AC/X-G吸附剂的制备及CH4/N2吸附分离性能

doi:10.11949/j.issn.0438-1157.20151606

化工学报 ›› 2016, Vol. 67 ›› Issue (6): 2386-2392.DOI: 10.11949/j.issn.0438-1157.20151606

AC/X-G吸附剂的制备及CH₄/N₂吸附分离性能

张冬梅¹, 程文萍¹, 张明胜¹, 崔杏雨², 马静红², 李瑞丰^1,2

1. 太原理工大学化学化工学院, 山西太原 030024;
2. 太原理工大学精细化工研究所, 山西太原 030024

收稿日期:2015-10-23 修回日期:2016-03-03 出版日期:2016-06-05 发布日期:2016-06-05
通讯作者: 程文萍
基金资助:
国家自然科学基金项目(51204120);山西省青年科技研究基金项目(2014021014-1);山西省自然科学基金项目(2012011005-6);山西省煤基重点科技攻关项目(FT201402-03)。

Preparation of AC/X-G adsorbent and CH₄/N₂ adsorption separation performance

ZHANG Dongmei¹, CHENG Wenping¹, ZHANG Mingsheng¹, CUI Xingyu², MA Jinghong², LI Ruifeng^1,2

1. College of Chemistry and Chemical Engineering, Taiyuan University of Technology, Taiyuan 030024, Shanxi, China;
2. Institute of Special Chemicals, Taiyuan University of Technology, Taiyuan 030024, Shanxi, China

Received:2015-10-23 Revised:2016-03-03 Online:2016-06-05 Published:2016-06-05
Supported by:
supported by the National Natural Science Foundation of China (51204120), the Natural Science Foundation of Shanxi Province (2014021014-1, 2012011005-6) and the Key Scientific and Technological Project of Coal Fund of Shanxi Province (FT201402-03).

摘要/Abstract

摘要：

采用浓度为0.2g·ml^-1的葡萄糖溶液对13X沸石/活性炭复合材料(AC/X)进行碳沉积,研究沉积次数对复合吸附剂(AC/X-G)孔结构、表面性质和CH₄/N₂吸附分离性能的影响。通过X射线衍射,77K下的N₂吸附/脱附,扫描电镜,CO₂-TPD以及红外光谱表征样品的晶型、孔结构和表面性质,在298K、100kPa下对其CH₄和N₂吸附等温线进行测定,并将吸附结果与文献中碳材料和13X沸石的吸附性能进行比较。结果表明:随着沉积次数的增加,AC/X-G吸附剂中X型沸石的相对含量降低,微孔比表面积和微孔体积减少。AC/X-G的表面被碳膜覆盖,碱量降低,但出现强碱位和含氧基团C-O键。AC/X-G的CH₄和N₂吸附量下降,但吸附分离系数提高,沉积3次的样品AC/X-G-3的CH₄/N₂吸附分离系数达到3.0,表面的含氧基团有利于提高复合材料的CH₄/N₂吸附分离性能。

关键词: 吸附剂, 葡萄糖, 碳沉积, 吸附, 分离

Abstract:

The 13X/activated carbon composite was treated by 0.2 g·ml^-1 glucose solution for carbon deposition. The effect of deposition times on the pore structure, surface properties and separation performance of CH₄/N₂ were studied. The crystalline, pore structure and surface properties of the samples were investigated by X-ray diffraction (XRD), N₂ adsorption-desorption isotherms at 77 K, scanning electron microscopy (SEM), CO₂-TPD and Fourier transform infrared spectrum (FT-IR). The adsorption isotherms of CH₄ and N₂ were tested at 298 K and 100 kPa,and compared with the adsorption separation properties of carbon materials and 13X zeolite reported in the literatures. The experimental results showed that the relative content of X zeolite, the micropore surface area and the micropore volume of AC/X-G were gradually decreased with the increase of deposition times. The surface of samples was covered by carbon membrane, which led to decrease of the alkaline functional groups but increase of containing C-O groups. The adsorption capacities of CH₄ and N₂ decreased, while the adsorption separation coefficient was improved. After third deposition, the adsorption separation coefficient of CH₄/N₂ reached 3.0. The oxygen-containing functional groups on the surface of AC/X-G were beneficial to improve the separation performance of CH₄/N₂.

Key words: adsorbent, glucose, carbon deposition, adsorption, separation

中图分类号:

TQ424

张冬梅, 程文萍, 张明胜, 崔杏雨, 马静红, 李瑞丰. AC/X-G吸附剂的制备及CH₄/N₂吸附分离性能[J]. 化工学报, 2016, 67(6): 2386-2392.

ZHANG Dongmei, CHENG Wenping, ZHANG Mingsheng, CUI Xingyu, MA Jinghong, LI Ruifeng. Preparation of AC/X-G adsorbent and CH₄/N₂ adsorption separation performance[J]. CIESC Journal, 2016, 67(6): 2386-2392.

参考文献 26

[1]	YANG H W, YIN C B, JIANG B, et al. Optimization and analysis of a VPSA process for N2/CH4 separation [J]. Separation and Purification Technology, 2014, 134: 232-240.
[2]	LOKHANDWALA K A, PINNAU I, HE Z J, et al. Membrane separation of nitrogen from natural gas: a case study from membrane synthesis to commercial deployment [J]. Journal of Membrane Science, 2010, 346(2): 270-279.
[3]	BUONOMENNA M G, GOLEMME G, TONE C M, et al. Nanostructured poly(styrene-b-butadiene-b-styrene) (SBS) membranes for the separation of nitrogen from natural gas [J]. Advanced Functional Materials, 2012, 22(8): 1759-1767.
[4]	阮雪华, 贺高红, 肖武, 等. 生物甲烷膜分离提纯系统的设计与优化[J]. 化工学报, 2014, 65(5): 1688-1695. RUAN X H, HE G H, XIAO W, et al. Design and optimization of membrane-based system for bio-methane purification [J]. CIESC Journal, 2014, 65(5): 1688-1695.
[5]	ZHONG D L, LU Y Y, SUN D J, et al. Performance evaluation of methane separation from coal mine gas by gas hydrate formation in a stirred reactor and in a fixed bed of silica sand [J]. Fuel, 2015, 143: 568-594.
[6]	范庆虎, 李红艳, 尹全森, 等. 低浓度煤层气液化技术及其应用[J]. 天然气工业, 2008, 28(3): 117-120. FAN Q H, LI H Y, YIN Q S, et al. Liquefaction technology on low-concentration CBM and its application [J]. Natur. Gas Ind., 2008, 28(3): 117-120.
[7]	BRIAN R S. Process for removing nitrogen from natural gas: US 4352685 [P]. 1982-10-05.
[8]	FRIESEN D T, BABCOCK W C, EDLUND D J, et al. Liquid of absorbent solutions for separating nitrogen from natural gas: US 6136222 [P]. 2000-10-24.
[9]	WARMUZI?SKI K, SODZAWICZNY W. Effect of adsorption pressure on methane purity during PSA separations of CH4/N2 mixtures [J]. Chemical Engineering and Processing, 1999, 38: 55-60.
[10]	GU M, ZHANG B, QI Z D, et al. Effects of pore structure of granular activated carbons on CH4 enrichment from CH4/N2 by vacuum pressure swing adsorption [J]. Separation and Purification Technology, 2015, 146: 213-218.
[11]	MAROTO-VALER M M, ZHANG Y Z, GRANITE E J, et al. Effect of porous structure and surface functionality on the mercury capacity of a fly ash carbon and its activated sample [J]. Fuel, 2005, 84(1): 105-108.
[12]	刘立恒, 辜敏, 鲜学福. 孔结构和表面化学性质对活性炭吸附性能的影响[J]. 环境工程学报, 2012, 6(4): 1299-1304. LIU L H, GU M, XIAN X F. Effect of pore structure and surface chemical properties on adsorption properties of activated carbons [J]. Chinese Journal of Environmental Engineering, 2012, 6(4): 1299-1304.
[13]	BAKSH M S A, YANG R T, CHUNG D D L. Composite sorbents by chemical vapor deposition on activated carbon [J]. Carbon, 1989, 27(6): 931-934.
[14]	杨明莉. 煤层甲烷变压吸附浓缩的研究[D]. 重庆: 重庆大学, 2004. YANG M L. Study on concentration of methane in coal bed by pressure swing adsorption [D]. Chongqing: Chongqing University, 2004.
[15]	WAN DAUDA W M A, AHMAD M A, AROUA M K. Carbon molecular sieves from palm shell: effect of the benzene deposition times on gas separation properties [J]. Separation and Purification Technology, 2007, 57: 289-293.
[16]	张香兰, 周玮, 张英, 等. 甲烷沉积法对甲烷/氮气分离炭分子筛性能的研究[J]. 化学工业与工程, 2011, 28(5): 20-25. ZHANG X L, ZHOU W, ZHANG Y, et al. Effect of CH4 sedimentary conditions on performance of carbon molecular sieve in methane/nitrogen separation process [J]. Chemical Industry and Engineering, 2011, 28(5): 20-25.
[17]	VILLAR-RODIL S, NAVARRETE R, DENOYEL R, et al. Carbon molecular sieve cloths prepared by chemical vapour deposition of methane for separation of gas mixtures [J]. Microporous and Mesoporous Materials, 2005, 77(2): 109-118.
[18]	LI Z L, CUI X Y, MA J H, et al. Preparation of granular X-type zeolite/activated carbon composite from elutrilithe by adding pitch and solid SiO2 [J]. Materials Chemistry and Physics, 2014, 147(3): 1003-1008.
[19]	薛彩龙, 程文萍, 崔杏雨, 等. X沸石/活性炭孔结构对CH4/N2分离的影响[J]. 煤炭转化, 2015, 38(3): 92-96. XUE C L, CHENG W P, CUI X Y, et al. Effect of pore structure of zeolite X/activated carbon composite on CH4/N2 separation [J]. Coal Conversion, 2015, 38(3): 92-96.
[20]	张薄, 辜敏, 鲜学福. 碳分子筛的结构和表面性质对其吸附分离CH4/N2和CO2/N2的影响[J]. 功能材料, 2012, 43(20): 2858-2862. ZHANG B, GU M, XIAN X F. Effects of structure and surface property on adsorptive separation of carbon molecular sieve for CH4/N2 and CO2/N2 [J]. Functional Materials, 2012, 20(43): 2858-2862.
[21]	刘立恒, 辜敏, 鲜学福, 等. 黏结剂对颗粒活性炭 PSA 分离CH4/N2性能的影响[J]. 材料研究学报, 2011, 25(3): 249-254. LIU L H, GU M, XIAN X F, et al. Effect of binders on CH4/N2 performances of granular activated carbons by pressure swing adsorption [J]. Chinese Journal of Materials Research, 2011, 25(3): 249-254.
[22]	QUINN D F. Supercritical adsorption of ‘permanent’ gases under corresponding states on various carbons [J]. Carbon, 2002, 40(15): 2767-2773.
[23]	OLAJOSSY A, GAWDZIK A, BUDNER Z, et al. Methane separation from coal mine methane gas by vacuum pressure swing adsorption [J]. Chemical Engineering Research and Design, 2003, 81(4): 474-482.
[24]	张进华, 车永芳, 李兰廷, 等. 煤基碳分子筛的制备及CH4/N2分离性能研究[J]. 洁净煤技术, 2011, 17(2): 64-67. ZHANG J H, CHE Y F, LI L T, et al. Preparation of coal-based carbon molecular sieve and its application effects in CH4/N2 separation [J]. Clean Coal Technology, 2011, 17(2): 64-67.
[25]	KLUSON P, SCAIFE S, QUIRKE N. The design of microporous graphitic adsorbents for selective separation of gases [J]. Separation and Purification Technology, 2000, 20(1): 15-24.
[26]	MOFARAHI M, BAKHTYARI A. Experimental investigation and thermodynamic modeling of CH4/N2 adsorption on zeolite 13X [J]. Journal of Chemical & Engineering Data, 2015, 60(3): 683-696.

AC/X-G吸附剂的制备及CH₄/N₂吸附分离性能

Preparation of AC/X-G adsorbent and CH₄/N₂ adsorption separation performance

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 26

相关文章 15

编辑推荐

Metrics

本文评价

[1]	晁京伟, 许嘉兴, 李廷贤. 基于无管束蒸发换热强化策略的吸附热池的供热性能研究[J]. 化工学报, 2023, 74(S1): 302-310.
[2]	赵亚欣, 张雪芹, 王荣柱, 孙国, 姚善泾, 林东强. 流穿模式离子交换层析去除单抗聚集体[J]. 化工学报, 2023, 74(9): 3879-3887.
[3]	杨学金, 杨金涛, 宁平, 王访, 宋晓双, 贾丽娟, 冯嘉予. 剧毒气体PH₃的干法净化技术研究进展[J]. 化工学报, 2023, 74(9): 3742-3755.
[4]	刘爽, 张霖宙, 许志明, 赵锁奇. 渣油及其组分黏度的分子层次组成关联研究[J]. 化工学报, 2023, 74(8): 3226-3241.
[5]	张佳怡, 何佳莉, 谢江鹏, 王健, 赵鹬, 张栋强. 渗透汽化技术用于锂电池生产中N-甲基吡咯烷酮回收的研究进展[J]. 化工学报, 2023, 74(8): 3203-3215.
[6]	盛冰纯, 于建国, 林森. 铝基锂吸附剂分离高钠型地下卤水锂资源过程研究[J]. 化工学报, 2023, 74(8): 3375-3385.
[7]	张瑞航, 曹潘, 杨锋, 李昆, 肖朋, 邓春, 刘蓓, 孙长宇, 陈光进. ZIF-8纳米流体天然气乙烷回收工艺的产品纯度关键影响因素分析[J]. 化工学报, 2023, 74(8): 3386-3393.
[8]	高燕, 伍鹏, 尚超, 胡泽君, 陈晓东. 基于双流体喷嘴的磁性琼脂糖微球的制备及其蛋白吸附性能探究[J]. 化工学报, 2023, 74(8): 3457-3471.
[9]	邢雷, 苗春雨, 蒋明虎, 赵立新, 李新亚. 井下微型气液旋流分离器优化设计与性能分析[J]. 化工学报, 2023, 74(8): 3394-3406.
[10]	陈吉, 洪泽, 雷昭, 凌强, 赵志刚, 彭陈辉, 崔平. 基于分子动力学的焦炭溶损反应及其机理研究[J]. 化工学报, 2023, 74(7): 2935-2946.
[11]	张缘良, 栾昕奇, 苏伟格, 李畅浩, 赵钟兴, 周利琴, 陈健民, 黄艳, 赵祯霞. 离子液体复合萃取剂选择性萃取尼古丁的研究及DFT计算[J]. 化工学报, 2023, 74(7): 2947-2956.
[12]	高金明, 郭玉娇, 鄂承林, 卢春喜. 一种封闭罩内顺流多旋臂气液分离器的分离特性研究[J]. 化工学报, 2023, 74(7): 2957-2966.
[13]	文兆伦, 李沛睿, 张忠林, 杜晓, 侯起旺, 刘叶刚, 郝晓刚, 官国清. 基于自热再生的隔壁塔深冷空分工艺设计及优化[J]. 化工学报, 2023, 74(7): 2988-2998.
[14]	王杰, 丘晓琳, 赵烨, 刘鑫洋, 韩忠强, 许雍, 蒋文瀚. 聚电解质静电沉积改性PHBV抗氧化膜的制备与性能研究[J]. 化工学报, 2023, 74(7): 3068-3078.
[15]	韩奎奎, 谭湘龙, 李金芝, 杨婷, 张春, 张永汾, 刘洪全, 于中伟, 顾学红. 四通道中空纤维MFI分子筛膜用于二甲苯异构体分离[J]. 化工学报, 2023, 74(6): 2468-2476.