R290在水平光滑管内的沸腾换热

doi:10.11949/j.issn.0438-1157.20170321

摘要/Abstract

摘要：

对内径为4、6 mm水平光滑铜管内R290的沸腾换热特性进行了实验研究，分析了质流密度、热通量、饱和温度、管径对沸腾传热系数以及临界干度的影响，选择5种适用于R290的水平光滑管内沸腾换热关联式，对实验工况下R290的沸腾传热系数进行预测，并与实验值对比。结果表明，管径越小、质流密度越大，或者饱和温度越高，则沸腾传热系数越大；在干度逐渐增大的过程中，沸腾传热系数随热通量的增大先增大后减小。热通量、管径相比质流密度、饱和温度对临界干度的影响更明显，且热通量越大，临界干度越小；管径越小，临界干度越大。5种关联式中，Fang关联式的预测能力最佳。

关键词: R290, 气液两相流, 传热, 水平光滑管, 蒸发, 预测

Abstract:

The boiling heat transfer characteristics of R290 in smooth horizontal copper tubes with inner diameters of 4,6 mm was investigated experimentally. The effects of mass flux, heat flux, saturated temperature and inner diameter of tube on boiling heat transfer coefficient and critical quality were analyzed. Five boiling heat transfer correlations which are suitable to predict the boiling heat transfer coefficients of R290 in horizontal tube were chosen to obtain the calculated data compared with experimental data of boiling heat transfer coefficient. The correlation with the minimum error between calculated and experimental data among these five correlations was considered as the most suitable one for the investigation. The results showed that boiling heat transfer coefficient increased with the decrease of inner diameter of tube, with the increase of mass flux, or with the increase of saturated temperature. It increased first and then decreased with the increase of heat flux while vapor quality was increasing gradually. Heat flux and inner diameter had more evident effects on critical quality than mass flux and saturated temperature. Critical quality increased with the decrease of heat flux and inner diameter. Among the five correlations, Fang correlation showed the best capacity of prediction for the boiling heat transfer coefficients.

Key words: R290, gas-liquid two-phase flow, heat transfer, smooth horizontal tube, vaporization, prediction

中图分类号:

TK124

戴源德, 林秦汉, 邹思凯, 郭玉洁. R290在水平光滑管内的沸腾换热[J]. 化工学报, 2017, 68(9): 3420-3426.

DAI Yuande, LIN Qinhan, ZOU Sikai, GUO Yujie. Boiling heat transfer performances of R290 in smooth horizontal tubes[J]. CIESC Journal, 2017, 68(9): 3420-3426.

参考文献 30

[1]	沈希, 贾高顺. CFCs和HCFCs的替代[J]. 浙江工业大学学报, 1997, 25(2):122-126. SHEN X, JIA G S. Substitutes of CFCs and HCFCs[J]. Journal of Zhejiang University of Technology, 1997, 25(2):122-126.
[2]	VAITKUS L, DAGILIS V. Analysis of alternatives to high GWP refrigerants for eutectic refrigerating systems[J]. International Journal of Refrigeration, 2017, 76:160-169.
[3]	张明秀. 氟里昂CFC、HCFC的替代情况介绍[J]. 低温与特气, 2007, 25(3):10-12. ZHANG M X. Introduction to substitution for freon CFC, HCFC[J]. Low Temperature and Speciality Gases, 2007, 25(3):10-12.
[4]	陈伟, 祁影霞, 张华. HCFCs制冷剂替代物研究进展及性能分析[J]. 低温与超导, 2011, 39(12):41-44. CHEN W, QI Y X, ZHANG H. Research progress and performance analysis on HCFCs alternative refrigerants[J]. Cryo. & Supercond., 2011, 39(12):41-44.
[5]	LAI N A. Equations of state for HFO-1234ze(E) and their application in the study on refrigeration cycle[J]. International Journal of Refrigeration, 2014, 43(4):194-202.
[6]	CHEN J B, LI H, XI L. Performance of air cooled heat pump air conditioner with natural refrigerant R1270 and R290 to replace R22[J]. Advanced Materials Research, 2011, 374-377(9):484-487.
[7]	张战, 张舸, 王建拴, 等. R22与R290热物性对比分析及实验研究[J]. 天津城建大学学报, 2002, 8(4):258-264. ZHANG Z, ZHANG G, WANG J S, et al. Comparative analysis and experimental study of thermodynamic properties of R22 and R290[J]. Journal of Tianjin Institute of Urban Construction, 2002, 8(4):258-264.
[8]	王倩, 吴挺, 张于峰, 等. R22替代物R290的理论与试验研究[J]. 流体机械, 2004, 32(7):46-50. WANG Q, WU T, ZHANG Y F, et al. Theory and experiment research on substitute R22 with R290[J]. Fluid Machinery, 2004, 32(7):46-50.
[9]	肖庭庭, 李征涛, 董浩, 等. R290替代R22的解决方案综述及展望[J]. 流体机械, 2015, 43(3):75-82. XIAO T T, LI Z T, DONG H, et al. Overview and prospect of solution to R290 as a substitute for R22[J]. Fluid Machinery, 2015, 43(3):75-82.
[10]	郭春辉, 刘知新, 徐永恩. 泄漏管直径对R290空调器使用安全性的影响[J]. 制冷与空调, 2014, 14(12):66-68. GUO C H, LIU Z X, XU Y E. Impacts of leakage pipe's diameter on safety application of R290 air-conditioner[J]. Refrigeration and Air-conditioning, 2014, 14(12):66-68.
[11]	童明伟, 吴治娟, 董茂林. R290的可燃爆炸性试验及在制冷机组中的试用[J]. 重庆大学学报(自然科学版), 2002, 25(1):36-39. TONG M W, WU Z J, DONG M L. Experiments of R290's flammability and the application in scale refrigerant system[J]. Journal of Chongqing University (Natural Science Edition), 2002, 25(1):36-39.
[12]	肖友元, 刘畅, 郭春辉, 等. 自然工质R290在家用空调器中的应用研究[J]. 流体机械, 2009, 37(5):61-65. XIAO Y Y, LIU C, GUO C H, et al. Experimental research on refrigeration system of air-conditioner which uses natural refrigerant R290[J]. Fluid Machinery, 2009, 37(5):61-65.
[13]	何国庚, 刘璇斐. R290在小型空调器中替代R22的优势与问题及其解决措施[J]. 制冷与空调, 2008, 8(2):58-62. HE G G, LIU X F. The advantages and problems and their solutions of small air-conditioner using R290 to substitute for R22[J]. Refrigeration and Air-conditioning, 2008, 8(2):58-62.
[14]	吴治将, 彭莺, 龙建佑. R290家用空调器系统性能优化实验研究[J]. 顺德职业技术学院学报, 2013, 11(1):12-14. WU Z J, PENG Y, LONG J Y. Experimental study on performance optimization of R290 home air-conditioning system[J]. Journal of Shunde Polytechnic, 2013, 11(1):12-14.
[15]	KANDLIKAR S G, GRANDE W J. Evolution of microchannel flow passages-thermohydraulic performance and fabrication technology[J]. Heat Transfer Engineering, 2002, 24(1):3-17.
[16]	葛琪林, 柳建华, 张良, 等. R290微通道内沸腾换热实验研究[J]. 热能动力工程, 2015, 30(5):672-677. GE Q L, LIU J H, ZHANG L, et al. Experimental study of the boiling heat exchange of R290 inside a micro-channel[J]. Journal of Engineering for Thermal Energy and Power, 2015, 30(5):672-677.
[17]	葛琪林, 柳建华, 张良, 等. 预热微通道内制冷剂对沸腾传热系数影响的实验研究[J]. 热能动力工程, 2016, 31(1):42-47. GE Q L, LIU J H, ZHANG L, et al. Experimental study of the influence of the refrigerant preheated on the boiling heat exchange coefficient inside a micro-channel[J]. Journal of Engineering for Thermal Energy and Power, 2016, 31(1):42-47.
[18]	CHOI K I, PAMITRAN A S, OH J T, et al. Pressure drop and heat transfer during two-phase flow vaporization of propane in horizontal smooth minichannels[J]. International Journal of Refrigeration, 2009, 32(5):837-845.
[19]	LEE H S, YOON J I, KIM J D, et al. Evaporating heat transfer and pressure drop of hydrocarbon refrigerants in 9.52 and 12.70 mm smooth tube[J]. International Journal of Heat & Mass Transfer, 2005, 48(12):2351-2359.
[20]	LEE H S, YOON J I, KIM J D, et al. Characteristics of condensing and evaporating heat transfer using hydrocarbon refrigerants[J]. Applied Thermal Engineering, 2006, 26(10):1054-1062.
[21]	WANG S, GONG M Q, CHEN G F, et al. Two-phase heat transfer and pressure drop of propane during saturated flow boiling inside a horizontal tube[J]. International Journal of Refrigeration, 2014, 41(5):200-209.
[22]	吴晓敏, 赵然, 魏兆福, 等. CO2/丙烷混合工质水平管内流动沸腾换热特性研究[J]. 工程热物理学报, 2013, 34(4):706-709. WU X M, ZHAO R, WEI Z F, et al. Experimental studies on flow boiling heat transfer of R744/R290 mixtures in a horizontal tube[J]. Journal of Engineering Thermophysics, 2013, 34(4):706-709.
[23]	SAITOH S, DANG C, NAKAMURA Y, et al. Boiling heat transfer of HFO-1234yf flowing in a smooth small-diameter horizontal tube[J]. International Journal of Refrigeration, 2011, 34(8):1846-1853.
[24]	SAISORN S, KAEW J, WONGWISES S. Flow pattern and heat transfer characteristics of R-134a refrigerant during flow boiling in a horizontal circular mini-channel[J]. International Journal of Heat & Mass Transfer, 2010, 53(19):4023-4038.
[25]	JIGE D, SAGAWA K, INOUE N. Effect of tube diameter on boiling heat transfer and flow characteristic of refrigerant R32 in horizontal small-diameter tubes[J]. International Journal of Refrigeration, 2017, 76:206-218.
[26]	SAITOH S, DAIGUJI H, HIHARA E. Effect of tube diameter on boiling heat transfer of R-134a in horizontal small-diameter tubes[J]. International Journal of Heat & Mass Transfer, 2005, 48(23/24):4973-4984.
[27]	LI W, WU Z. A general correlation for evaporative heat transfer in micro/mini-channels[J]. International Journal of Heat & Mass Transfer, 2010, 53(9/10):1778-1787.
[28]	CHANG Y S, KIM M S, RO S T. Performance and heat transfer characteristics of hydrocarbon refrigerants in a heat pump system[J]. International Journal of Refrigeration, 2000, 23(3):232-242.
[29]	PAMITRAN A S, CHOI K I, OH J T, et al. Two-phase flow heat transfer of propane vaporization in horizontal minichannels[J]. Journal of Mechanical Science and Technology, 2009, 23(3):599-606.
[30]	FANG X, WU Q, YUAN Y. A general correlation for saturated flow boiling heat transfer in channels of various sizes and flow directions[J]. International Journal of Heat & Mass Transfer, 2017, 107:972-981.