倾斜角对液体燃料润湿条件下砂床表面火蔓延的影响

doi:10.3969/j.issn.0438-1157.2013.11.019

化工学报 ›› 2013, Vol. 64 ›› Issue (11): 4025-4030.DOI: 10.3969/j.issn.0438-1157.2013.11.019

倾斜角对液体燃料润湿条件下砂床表面火蔓延的影响

姚瑶^1,2, 郭进¹, 谢烽¹, 胡坤伦¹

1. 安徽理工大学化学工程学院, 安徽淮南 232001;
2. 91291部队, 海南三亚 572011

收稿日期:2013-05-09 修回日期:2013-07-15 出版日期:2013-11-05 发布日期:2013-11-05
通讯作者: 胡坤伦
作者简介:姚瑶(1988-),男,硕士研究生。
基金资助:
火灾科学国家重点实验室开放基金项目(HZ2012-KF06);国家自然科学基金项目(51276177);安徽理工大学博士基金项目(11011)。

Effect of inclination angle on flame spread over sand bed wetted with liquid fuel

YAO Yao^1,2, GUO Jin¹, XIE Feng¹, HU Kunlun¹

1. School of Chemical Engineering, Anhui University of Science and Technology, Huainan 232001, Anhui, China;
2. 91291 Troops, Sanya 572011, Hainan, China

Received:2013-05-09 Revised:2013-07-15 Online:2013-11-05 Published:2013-11-05
Supported by:
supported by the Open Fund of the State Key Laboratory of Fire Science of China(HZ2012-KF06),the National Natural Science Foundation of China(51276177)and the Research Fund for the Doctoral Program of Anhui University of Science and Technology in China(11011).

摘要/Abstract

摘要： 利用纹影系统、CCD相机以及K型热电偶对正丁醇润湿条件下不同角度的砂床表面火蔓延特性进行了研究,分析了不同砂床表面倾角对火蔓延的影响机理。研究结果表明:正丁醇润湿条件下变角度砂床表面火焰是稳定匀速蔓延的,向上蔓延时,火焰的高度、黄色发光区以及蔓延速度随着倾角的增加而增大;向下蔓延时,火焰的高度、黄色发光区以及蔓延速度随着倾角的增加而减小;蔓延火焰前方存在预热区,且预热区随表面倾角的增大而增大:砂层内部存在热边界层,且砂床热边界层厚度随表面倾角的增加而减小。得到的火蔓延特性及燃烧机理为此类液体燃料的储存、使用以及环境保护提供了一定的科学依据。

关键词: 火蔓延, 多孔介质, 燃料, 表面倾角, 传热, 温度分布

Abstract: In order to prevent fire accident caused by leakage of liquid fuels in the process of storing,using and transporting,a schlieren system,CCD cameras and K-thermocouples were used to study the characteristics of flame spreading over sand bed wetted with 1-butanol.The effect of surface inclination angle of sand bed on the mechanism of flame spread was analyzed.The results indicate that the flame spreads on the sand bed at constant speed.When the flame spreads upward,its height,yellow luminous zone and spread rate increase with surface angle; when the flame spreads downward,they all decrease as the surface angle increases.As the surface inclination angle increases,the preheating zone magnifies,which is in front of the flame,and the thickness of thermal boundary layer decreases,which is in the sand layer.The investigation on flame spread characteristics and burning mechanism provide some guideline for fire suppression and environmental protection.

Key words: flame spread, porous media, fuel, surface inclination angle, heat transfer, temperature distribution

中图分类号:

姚瑶, 郭进, 谢烽, 胡坤伦. 倾斜角对液体燃料润湿条件下砂床表面火蔓延的影响[J]. 化工学报, 2013, 64(11): 4025-4030.

YAO Yao, GUO Jin, XIE Feng, HU Kunlun. Effect of inclination angle on flame spread over sand bed wetted with liquid fuel[J]. CIESC Journal, 2013, 64(11): 4025-4030.

参考文献 20

[1]	Takeno K,Hirano T.Fire spread over porous solids soaked with a combustible liquid[J].Proc. Combust. Inst.,1986,21:75-81
[2]	Takeno K,Hirano T.Behavior of combustible liquid soaked in porous beds during flame spread[J].Proc. Combust. Inst.,1988,22:1223-1230
[3]	Suzuki T,Kawamata M,Hirano T.Fuel spread sand in an opposed air stream[J].Fire Safety Science,1989,2:199-208
[4]	Kumana K,Suzuki M,Dobashi R,Hirano T.Effects of liquid distribution on flame spread over porous solid soaked with combustible liquid[J].Fire Safety Science,2000,6:637-648
[5]	Suzuki T,Masaaki K,Kinya M,Hirano T.Behavior of the reverse flow in front of the leading flame edge spreading over fuel soaked in an air stream[J].Fire Safety Science,1991,3:227-236
[6]	Chao C Y H,Wang J H,Kong W J.Effect of fuel properties on the combustion behavior of different types of porous beds soaked with combustible liquid[J].International Journal of Heat and Mass Transfer,2004,47(24):5201-52l0
[7]	Ishida H.Flame spread over ground soaked highly volatile liquid fuel[J].Fire Safty Journal,1988,13:115-123
[8]	Ishida H.Initiation of fire growth on fuel-soaked ground[J].Fire Safty Journal,1992,18(3):213-230
[9]	Ishida H,Sato K,Hokari K.Flame spread over fuel-spilled and/or snow-covered asphalt road[J].Journal of Fire Science,1996,14(1):50-66
[10]	Ishida H,Kenmotsu Y.Flame spread in opposed flow along the ground soaked with high-volatile liquid fuel[J].Journal of Fire Sciences,2009,27(3):285-297
[11]	Ishida H.Flame tip propagation with assisted flow along fuel-soaked ground[J].Journal of Fire Sciences,2011,29(2):99-110
[12]	Ishida H.Flame tip traveling in boundary layer flow with flammable mixture along fuel-soaked ground[J].Journal of Fire Sciences,2012,30(1):17-27
[13]	Chen Xiaoting(陈晓婷),Kong Wenjun(孔文俊),Wang Baorui(王宝瑞).Effect of external heat flux on combustion behaviors of porous beds soaked with liquid fuels[J].Journal of Engineering Thermophysics(工程热物理学报),2007,28(5):871-874
[14]	Kong Wenjun(孔文俊),Liu Xingyu(刘星宇),Wang Baorui(王宝瑞).Combined effects of material and fuel properties on burning characteristics of liquid fuels soaked in porous beds[J].Journal of Engineering Thermophysics(工程热物理学报),2007,28(1):149-152
[15]	Ishida H.Flame spread over fuel-soaked ground[J].Fire Safty Journal,1986,10(3):163-171
[16]	Ross H D.Ignition of and flame spread over laboratory-scale pools of pure liquid fuels[J].Progress in Energy and Combustion Science,1994,20(1):17-63
[17]	Zanganeh J,Moghtaderi B.Experimental study of temperature distribution and flame spread over an inert porous bed wetted with liquid fuel[J].International Journal of Emerging Multidisciplinary Fluid Sciences,2010,2:1-14
[18]	Zanganeh J,Moghtaderi B.Flame spread over porous sand and beds wetted with propenol[J].Fire and Materials,2011,35:61-70
[19]	Yin Yi(尹艺),Huang Xinjie(黄新杰),Zhang Ying(张英),et al.Characteristic of flame spread over porous solids soaked with hardly volatile combustible liquid[J].Journal of Combustion Science and Technology(燃烧科学与技术),2011,17(6):546-550
[20]	Yin Yi(尹艺).Study on the flame spread over porous solids soaked with a combustible liquid[D].Hefei:University of Science and Technology of China,2011

倾斜角对液体燃料润湿条件下砂床表面火蔓延的影响

Effect of inclination angle on flame spread over sand bed wetted with liquid fuel

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 15

编辑推荐

Metrics

本文评价

[1]	张双星, 刘舫辰, 张义飞, 杜文静. R-134a脉动热管相变蓄放热实验研究[J]. 化工学报, 2023, 74(S1): 165-171.
[2]	张义飞, 刘舫辰, 张双星, 杜文静. 超临界二氧化碳用印刷电路板式换热器性能分析[J]. 化工学报, 2023, 74(S1): 183-190.
[3]	陈爱强, 代艳奇, 刘悦, 刘斌, 吴翰铭. 基板温度对HFE7100液滴蒸发过程的影响研究[J]. 化工学报, 2023, 74(S1): 191-197.
[4]	刘明栖, 吴延鹏. 导光管直径和长度对传热影响的模拟分析[J]. 化工学报, 2023, 74(S1): 206-212.
[5]	王志国, 薛孟, 董芋双, 张田震, 秦晓凯, 韩强. 基于裂隙粗糙性表征方法的地热岩体热流耦合数值模拟与分析[J]. 化工学报, 2023, 74(S1): 223-234.
[6]	晁京伟, 许嘉兴, 李廷贤. 基于无管束蒸发换热强化策略的吸附热池的供热性能研究[J]. 化工学报, 2023, 74(S1): 302-310.
[7]	程成, 段钟弟, 孙浩然, 胡海涛, 薛鸿祥. 表面微结构对析晶沉积特性影响的格子Boltzmann模拟[J]. 化工学报, 2023, 74(S1): 74-86.
[8]	李艺彤, 郭航, 陈浩, 叶芳. 催化剂非均匀分布的质子交换膜燃料电池操作条件研究[J]. 化工学报, 2023, 74(9): 3831-3840.
[9]	王玉兵, 李杰, 詹宏波, 朱光亚, 张大林. R134a在菱形离散肋微小通道内的流动沸腾换热实验研究[J]. 化工学报, 2023, 74(9): 3797-3806.
[10]	陈哲文, 魏俊杰, 张玉明. 超临界水煤气化耦合SOFC发电系统集成及其能量转化机制[J]. 化工学报, 2023, 74(9): 3888-3902.
[11]	齐聪, 丁子, 余杰, 汤茂清, 梁林. 基于选择吸收纳米薄膜的太阳能温差发电特性研究[J]. 化工学报, 2023, 74(9): 3921-3930.
[12]	李科, 文键, 忻碧平. 耦合蒸气冷却屏的真空多层绝热结构对液氢储罐自增压过程的影响机制研究[J]. 化工学报, 2023, 74(9): 3786-3796.
[13]	陈天华, 刘兆轩, 韩群, 张程宾, 李文明. 喷雾冷却换热强化研究进展及影响因素[J]. 化工学报, 2023, 74(8): 3149-3170.
[14]	杨越, 张丹, 郑巨淦, 涂茂萍, 杨庆忠. NaCl水溶液喷射闪蒸-掺混蒸发的实验研究[J]. 化工学报, 2023, 74(8): 3279-3291.
[15]	洪瑞, 袁宝强, 杜文静. 垂直上升管内超临界二氧化碳传热恶化机理分析[J]. 化工学报, 2023, 74(8): 3309-3319.