SAPO-34分子筛硅铝比对甲醇制烯烃反应性能及积炭组成的影响

doi:10.11949/j.issn.0438-1157.20150842

化工学报 ›› 2015, Vol. 66 ›› Issue (8): 2982-2989.DOI: 10.11949/j.issn.0438-1157.20150842

• 催化、动力学与反应器 • 上一篇下一篇

SAPO-34分子筛硅铝比对甲醇制烯烃反应性能及积炭组成的影响

崔宇^1,2, 王垚¹, 魏飞¹

1 清华大学化学工程系, 北京 100084;
2 华电煤业集团有限公司, 北京 100035

收稿日期:2015-06-05 修回日期:2015-06-18 出版日期:2015-08-05 发布日期:2015-08-05
通讯作者: 魏飞
基金资助:
国家自然科学基金项目(2020619)。

Effect of Si/Al ratio of SAPO-34 on reactivity and coke composition in methanol to olefins reaction

CUI Yu^1,2, WANG Yao¹, WEI Fei¹

1 Department of Chemical Engineering, Tsinghua University, Beijing 100084, China;
2 Huadian Coal Industry Group, Beijing 100035, China

Received:2015-06-05 Revised:2015-06-18 Online:2015-08-05 Published:2015-08-05
Supported by:
supported by the National Natural Science Foundation of China (2020619).

摘要/Abstract

摘要：

为了研究硅铝比对甲醇制烯烃反应性能及积炭组成的影响,控制合成中的原料配比制备了一系列不同硅铝比的SAPO-34分子筛。对合成的SAPO-34分子筛上的总酸量、酸强度和酸中心的分布进行了表征,发现成对的酸性位点随硅铝比的增大而增加。在固定床反应器中,系统地研究了SAPO-34分子筛的硅铝比对MTO反应性能的影响。由于成对的酸性中心是氢转移、低聚和成环的主要活性中心,能够增加副产物丙烷选择性及焦炭的生成速率,降低SAPO-34催化剂的烯烃选择性和催化剂的寿命。反应失活分析表明,在350℃、常压、空速为10 h^-1的条件下,催化剂可用一级反应失活方程描述,失活与硅铝比的3次方呈正比。采用原位热重质谱分析结合溶炭色谱质谱联用分析,发现硅铝比较高的SAPO-34分子筛笼内萘及其同系物乃至蒽、菲等稠环芳烃产物的生成速度较快,堵塞产物扩散的通道,导致催化剂的快速失活。

关键词: 甲醇制烯烃, 分子筛, 催化, 活性, 成对酸中心, 失活

Abstract:

In order to investigate the effect of Si/Al ratio of SAPO-34 on the reactivity and coke composition in the methanol to olefins reaction, a series SAPO-34 samples with different Si/Al ratio were prepared with controlling the composition of the synthesis gel. The total acidity, acid strength and the distribution of acid sites of these samples were characterized. The results showed that the amount of close acid sites increased with increasing Si/Al ratio of SAPO-34. The influences of the Si/Al ratio of SAPO-34 on the performances in the reaction of methanol to olefins were investigated. The result showed close acid sites were the main active sites for hydrogen transfer and oligomerizations which increased the selectivity of by-product propane and coke, as a result the life time and the selectivity of olefins decreased. The dissolved coke were analyzed using in-situ thermogravity combined with mass spectrometry and gas chromatography mass spectrometry,the results showed that the close acid sites accelerated the generation of anthracene, phenanthrene, naphthalene, and other polycyclic aromatic products in the cage of SAPO-34, which led the blockage of the product diffusion channel and rapid deactivation of SAPO-34.

Key words: methanol to olefins, molecule sieve, catalysis, activity, close acid, deactivation

中图分类号:

TQ028.8

崔宇, 王垚, 魏飞. SAPO-34分子筛硅铝比对甲醇制烯烃反应性能及积炭组成的影响[J]. 化工学报, 2015, 66(8): 2982-2989.

CUI Yu, WANG Yao, WEI Fei. Effect of Si/Al ratio of SAPO-34 on reactivity and coke composition in methanol to olefins reaction[J]. CIESC Journal, 2015, 66(8): 2982-2989.

参考文献 22

[1]	Stöcker M. Methanol-to-hydrocarbons: catalytic materials and their behavior [J]. Micropor. Mesopor. Mat., 1999, 29(1/2): 3-48.
[2]	Chen J, Wright P A, Thomas J M, et al. SAPO-18 catalysts and their Brønsted acid sites [J]. J. Phys. Chem., 1994, 98(40): 10216-10224.
[3]	Chen J, Wright P, Natarajan S, et al. Understanding the Brønsted acidity of Sapo-5, Sapo-17, Sapo-18 and SAPO-34 and their catalytic performance for methanol conversion to hydrocarbons [J]. Stud. Surf. Sci. Catal., 1994, 84: 1731-1738.
[4]	Wilson S, Barger P. The characteristics of SAPO-34 which influence the conversion of methanol to light olefins [J]. Micropor. Mesopor. Mat., 1999, 29(1/2): 117-126.
[5]	Izadbakhsh A, Farhadi F, Khorasheh F, et al. Effect of SAPO-34's composition on its physico-chemical properties and deactivation in MTO process [J]. Appl. Catal. A: Gen., 2009, 364(1): 48-56.
[6]	Oikawa H, Shibata Y, Inazu K, et al. Highly selective conversion of ethene to propene over SAPO-34 as a solid acid catalyst [J]. Appl. Catal. A-Gen., 2006, 312: 181-185.
[7]	Popova M, Minchev C, Kanazirev V. Methanol conversion to light alkenes over SAPO-34 molecular sieves synthesized using various sources of silicon and aluminium [J]. Appl. Catal. A: Gen., 1998, 169(2): 227-235.
[8]	Tan J, Liu Z, Bao X, et al. Crystallization and Si incorporation mechanisms of SAPO-34 [J]. Micropor. Mesopor. Mat., 2002, 53(1-3): 97-108.
[9]	Jeanvoine Y, Ángyán J G, Kresse G, et al. Brønsted acid sites in HSAPO-34 and chabazite: anab initio structural study [J]. J. Phys. Chem. B, 1998, 102(29): 5573-5580.
[10]	Martins G, Berlier G, Bisio C, et al. Quantification of Brønsted acid sites in microporous catalysts by a combined FTIR and NH3-TPD study [J]. J. Phys. Chem. C, 2008, 112(18): 7193-7200.
[11]	Gábová V, Děde?ek J, ?ejka J. Control of Al distribution in ZSM-5 by conditions of zeolite synthesis [J]. Chem. Commun., 2003, (10): 1196-1197.
[12]	Děde?ek J, Kaucký D, Wichterlová B, et al. Co2+ ions as probes of Al distribution in the framework of zeolites. ZSM-5 study [J]. Phys. Chem. Chem. Phys., 2002, 4(21): 5406-5413.
[13]	Děde?ek J, Sklenak S, Li C, et al. Effect of Al-Si-Al and Al-Si-Si-Al pairs in the ZSM-5 zeolite framework on the 27Al NMR spectra. A combined high-resolution 27Al NMR and DFT/MM study [J]. J. Phys. Chem. C, 2009, 113(4): 1447-1458.
[14]	Qi Guozhen(齐国祯), Xie Zaiku(谢在库), Liu Hongxing(刘红星), Zhong Siqing(钟思青), Zhang Chengfang(张成芳), Chen Qingling(陈庆龄). Study on carbon deposition on SAPO-34 molecular sieve catalyst in transformation of methanol to olefins [J]. Petrochemical Technology(石油化工), 2006, 35(1): 29-32.
[15]	Qi Guozhen(齐国祯), Xie Zaiku(谢在库), Chen Qingling(陈庆龄). Methanol to olefins reaction on SAPO-34 catalyst-deactivation kinetics of catalytic reaction [J]. Chemical Reaction Engineering and Technology(化学反应工程与工艺), 2013, 29(1): 1-5.
[16]	Zhang Mingye (张明烨), Cui Yu (崔宇), Li Yuxin (李玉新), Wei Fei (魏飞), Wang Yao (王垚). TGA-MS study oncracking of the coke deposited on catalyst for MTO reaction [J]. Natural Gas Chemical Industry (天然气化工), 2014, 39(1): 6-11.
[17]	Sazama P, Děde?ek J, Gabova V, et al. Effect of aluminium distribution in the framework of ZSM-5 on hydrocarbon transformation. Cracking of 1-butene [J]. J. Catal., 2008, 254(2): 180-189.
[18]	Sklenak S, Děde?ek J, Li C, et al. Aluminium siting in the ZSM-5 framework by combination of high resolution 27Al NMR and DFT/MM calculations [J]. Phys. Chem. Chem. Phys., 2009, 11(8): 1237-1247.
[19]	Qian Q, Vog Charlotte Mokhtar Mohamed. Combined operando UV/Vis/IR spectroscopy reveals the role of methoxy and aromatic species during the methanol-to-olefins reaction over H-SAPO-34 [J]. Chem. Cat. Chem., 2014, 6(12): 3396-3408.
[20]	Li Y, Zhang M, Wang D. Differences in the methanol-to-olefins reaction catalyzed by SAPO-34 with dimethyl ether as reactant [J]. J. Catal., 2014, 311: 281-287.
[21]	Kim Wookdong, Ryoo Ryong. Probing the catalytic function of external acid sites located on the MFI nanosheet for conversion of methanol to hydrocarbons [J]. Catal. Lett., 2014, 144(7): 1164-1169.
[22]	Dai Weili, Wang Chuanming, Dyballa Michael. Understanding the early stages of the methanol-to-olefin conversion on H-SAPO-34 [J]. ACS Catal., 2015, 5(1): 317-326.

SAPO-34分子筛硅铝比对甲醇制烯烃反应性能及积炭组成的影响

Effect of Si/Al ratio of SAPO-34 on reactivity and coke composition in methanol to olefins reaction

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 22

相关文章 15

编辑推荐

Metrics

本文评价

[1]	范孝雄, 郝丽芳, 范垂钢, 李松庚. LaMnO₃/生物炭催化剂低温NH₃-SCR催化脱硝性能研究[J]. 化工学报, 2023, 74(9): 3821-3830.
[2]	吴雷, 刘姣, 李长聪, 周军, 叶干, 刘田田, 朱瑞玉, 张秋利, 宋永辉. 低阶粉煤催化微波热解制备含碳纳米管的高附加值改性兰炭末[J]. 化工学报, 2023, 74(9): 3956-3967.
[3]	李艺彤, 郭航, 陈浩, 叶芳. 催化剂非均匀分布的质子交换膜燃料电池操作条件研究[J]. 化工学报, 2023, 74(9): 3831-3840.
[4]	杨学金, 杨金涛, 宁平, 王访, 宋晓双, 贾丽娟, 冯嘉予. 剧毒气体PH₃的干法净化技术研究进展[J]. 化工学报, 2023, 74(9): 3742-3755.
[5]	程业品, 胡达清, 徐奕莎, 刘华彦, 卢晗锋, 崔国凯. 离子液体基低共熔溶剂在转化CO₂中的应用[J]. 化工学报, 2023, 74(9): 3640-3653.
[6]	陈杰, 林永胜, 肖恺, 杨臣, 邱挺. 胆碱基碱性离子液体催化合成仲丁醇性能研究[J]. 化工学报, 2023, 74(9): 3716-3730.
[7]	杨菲菲, 赵世熙, 周维, 倪中海. Sn掺杂的In₂O₃催化CO₂选择性加氢制甲醇[J]. 化工学报, 2023, 74(8): 3366-3374.
[8]	李凯旋, 谭伟, 张曼玉, 徐志豪, 王旭裕, 纪红兵. 富含零价钴活性位点的钴氮碳/活性炭设计及甲醛催化氧化应用研究[J]. 化工学报, 2023, 74(8): 3342-3352.
[9]	杨欣, 彭啸, 薛凯茹, 苏梦威, 吴燕. 分子印迹-TiO₂光电催化降解增溶PHE废水性能研究[J]. 化工学报, 2023, 74(8): 3564-3571.
[10]	吕龙义, 及文博, 韩沐达, 李伟光, 高文芳, 刘晓阳, 孙丽, 王鹏飞, 任芝军, 张光明. 铁基导电材料强化厌氧去除卤代有机污染物：研究进展及未来展望[J]. 化工学报, 2023, 74(8): 3193-3202.
[11]	陈雅鑫, 袁航, 刘冠章, 毛磊, 杨纯, 张瑞芳, 张光亚. 蛋白质纳米笼介导的酶自固定化研究进展[J]. 化工学报, 2023, 74(7): 2773-2782.
[12]	汤晓玲, 王嘉瑞, 朱玄烨, 郑仁朝. 基于Pickering乳液的卤醇脱卤酶催化合成手性环氧氯丙烷[J]. 化工学报, 2023, 74(7): 2926-2934.
[13]	余娅洁, 李静茹, 周树锋, 李清彪, 詹国武. 基于天然生物模板构建纳米材料及集成催化剂研究进展[J]. 化工学报, 2023, 74(7): 2735-2752.
[14]	屈园浩, 邓文义, 谢晓丹, 苏亚欣. 活性炭/石墨辅助污泥电渗脱水研究[J]. 化工学报, 2023, 74(7): 3038-3050.
[15]	王杰, 丘晓琳, 赵烨, 刘鑫洋, 韩忠强, 许雍, 蒋文瀚. 聚电解质静电沉积改性PHBV抗氧化膜的制备与性能研究[J]. 化工学报, 2023, 74(7): 3068-3078.