液体中可压缩气体射流的瞬态特性

doi:10.11949/j.issn.0438-1157.20151874

摘要/Abstract

摘要：

针对水下超声速气体射流实验装置,分别采用高速摄影对水下超声速气体射流的形态及发展过程进行了可视化观察分析,采用VOF方法建立了二维轴对称两相数值计算流模型,对实验工况进行数值模拟,得到详细的水下超声速射流流场结构。两者结合得以研究水下气体超声速射流的形态及发展过程。研究结果表明:超声速水下射流流场明显包含射流区、过渡区和羽流区3个不同特征区域,射流区内气相的胀鼓和回击现象导致了严重的振荡流模式。气液界面不稳定性引起射流局部颈缩,从而引起颈缩上游气相截面的扩张、收缩甚至断流。可观测的小幅度的颈缩导致上游的胀鼓现象;稍大幅度的颈缩导致上游的回击现象;大幅度的颈缩甚至导致射流中断,并在随后重建射流。

关键词: 气液两相流, 数值模拟, 实验验证, 可压缩气体射流, 流动振荡

Abstract:

A device of submerged supersonic gas jet is configured and a two-dimensional axis-symmetric model of two-phase flow is established via volume of fluid (VOF) method. The flow field of the submerged supersonic gas jet is experimentally visualized using a photographic technique which allows simultaneous analysis of the jet interface to investigate the behavior of gas jets injected into water ambient. The detailed internal structure of the flow field is obtained by numerical technique via finite volume method (FVM). The results show that the flow field from the nozzle exit to the far away field of downstream includes three different characteristic regions: the jet region, the transition region and the plume region. The gravity can be ignored in jet region. And the bulge and back-attack phenomena lead to the heavy oscillation flow pattern. Gas-liquid interface instabilities cause jet necking phenomena which leads expand or pinch-off of the gas jet and subsequent bulge and back-attack phenomena. A small scale of the necking results in the bulge phenomenon at upstream. A slightly larger scale of the necking causes the back-attack phenomenon. A large scale of necking even leads to the jet pinch-off phenomenon and then jet rebuilding.

Key words: gas-liquid flow, numerical simulation, experiment validation, compressible gas jet, flow oscillation

中图分类号:

O359⁺.1

王超, 施红辉, 汪剑锋. 液体中可压缩气体射流的瞬态特性[J]. 化工学报, 2016, 67(6): 2291-2299.

WANG Chao, SHI Honghui, WANG Jianfeng. Transient characteristics of compressible gas jet in liquid[J]. CIESC Journal, 2016, 67(6): 2291-2299.

参考文献 33

[1]	HOEFELE E O, BRIMACOMBE J K. Flow regimes in submerged gas injection [J]. Metallurgical Transactions B, 1979, 10B: 631-648.
[2]	MORI K, OZAWA Y, SANO M. Characterization of gas jet behavior at a submerged orifice in liquid metal [J]. Trans. ISIJ, 1982, 22: 377-384.
[3]	OZAWA Y, MORI K. Characterization of jetting observed in gas injection into liquid [J]. Trans. ISIJ, 1983, 23: 764-768.
[4]	LOTH E, FAETH G M. Structure of underexpanded round air jets submerged in water [J]. Int. J. Multiphase Flow, 1989, 15(4): 589-603.
[5]	ANDWESON J E, MARSUL P C. 向液体供气的超声相干气体射流: 1239207[P]. 1999-12-22. ANDWESON J E, MARSUL P C. A supersonic interaction gas jet for supplying gas into liquid: 1239207[P]. 1999-12-22.
[6]	刘作华, 宁伟征, 孙瑞祥, 等. 偏心空气射流双层浆搅拌反应器流场结构的分形特征 [J]. 化工学报, 2011, 62(3): 628-635 LIU Z H, NING W Z, SUN R X, et al. Fractal flow structure in eccentric air jet stirred reactor with double impeller [J]. CIESC Journal, 2011, 62(3): 628-635.
[7]	付碧华, 王亦飞, 林岚, 等. 洗涤冷却管出口处的射流深度和界面波动特性 [J]. 化工学报, 2011, 62(7): 1817-1823. FU B H, WANG Y F, LIN L, et al. Penetration depth and characteristics of interface fluctuation at quenching pipe outlet [J]. CIESC Journal, 2011, 62(7): 1817-1823.
[8]	郭天琪, 黄正梁, 王靖岱, 等.射流鼓泡反应器的混合特性 [J]. 化工学报, 2015, 66(11): 4438-4445. GUO T Q, HUANG Z L, WANG J D, et al. Mixing characteristics in jet bubbling reactor [J]. CIESC Journal, 2015, 66(11): 1817-1823.
[9]	CHEN L W, WANG G L, LU X Y. Numerical investigation of a jet from a blunt body opposing a supersonic flow [J]. J. Fluid Mech., 2011, 684: 85-110.
[10]	VUORINEN V, YU J, TIRUNAGARI S, et al. Large-eddy simulation of highly underexpanded transient gas jets [J]. Phy. Fluids, 2013, 25: 016101.
[11]	贺小艳, 马汉东, 纪楚群. 水下气体射流初期数值研究 [J]. 水动力学研究与进展(A辑), 2004, 19(2): 207-212. HE X Y, MA H D, JI C Q. Numerical simulation of gas jets in water [J]. J. Hydrodynamics, 2004, 19(2): 207-212.
[12]	TANG L S, LIU Y W, WU Z F, et al. Experimental study on characteristics of bubble growth and pressure wave propagation by supersonic gas jets under water [J]. J. Propulsion Tech., 2011, 32(3): 417-420.
[13]	王超, 汪剑锋, 施红辉. 超声速气体浸没射流的数值计算和实验 [J]. 化工学报, 2014, 65(11): 4293-4300. WANG C, WANG J F, SHI H H. Numerical simulation and experiments on submerged supersonic gas jets [J]. CIESC Journal, 2014, 65(11): 4293-4300.
[14]	AOKI T, MASUDA S. Characteristics of submerged gas jets and a new type bottom blowing tuyere[C]//WRAITH A E. Injection Phenomena in Extraction and Refining. Newcastle: University of Newcastle upon Tyne, 1982: A1-A36.
[15]	戚隆溪, 曹勇, 王柏懿.水下欠膨胀高速气体射流的实验研究 [J]. 力学学报, 2000, 32(6): 667-675. QI L X, CAO Y, WANG B Y. Experimental study of underexpanded sonic air jets in water [J]. Chinese J. Theo. Appl. Mechanics, 2000, 32(6): 667-675.
[16]	王柏懿, 戴振卿, 戚隆溪, 等. 水下超声速气体射流回击现象的实验研究 [J]. 力学学报, 2007, 39(2): 267-272. WANG B Y, DAI Z Q, QI L X, et al. Experimental study on back-attack phenomenon in underwater supersonic gas jet [J]. Chinese J. Theo. Appl. Mechanics, 2007, 39(2): 267-272.
[17]	DAI Z Q, WANG B Y, SHI H H. Experimental study on hydrodynamic behaviors of high-speed gas jets in still water [J]. Acta Mech. Sin., 2006, 22: 443-448.
[18]	王晓刚, 王超, 郭强, 等. 二维水槽中高速气体射流的震荡流流型研究 [J].浙江理工大学学报, 2009, 26(4): 613-618. WANG X G, WANG C, GUO Q, et al. Study on the flow vibration of two-dimensional supersonic gas jets in water [J]. J. Zhejiang Sci.-Tech. Univ., 2009, 26(4): 613-618.
[19]	郭强, 施红辉, 王超, 等. 准二维水下超声速垂直过膨胀射流研究 [J]. 实验流体力学, 2010, 24(3): 6-11, 18. GUO Q, SHI H H, WANG C, et al. Experimental study on the quasi-two-dimensional overexpanded gas jets in water [J]. J. Experiments in Fluid Mechanics, 2010, 24(3): 6-11, 18.
[20]	施红辉, 郭强, 王超, 等. 水下超声速气体射流膨胀和回击的关联性研究 [J]. 力学学报, 2010, 42(6): 1206-1210. SHI H H, GUO Q, WANG C, et al. Experiments on the relationship between bulging and back-attack of submerged supersonic gas jet [J]. Chinese J. Theo. Appl. Mechanics, 2010, 42(6): 1206-1210.
[21]	施红辉, 王柏懿, 戴振卿. 水下超声速气体射流的力学机制研究 [J]. 中国科学(G辑), 2010, 53(3): 527-535. SHI H H, WANG B Y, DAI Z Q. Research on the mechanics of underwater supersonic gas jets [J]. Science China: Phys. Mech. Astron., 2010, 53(3): 527-535.
[22]	SHI H H, GUO Q, WANG C. Oscillation flow induced by underwater supersonic gas jets [J]. Shock Waves, 2010, 20: 347-352.
[23]	BISIO G, RUBATTO G. Process improvements in iron and steel industry by analysis of heat and mass transfer [J]. Energy Conversion and Management, 2002, 43: 205-220.
[24]	WEILAND C, YAGLA J, VLACHOS P. Submerged gas jet interface stability [J]. XXII ICTAM, 2008, 8: 25-29.
[25]	王乐勤, 郝宗睿, 吴大转. 水下气体射流初期流场的数值研究 [J]. 工程热物理学报, 2009, 30(7): 1132-1135. WANG L Q, HAO Z R, WU D Z. Numerical simulation of initial flow of underwater gas jet [J]. J. Engin. Thermophys., 2009, 30(7): 1132-1135.
[26]	朱卫兵, 于洋, 王革, 等. 超音速欠膨胀多喷管燃气射流的数值模拟 [J]. 弹箭与制导学报, 2004, 24(3): 49-52. ZHU W B, YU Y, WANG G, et al. Numerical simulation of the supersonic and underexpanded jet flow [J]. J. Projectiles, Rochets, Missiles and Guidances, 2004, 24(3): 49-52.
[27]	甘晓松, 贾有军, 鲁传敬, 等. 水下燃气射流流场数值模拟 [J]. 固体火箭技术, 2009, 32(1): 23-26. GAN X S, JIA Y J, LU C J, et al. Research on numerical simulation of combustion gas jet under water [J]. J. Solid Rocket Tech., 2009, 32(1): 23-26.
[28]	武心壮, 邱健, 郭丹丹, 等. 蒸汽射流压力震荡主频研究 [J]. 化工进展, 2014, 33(10): 2589-2593. WU X Z, QIU J, GUO D D, et al. Research on main frequency of pressure oscillation by steam jet in water [J]. Chem. Indust. Engin. Prog., 2014, 33(10): 2589-2593.
[29]	TANG J N, WANG N F, WEI S Y. Flow structure of gaseous jets injected into water for underwater propulsion [J]. Acta Mech. Sin., 2011, 27(4): 461-472.
[30]	ANDERSON J D. Computational Fluid Dynamics: the Basic with Applications[M]. New York: McGraw-Hill, 1995: 56.
[31]	HIRT C, NICHOLS B D. Volume of fluid (VOF) method for the dynamics of free boundaries [J]. J. Comput. Phys., 1981, 39: 201-255.
[32]	CHAN L, CHIN C, SORIA J, et al. Large eddy simulation and Reynolds-averaged Navier-Stokes calculations of supersonic impinging jets at varying nozzle-to-wall distances and impinging angles [J]. Inter. J. Heat and Fluid Flow, 2014, 47: 31-41.
[33]	CHIN C, LI M, HARKIN T, et al. Investigation of the flow structures in supersonic free and impinging jet flows [J]. J. Fluids Eng., 2013, 135(3): 031202.