHU Zichuan, SUN Jingyuan, HUANG Zhengliang, WANG Jingdai, YANG Yongrong. Numerical simulation of gas-solids fluidized bed with applied electric field[J]. CIESC Journal, 2013, 64(2): 490-497.

参考文献 23

[1]	Jin Yong(金涌), Zhu Jinxu(祝金旭), Wang Zhanwen(汪展文), Yu Zhiqing(俞芷青).Fluidization Engineering Principles (流态化工程原理)[M].Beijing:Tsinghua University Press, 2001
[2]	Ciborowski J, Wlodarski A.On electrostatic effects in fluidized beds[J].Chemical Engineering Science,1962, 17(1):23-32
[3]	Johnson T W, Melcher J R.Electromechanics of electrofluidized beds[J].Industrial & Engineering Chemistry Fundamentals,1975, 14(3):146-153
[4]	Colver G M.Bubble control in gas-fluidized beds with applied electric fields[J].Powder Technology,1977, 17(1):9-18
[5]	Dietz P W, Melcher J R.Interparticle electrical forces in packed and fluidized beds[J].Industrial & Engineering Chemistry Fundamentals,1978, 17(1):28-32
[6]	Zahn M, Rhee S W.Electric field effects on the equilibrium and small signal stabilization of electrofluidized beds[J].IEEE Transactions on,Industry Applications,1984,IA-20:137-147
[7]	Wittmann C V.Hydrodynamic changes and chemical reaction in a transparent two-dimensional cross-flow electrofluidized bed(Ⅱ):Theoretical results[J].Industrial & Engineering Chemistry Research,1989, 28(4):454-470
[8]	Kleijn van Willigen F, van Ommen J R, van Turnhout J, et al. Bubble size reduction in a fluidized bed by electric fields[J].International Journal of Chemical Reactor Engineering,2003,DOI:10.2202/1542-6580.1059
[9]	Kleijn van Willigen F, van Ommen J R, van Turnhout J, et al. Bubble size reduction in electric-field-enhanced fluidized beds[J].Journal of Electrostatics,2005, 63(6/7/8/9/10):943-948
[10]	Kleijn van Willigen F, Demirbas B, Deen N G, et al. Discrete particle simulations of an electric-field enhanced fluidized bed[J].Powder Technology,2008, 183(2):196-206
[11]	Rokkam R G, Fox R O, Muhle M E.Computational fluid dynamics and electrostatic modeling of polymerization fluidized-bed reactors[J].Powder Technology,2010, 203(2):109-124
[12]	Rokkam R G, Fox R O, Muhle M E.CFD modeling of electrostatic forces in gas-solid fluidized beds[J].The Journal of Computational Multiphase Flows,2010, 2(4):189-205
[13]	Jalalinejad F, Bi X T, Grace J R.Effect of electrostatic charges on single bubble in gas-solid fluidized beds[J].International Journal of Multiphase Flow,2012,44:15-18
[14]	Ding J, Gidaspow D.A bubbling fluidization model using kinetic theory of granular flow[J].AIChE Journal,1990, 36(4):523-538
[15]	Gidaspow D.Multiphase Flow and Fluidization:Continuum and Kinetic Theory Descriptions[M].USA:Academic Press, 1994
[16]	Goldschmidt M, Kuipers J, van Swaaij W.Hydrodynamic modelling of dense gas-fluidised beds using the kinetic theory of granular flow:effect of coefficient of restitution on bed dynamics[J].Chemical Engineering Science,2001, 56(2):571-578
[17]	Syamlal M.The particle-particle drag term in a multiparticle model of fluidization.Topical Report, DOE/MC/21353-2373, NTIS/DE87006500, National Technical Information Service, Springfield, VA,1987
[18]	Robinson D A, Friedman S P.Electrical conductivity and dielectric permittivity of sphere packings:measurements and modelling of cubic lattices, randomly packed mono-size spheres and multi-size mixtures[J].Physica A:Statistical Mechanics and Its Applications,2005, 358(2):447-465
[19]	Rivas M A, Iglesias T P.On permittivity and density of the systems {triglyme+(dimethyl or diethyl carbonate)} and formulation of Δε in terms of volume or mole fraction[J].The Journal of Chemical Thermodynamics,2008, 40(7):1120-1130
[20]	Xie Guangrun(解广润), Chen Cixuan(陈慈萱).High Voltage Electrostatic Precipitator(高压静电除尘)[M].Beijing:China Water & Power Press, 1993
[21]	Guenther C, Syamlal M.The effect of numerical diffusion on simulation of isolated bubbles in a gas-solid fluidized bed[J].Powder Technology,2001, 116(2):142-154
[22]	Wang Fang,Wang Jingdai,Yang Yongrong.Distribution of electrostatic potential in a gas-solid fluidized bed and measurement of bed level[J].Industrial & Engineering Chemistry Research,2008, 47(23):9517-9526
[23]	Xu Nan(许南).Analysis of electrostatic induction signal and study of the action of external electric field in the fluidized bed.Hangzhou:Zhejiang University, 2012

外加电场下气固流化床的数值模拟

Numerical simulation of gas-solids fluidized bed with applied electric field

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 23

相关文章 15

编辑推荐

Metrics

本文评价

[1]	张思雨, 殷勇高, 贾鹏琦, 叶威. 双U型地埋管群跨季节蓄热特性研究[J]. 化工学报, 2023, 74(S1): 295-301.
[2]	肖明堃, 杨光, 黄永华, 吴静怡. 浸没孔液氧气泡动力学数值研究[J]. 化工学报, 2023, 74(S1): 87-95.
[3]	吴延鹏, 李晓宇, 钟乔洋. 静电纺丝纳米纤维双疏膜油性细颗粒物过滤性能实验分析[J]. 化工学报, 2023, 74(S1): 259-264.
[4]	温凯杰, 郭力, 夏诏杰, 陈建华. 一种耦合CFD与深度学习的气固快速模拟方法[J]. 化工学报, 2023, 74(9): 3775-3785.
[5]	汪林正, 陆俞冰, 张睿智, 罗永浩. 基于分子动力学模拟的VOCs热氧化特性分析[J]. 化工学报, 2023, 74(8): 3242-3255.
[6]	邢雷, 苗春雨, 蒋明虎, 赵立新, 李新亚. 井下微型气液旋流分离器优化设计与性能分析[J]. 化工学报, 2023, 74(8): 3394-3406.
[7]	岳林静, 廖艺涵, 薛源, 李雪洁, 李玉星, 刘翠伟. 凹坑缺陷对厚孔板喉部空化流动特性影响研究[J]. 化工学报, 2023, 74(8): 3292-3308.
[8]	牛超, 沈胜强, 杨艳, 潘泊年, 李熠桥. 甲烷BOG喷射器流动过程计算与性能分析[J]. 化工学报, 2023, 74(7): 2858-2868.
[9]	何晓崐, 刘锐, 薛园, 左然. MOCVD生长AlN单晶薄膜的气相和表面化学反应综述[J]. 化工学报, 2023, 74(7): 2800-2813.
[10]	刘道银, 陈柄岐, 张祖扬, 吴琰. 颗粒聚团结构对曳力特性影响的数值模拟[J]. 化工学报, 2023, 74(6): 2351-2362.
[11]	李晨曦, 刘永峰, 张璐, 刘海峰, 宋金瓯, 何旭. O₂/CO₂氛围下正庚烷的燃烧机理研究[J]. 化工学报, 2023, 74(5): 2157-2169.
[12]	董鑫, 单永瑞, 刘易诺, 冯颖, 张建伟. 非牛顿流体气泡羽流涡特性数值模拟研究[J]. 化工学报, 2023, 74(5): 1950-1964.
[13]	李正涛, 袁志杰, 贺高红, 姜晓滨. 疏水界面上的NaCl液滴蒸发过程内环流调控机制研究[J]. 化工学报, 2023, 74(5): 1904-1913.
[14]	周艾然, 陆平, 夏建辉, 李冬勤, 郭杰, 杜明, 董立春. 氯化钛白氧化反应器结疤问题分析及数值模拟[J]. 化工学报, 2023, 74(4): 1499-1508.
[15]	李亚飞, 邓建强, 何阳. 跨临界CO₂快速膨胀过程中非平衡冷凝和闪蒸机理的数值研究[J]. 化工学报, 2022, 73(7): 2912-2923.