梯形微通道内乙醇水混合蒸气冷凝流型可视化实验

doi:10.11949/j.issn.0438-1157.20150399

化工学报 ›› 2015, Vol. 66 ›› Issue (11): 4320-4326.DOI: 10.11949/j.issn.0438-1157.20150399

梯形微通道内乙醇水混合蒸气冷凝流型可视化实验

姜睿, 马学虎, 兰忠, 白涛, 白玉潇

大连理工大学化学工程研究所, 辽宁省化工资源清洁利用重点实验室, 辽宁大连 116023

收稿日期:2015-03-30 修回日期:2015-05-05 出版日期:2015-11-05 发布日期:2015-11-05
通讯作者: 马学虎
基金资助:
国家自然科学基金项目(51236002);高等学校博士学科点专项科研基金项目(20120041110018)。

Visualization study of flow patterns for ethanol-water mixtures condensation in microchannels

JIANG Rui, MA Xuehu, LAN Zhong, BAI Tao, BAI Yuxiao

Institute of Chemical Engineering, Liaoning Provincial Key Laboratory of Clean Utilization of Chemical Resources, Dalian University of Technology, Dalian 116023, Liaoning, China

Received:2015-03-30 Revised:2015-05-05 Online:2015-11-05 Published:2015-11-05
Supported by:
supported by the National Natural Science Foundation of China (51236002) and the Doctoral Program Foundation for Returned Scholars, Ministry of Education of China (20120041110018).

摘要/Abstract

摘要：

利用高速摄像系统对梯形硅基微通道进行乙醇水混合蒸气冷凝流型可视化实验。梯形微通道结构为梯形,水力学直径165.87 mm,通道长度50 mm。实验中混合蒸气乙醇质量分数范围为2%～60%。实验发现入口蒸气乙醇浓度对通道内流型有重要影响。沿着冷凝方向,发现环状流、环状条纹流、翻滚流、喷射流/喷射滴状流及气泡流。不同蒸气入口乙醇质量分数有不同的流型分布,低乙醇浓度的蒸气冷凝环状条纹流及喷射流区域出现伪滴状凝结形式,高乙醇浓度的蒸气冷凝出现翻滚流流型。实验以蒸气质量通量及蒸气干度为坐标对不同入口浓度蒸气冷凝建立了两相流型图,并对喷射流发生干度建立了流型转变预测式。

关键词: 微通道, 凝结, 两相流, 混合蒸气, Marangoni效应

Abstract:

A visualization experiment was carried out to investigate the condensation flow patterns of the ethanol-water vapor mixtures in an array of microchannels under a wide range of concentration (2%—60%). The microchannel was a trapezoidal silicon one with a hydraulic diameter of 165.87 mm and a length of 50 mm. The visualization study indicated that the ethanol concentration remarkably influenced the flow regimes. Along the flow direction, annular, annular-streak, annular-streak-droplet, annular-churn, injection, droplet-injection and bubble flow patterns were observed in the vapor mixtures condensation of different inlet ethanol concentration (60%, 31%, 20%, 6%, 4%, 2%). Due to the Marangoni effect, the film of the annular flow was more fluctuant comparing with the pure steam condensation. With the decreasing of the ethanol concentration, the injection flow pattern became more regular and the droplet would appear in the injection flow area. The two-phase flow pattern maps of different inlet ethanol concentrations were also developed to describe the experiment. A correlation based on the critical quality correlation was proposed to indicate the transition of the two-phase flow patterns.

Key words: microchannels, condensation, two-phase flow, binary steam, Marangoni effect

中图分类号:

O359⁺.1

姜睿, 马学虎, 兰忠, 白涛, 白玉潇. 梯形微通道内乙醇水混合蒸气冷凝流型可视化实验[J]. 化工学报, 2015, 66(11): 4320-4326.

JIANG Rui, MA Xuehu, LAN Zhong, BAI Tao, BAI Yuxiao. Visualization study of flow patterns for ethanol-water mixtures condensation in microchannels[J]. CIESC Journal, 2015, 66(11): 4320-4326.

参考文献 22

[1]	Quan X J, Chen P, Wu H Y. Transition from annular flow to plug/slug flow in condensation of steam in microchannels [J]. Int. J. Heat Mass Transfer, 2008, 51(3): 707-716.
[2]	Chen Y P, Chen P. Condensation of steam in silicon microchannels [J]. International Communications in Heat and Mass Transfer, 2005, 32(1): 175-183.
[3]	Wu H Y, Yu M M, Cheng P, Wu X Y. Injection flow during steam condensation in silicon microchannels [J]. Journal of Micromechanics and Microengineering, 2007, 17(8): 1618-1627.
[4]	Wu H Y, Cheng P. Condensation flow patterns in silicon microchannels [J]. International Journal of Heat and Mass Transfer, 2005, 48(11): 2186-2197.
[5]	Wu J F, Shi M H, Chen Y P, Li X. Visualization study of steam condensation in wide rectangular silicon microchannels [J]. International Journal of Thermal Sciences, 2010, 49(6): 922-930.
[6]	Chen Y P, Wu R, Shi M H, Wu J F, Peterson G P. Visualization study of steam condensation in triangular microchannels [J]. Int. J. Heat Mass Transfer, 2009, 52(21): 5122-5129.
[7]	Ma X H, Fan X G, Lan Z, Hao T T. Flow patterns and transition characteristics for steam condensation in silicon microchannels [J]. Journal of Micromechanics and Microengineering, 2011, 21(7): 075009.
[8]	Fang C, Steinbrenner J E, Wang F M, Kenneth E G. Impact of wall hydrophobicity on condensation flow and heat transfer in silicon microchannels [J]. Journal of Micromechanics and Microengineering, 2010, 20(4): 045018.
[9]	Chen Y P, Shen C Q, Shi M H, Peterson G P. Visualization study of flow condensation in hydrophobic microchannels [J]. AIChE Journal, 2014, 60(3): 1182-1192.
[10]	Enright R, Miljkovic N, Alvarado J, Kwang K, Rose J. Dropwise condensation on micro-and nanostructured surfaces [J]. Nanoscale and Microscale Thermophysical Engineering, 2014, 18: 223-250.
[11]	Hu Shenhua(胡申华), Yan Junjie(严俊杰), Wang Jinshi(王进仕). Affecting factors of Marangoni condensation mode [J]. CIESC Journal(化工学报), 2011, 62(11): 3053-3059.
[12]	Utaka Y, Wang S. Characteristic curves and the promotion effect of ethanol addition on steam condensation heat transfer [J]. Int. J. Heat Mass Transfer, 2004, 47: 4507-4516.
[13]	Utaka Y, Kamiyama T. Condensate drop movement in Marangoni condensation by applying bulk temperature gradient on heat transfer surface [J]. Heat Transfer-Asian Research, 2008, 37(7): 387-397.
[14]	Utaka Y, Nishikawa T. Measurement of condensate film thickness for solutal Marangoni condensation applying laser extinction method [J]. Journal of Enhanced Heat Transfer, 2003, 10(2): 119-130.
[15]	Wang J S, Yan J J, Hu S H, Liu J P. Marangoni condensation heat transfer of water-ethanol mixtures on a vertical surface with temperature gradients [J]. Int. J. Heat Mass Transfer, 2009, 52(9): 2324-2334.
[16]	Yan J J, Wang J S, Yang Y S, Hu S H, Liu J P. Research on Marangoni condensation modes for water-ethanol mixture vapors [J]. Microgravity Science and Technology, 2009, 21(1): 77-85.
[17]	Deans J, Martin P J, Norris S. The condensation of steam containing low concentrations of trimethylamine [J]. International Journal of Heat and Mass Transfer, 2013, 61: 381-388.
[18]	Ma X H, Lan Z, Xu W, Wang M Z, Wang S F. Effect of surface free energy difference on steam-ethanol mixture condensation heat transfer [J]. Int. J. Heat Mass Transfer, 2012, 55: 531-537.
[19]	Lin P H, Fu B R, Pan C. Critical heat flux on flow boiling of methanol-water mixtures in a diverging microchannel with artificial cavities [J]. International Journal of Heat and Mass Transfer, 2011, 54(15): 3156-3166.
[20]	Fu B R, Tsou M S, Pan C. Boiling heat transfer and critical heat flux of ethanol-water mixtures flowing through a diverging microchannel with artificial cavities [J]. International Journal of Heat and Mass Transfer, 2012, 55(5/6): 1807-1814.
[21]	Fu B R, Lin P H, Tsou M S, et al. Flow pattern maps and transition criteria for flow boiling of binary mixtures in a diverging microchannel [J]. International Journal of Heat and Mass Transfer, 2012, 55(5): 1754-1763.
[22]	Poling B E, Prausnitz J M, John Paul O C, Reid R C. The Properties of Gases and Liquids [M]. New York: McGraw-Hill, 2001.

梯形微通道内乙醇水混合蒸气冷凝流型可视化实验

Visualization study of flow patterns for ethanol-water mixtures condensation in microchannels

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 22

相关文章 15

编辑推荐

Metrics

本文评价

[1]	肖明堃, 杨光, 黄永华, 吴静怡. 浸没孔液氧气泡动力学数值研究[J]. 化工学报, 2023, 74(S1): 87-95.
[2]	周绍华, 詹飞龙, 丁国良, 张浩, 邵艳坡, 刘艳涛, 郜哲明. 短管节流阀内流动噪声的实验研究及降噪措施[J]. 化工学报, 2023, 74(S1): 113-121.
[3]	苏伟, 马东旭, 金旭, 刘忠彦, 张小松. 表面润湿性对霜层传递特性影响可视化实验研究[J]. 化工学报, 2023, 74(S1): 122-131.
[4]	江河, 袁俊飞, 王林, 邢谷雨. 均流腔结构对微细通道内相变流动特性影响的实验研究[J]. 化工学报, 2023, 74(S1): 235-244.
[5]	温凯杰, 郭力, 夏诏杰, 陈建华. 一种耦合CFD与深度学习的气固快速模拟方法[J]. 化工学报, 2023, 74(9): 3775-3785.
[6]	王玉兵, 李杰, 詹宏波, 朱光亚, 张大林. R134a在菱形离散肋微小通道内的流动沸腾换热实验研究[J]. 化工学报, 2023, 74(9): 3797-3806.
[7]	何松, 刘乔迈, 谢广烁, 王斯民, 肖娟. 高浓度水煤浆管道气膜减阻两相流模拟及代理辅助优化[J]. 化工学报, 2023, 74(9): 3766-3774.
[8]	袁佳琦, 刘政, 黄锐, 张乐福, 贺登辉. 泡状入流条件下旋流泵能量转换特性研究[J]. 化工学报, 2023, 74(9): 3807-3820.
[9]	高燕, 伍鹏, 尚超, 胡泽君, 陈晓东. 基于双流体喷嘴的磁性琼脂糖微球的制备及其蛋白吸附性能探究[J]. 化工学报, 2023, 74(8): 3457-3471.
[10]	邢雷, 苗春雨, 蒋明虎, 赵立新, 李新亚. 井下微型气液旋流分离器优化设计与性能分析[J]. 化工学报, 2023, 74(8): 3394-3406.
[11]	刘文竹, 云和明, 王宝雪, 胡明哲, 仲崇龙. 基于场协同和耗散的微通道拓扑优化研究[J]. 化工学报, 2023, 74(8): 3329-3341.
[12]	郭雨莹, 敬加强, 黄婉妮, 张平, 孙杰, 朱宇, 冯君炫, 陆洪江. 稠油管道水润滑减阻及压降预测模型修正[J]. 化工学报, 2023, 74(7): 2898-2907.
[13]	高金明, 郭玉娇, 鄂承林, 卢春喜. 一种封闭罩内顺流多旋臂气液分离器的分离特性研究[J]. 化工学报, 2023, 74(7): 2957-2966.
[14]	何宣志, 何永清, 闻桂叶, 焦凤. 磁液液滴颈部自相似破裂行为[J]. 化工学报, 2023, 74(7): 2889-2897.
[15]	牛超, 沈胜强, 杨艳, 潘泊年, 李熠桥. 甲烷BOG喷射器流动过程计算与性能分析[J]. 化工学报, 2023, 74(7): 2858-2868.