U形弯头单元内气液两相流型及压降波动特性

doi:10.11949/j.issn.0438-1157.20171148

摘要/Abstract

摘要：

对空气-水两相流在内径16 mm、弯曲半径100 mm的横向U形弯头单元内向上流动时的流型进行了实验研究。利用流动可视化技术及其相应压降波动规律实现了流型的客观识别。总结了不同流型的压降波动特性并据此提出了定量识别流型的新方法。实验范围内发现了分层-搅拌流、塞状-泡状流、段塞-波形流、环状-波形流和环状弥散流等5种与水平直管和垂直直管不同的流型。相比标准偏差，压降波动的功率谱（PSD）分布能更好地反映U形弯头单元内不同流型的流态演变特征与动力学特性。PSD分布的偏度或峰度与气液表观流速比的结合可以定量客观地识别U形弯头单元内的流型，流型转变时的气液表观流速比为1和13。

关键词: 气液两相流, U形弯头单元, 流型, 成像, 压降波动

Abstract:

Flow regimes of air-water two-phase flow were experimentally studied in a horizontal upward U-bend unit with an inner diameter of 16 mm and a radius of curvature as 100 mm. Visualization technique on flow observation and analysis of corresponding pressure drop fluctuations were used to objectively identify flow regimes. The fluctuation characteristics of pressure drops at various flow regimes were summarized and a new method for recognizing flow regimes quantitatively was proposed. A total of five flow regimes, i.e., stratified-churn, plug-bubble, slug-wavy, annular-wavy and annular-dispersed flows were identified within the scope of experiment. They are different from flow regimes in a horizontal or vertical straight tube. Compared to standard deviation of pressure drop signals, power spectral density (PSD) distributions can better reflect evolution characteristics and dynamic properties of different flow regimes in the U-bend unit. Combination of skewness or kurtosis of PSD distributions and ratio of gas-liquid superficial velocities could objectively and quantitatively identify flow regimes in the U-bend unit. Flow regime transition occurs at ratios of gas-liquid superficial velocities as 1 and 13.

Key words: gas-liquid flow, U-bend unit, flow regimes, imaging, pressure drop fluctuations

中图分类号:

O359

马晓旭, 田茂诚. U形弯头单元内气液两相流型及压降波动特性[J]. 化工学报, 2018, 69(5): 1972-1981.

MA Xiaoxu, TIAN Maocheng. Flow regimes of gas-liquid two phase flow in a U-bend unit and characteristics of pressure drop fluctuations[J]. CIESC Journal, 2018, 69(5): 1972-1981.

参考文献 36

[1]	WOJTAN L, URSENBACHER T, THOME J R. Investigation of flow boiling in horizontal tubes(Ⅱ):Development of a new heat transfer model for stratified-wavy, dry out and mist flow regimes[J]. International Journal of Heat and Mass Transfer, 2005, 48:2970-2985.
[2]	QUIBEN J M, THOME J R. Flow pattern based two-phase frictional pressure drop model for horizontal tubes(Ⅱ):New phenomenological model[J]. International Journal of Heat Fluid Flow, 2007, 28:1060-1072.
[3]	张井志, 李蔚. 水平圆形与方形微小通道内R134a冷凝数值模拟[J]. 化工学报, 2016, 67(5):1748-1754. ZHANG J Z, LI W. Numerical simulation of condensation in horizontal circular and square minichannels using R134a[J]. CIESC Journal, 2016, 67(5):1748-1754.
[4]	PETTIGREW M J, KNOWLES G D. Some aspects of heat exchanger tube damping in two-phase mixture[J]. Journal of Fluids and Structures, 1997, 11:929-945.
[5]	马晓旭, 田茂诚, 张冠敏, 等. 水平管内气液两相流诱导振动的数值研究[J]. 振动与冲击, 2016, 35(16):204-210. MA X X, TIAN M C, ZHANG G M, et al. Numerical investigation on gas liquid two phase flow induced vibration in a horizontal tube[J]. Journal of Vibration and Shock, 2016, 35(16):204-210.
[6]	黄素逸, 蒲十周. 汽液两相流中流体诱导振动的研究[J]. 化工学报, 1992, 43(6):760-763. HUANG S Y, PU S Z. Flow-induced vibration in gas-liquid flow[J]. Journal of Chemical Industry and Engineering (China), 1992, 43(6):760-763.
[7]	MANDHANE J M, GREGORY G A, AZIZ K. A flow pattern map for gas-liquid flow in horizontal pipes[J]. International Journal of Multiphase Flow, 1974, 1(4):537-553.
[8]	WEISMAN J, DUNCAN D, GIBSON J, et al. Effects of fluid properties and the pipe diameter on two-phase flow pattern in horizontal lines[J]. International Journal of Multiphase Flow, 1979, 5(6):437-462.
[9]	TAITEL Y, BORNEA D, DUKLER A E. Modelling flow pattern transitions for steady upward gas-liquid flow in vertical tubes[J]. AIChE Journal, 1980, 26(1):345-354.
[10]	BARNEA D, SHOHAM O, TAITEL Y, et al. Flow pattern transition for gas-liquid flow in horizontal and inclined pipes:comparison of experimental data with theory[J]. International Journal of Multiphase Flow, 1980, 6(3):217-225.
[11]	曹夏昕, 阎昌琪. 倾斜管内气液两相流流型的实验研究[J]. 核动力工程, 2005, 26(6):572-575. CAO X X, YAN C Q. Experimental study of gas-liquid flow pattern in inclined pipe[J]. Nuclear Power Engineering, 2005, 26(6):572-575.
[12]	USUI K, AOKI S, INOUE A. Flow behavior and pressure drop of two-phase flow through C-shaped bend in vertical plane(Ⅰ):Upward flow[J]. Journal of Nuclear Science and Technology, 1980, 17:875-887.
[13]	USUI K, AOKI S, INOUE A. Flow behavior and pressure drop of two-phase flow through C-shaped bend in vertical plane(Ⅱ):Downward flow[J]. Journal of Nuclear Science and Technology, 1981, 18:179-190.
[14]	WANG C C, CHEN I Y, YANG Y W, et al. Two-phase flow pattern in small diameter tubes with the presence of horizontal return bend[J]. International Journal of Heat and Mass Transfer, 2003, 46:2975-2981.
[15]	WANG C C, CHEN I Y, LIN Y T, et al. A visual observation of the air-water two-phase flow in small diameter tubes subject to the influence of vertical return bends[J]. Chemical Engineering Research and Design, 2008, 86:1223-1235.
[16]	DONALDSON A A, KIRPALANI D M, MACCHI A. Curvature induced flow pattern transitions in serpentine mini-channels[J]. International Journal of Multiphase Flow, 2011, 37(5):429-439.
[17]	PIETRZAK M. Flow patterns and gas fractions of air-oil and air-water flow in pipe bends[J]. Chemical Engineering Research and Design, 2014, 92:1647-1658.
[18]	PIETRZAK M. Flow patterns and volume fractions of phases during liquid-liquid two-phase flow in pipe bends[J]. Experimental Thermal and Fluid Science, 2014, 54:247-258.
[19]	SHARMA M, RAVI P, GHOSH S, et al. Hydrodynamics of lube oil-water flow through 180° return bends[J]. Chemical Engineering Science, 2011, 66:4468-4476.
[20]	DA SILVA LIMA R J, THOME J R. Two-phase flow patterns in U-bends and their contiguous straight tubes for different orientations, tube and bend diameters[J]. International Journal of Refrigeration, 2012, 35:1439-1454.
[21]	WU H L, PENG X F, YE P, et al. Simulation of refrigerant flow boiling in serpentine tubes[J]. International Journal of Heat and Mass Transfer, 2007, 50(5):1186-1195.
[22]	YANG Z, PENG X, YE P. Numerical and experimental investigation of two phase flow during boiling in a coiled tube[J]. International Journal of Heat and Mass Transfer, 2008, 51(5):1003-1016.
[23]	MOZAFARI M, AKHANVAN-BEHABADI M A, QOBADIAREAEE H, et al. Experimental study on condensation flow patterns inside inclined U-bend tubes[J]. Experimental Thermal and Fluid Science, 2015, 68:276-287.
[24]	陈听宽, 杨志华, 王芊. 垂直U型管两相流流型和传热研究(Ⅰ):U型管弯管段两相流流型转变[J]. 化工学报, 1985, 36(4):426-434. CHEN T K, YANG Z H, WANG Q. Two-phase flow and heat transfer in vertical U-shaped tubes (Ⅰ):Flow pattern transitions in the bend[J]. Journal of Chemical Industry and Engineering (China), 1985, 36(4):426-434.
[25]	王芊, 陈听宽. 不同位置放置的U-型管内气液两相流流型转换的研究[J]. 西安交通大学学报, 1985, 19(6):105-116. WANG Q, CHEN T K. An investigation on flow pattern transitions of gas-liquid two-phase flows in U-shaped bends of various arrangements[J]. Journal of Xi'an Jiaotong University, 1985, 19(6):105-116.
[26]	李晓平, 宫敬, 沈建宏. 立管严重段塞流控制方法实验研究[J]. 中国海上油气, 2005, 17(6):416-420. LI X P, GONG J, SHEN J H. Experimental study on the control method of severe slug flow in riser[J]. China Offshore Oil and Gas, 2005, 17(6):416-420.
[27]	邓冬. 回转弯道对竖直U型管内液氮流动与传热的影响研究[D]. 上海:上海交通大学, 2014. DENG D. The influence of return bend on the liquid nitrogen flow and heat transfer in U-tubes[D]. Shanghai:Shanghai Jiao Tong University, 2014.
[28]	鹿院卫, 钱焕群, 孙贺东, 等. 倒U形管内油气水三相流动流型分布的研究[J]. 油气储运, 2004, 23(1):29-33. LU Y W, QIAN H Q, SUN H D, et al. The experimental study on the flow patterns of oil-gas-water three phase flow in inverse U tube[J]. Oil & Gas Storage and Transportation, 2004, 23(1):29-33.
[29]	屈健, 吴慧英, 唐慧敏. 微小型振荡热管的流动可视化实验.[J]. 航空动力学报, 2009, 24(4):766-771. QU J, WU H Y, TANG H M. Flow visualization of micro/mini pulsating heat pipes[J]. Journal of Aerospace Power, 2009, 24(4):766-771.
[30]	DE KERPEL K, AMEEL B, HUISSEUNE H, et al. Two-phase flow behaviour and pressure drop of R134a in a smooth hairpin[J]. International Journal of Heat and Mass Transfer, 2012, 55(4):1179-1188.
[31]	PADILLA M, REVELLIN R, WALLET J, et al. Flow regime visualization and pressure drops of HFO-1234yf, R-134a and R-410A during downward two phase flow in vertical return bends[J]. International Journal of Heat Fluid Flow, 2013, 40:116-134.
[32]	DE OLIVEIRA P M, STRLE E, BARBOSA JR J R. Developing air-water flow downstream of a vertical 180? return bend[J]. International Journal of Multiphase Flow, 2014, 67:32-41.
[33]	DE KERPEL K, DE SCHAMPHELEIRE S, DE KEULENAER T, et al. Two-phase frictional pressure drop and flow behaviour up and downstream of a sharp return bend[J]. Applied Thermal Engineering, 2016, 93:824-838.
[34]	孙斌, 周云龙, 陆军. 水平管气液两相流流型压差波动的PSD特征[J]. 仪器仪表学报, 2003, 24(4):377-378. SUN B, ZHOU Y L, LU J. PSD characteristics of the differential pressure fluctuation of gas-liquid two-phase flow in a horizontal pipe[J]. Chinese Journal of Scientific Instrument, 2003, 24(4):377-378.
[35]	白博峰, 郭烈锦, 赵亮. 垂直上升管汽液两相流型的压差波动特征识别[J]. 化工学报, 1999, 50(6):799-805. BAI B F, GUO L J, ZHAO L. Identification of flow regimes in vertical upward steam-water two phase flow using differential pressure fluctuations[J]. Journal of Chemical Industry and Engineering (China), 1999, 50(6):799-805.
[36]	白博峰, 郭烈锦, 陈学俊. 空气-水两相流压差波动研究[J]. 中国电机工程学报, 2002, 22(3):22-26. BAI B F, GUO L J, CHEN X J. Fluctuating differential pressure for air-water two-phase flow[J]. Proceedings of the CSEE, 2002, 22(3):22-26.