电渗透/Fe-过硫酸盐氧化协同强化污泥深度脱水

doi:10.11949/j.issn.0438-1157.20160177

化工学报 ›› 2016, Vol. 67 ›› Issue (9): 4013-4019.DOI: 10.11949/j.issn.0438-1157.20160177

电渗透/Fe-过硫酸盐氧化协同强化污泥深度脱水

李亚林, 刘蕾, 张毅, 魏添, 史丹

河南工程学院资源与环境学院, 河南郑州 451191

收稿日期:2016-02-17 修回日期:2016-03-14 出版日期:2016-09-05 发布日期:2016-09-05
通讯作者: 李亚林
基金资助:
河南省科技攻关项目（162102310402）；河南省高等学校重点科研项目计划（15A610010）；郑州市科技攻关项目（20150237）。

Coordination of electro-osmotic and Fe-persulfate oxidation process on sewage sludge deep-dewatering

LI Yalin, LIU Lei, ZHANG Yi, WEI Tian, SHI Dan

Department of Resources and Environment, Henan Institute of Engineering, Zhengzhou 451191, Henan, China

Received:2016-02-17 Revised:2016-03-14 Online:2016-09-05 Published:2016-09-05
Supported by:
supported by the Henan Science and Technology Program (162102310402), the Foundation of Henan Educational Committee (15A610010) and Zhengzhou Science and Technology Program(20150237).

摘要/Abstract

摘要：

利用电渗透和高级氧化技术，采用自制实验装置对城市污水处理厂的脱水污泥进行了脱水研究，系统研究了过硫酸盐投加量、铁盐与过硫酸盐比例、电压梯度、脱水时间和污泥厚度对污泥脱水的影响。结果表明，电渗透-高级氧化复合技术可以改善污泥的脱水性能，在污泥样品为140 g、过硫酸盐投加量为100（mg·g DS）^-1、Fe²⁺与过硫酸盐比例为1：1、机械压力为17.59 kPa、控制初始电压为11 V·cm^-1时，污泥的含水率可以降低至60%以下，与单独使用电渗透技术相比，泥饼具有更好的均匀性，便于后续的运输和安置。

关键词: 电渗透, 氧化, 污泥, 脱水, 废物处理

Abstract:

Dewatered sewage sludge of sewage treatment plant was studied by self-made experimental device dewatering based on electro-osmotic-advanced oxidation process which would be influenced by the dosage of persulfate, proportion of ferric salt and persulfate, voltage gradient and the thickness of dewatered sewage sludge. The results showed that the combination of electro-osmosis-advanced oxidation technology can improve the dewater ability. The water content can be reduced to below 60% with sludge amount of 140 g, persulfate dosage of 100 mg·(g DS)^-1, Fe²⁺/persulfate of 1:1, mechanical pressure of 17.59 kPa and controlling initial voltage of 11 V·cm^-1. Electro-osmotic-advanced oxidation process can ensure fully use of oxidation ability of to improve the sludge dewater ability based on the mechanism of reduction of electric field and electronic metastasis reaction, making persulfate fully activated compared with sludge dewatering by activated persulfate. Better than the traditional electro-osmosis sludge dewatering, more amount sludge can be treated one time and sludge cake uniformity can be highly improved for the subsequent transportation and settlement.

Key words: electro-osmotic, oxidation, sewage sludge, dewatering, waste treatment

中图分类号:

X705

李亚林, 刘蕾, 张毅, 魏添, 史丹. 电渗透/Fe-过硫酸盐氧化协同强化污泥深度脱水[J]. 化工学报, 2016, 67(9): 4013-4019.

LI Yalin, LIU Lei, ZHANG Yi, WEI Tian, SHI Dan. Coordination of electro-osmotic and Fe-persulfate oxidation process on sewage sludge deep-dewatering[J]. CIESC Journal, 2016, 67(9): 4013-4019.

参考文献 22

[1]	ZHAN T L, ZHAN X, LIN W, et al. Field and laboratory investigation on geotechnical properties of sewage sludge disposed in a pit at Changan landfill, Chengdu, China[J]. Engineering Geology, 2014, 170:24-32.
[2]	SAVEYN H, CURVERS D, PEL L, et al. In situ determination of solidosity profiles during activated sludge electrodewatering[J]. Water Research, 2006, 40(11):2135-2142.
[3]	TUAN P A, SILLANPAA M. Effect of freeze/thaw conditions, polyelectrolyte addition, and sludge loading on sludge electro-dewatering process[J]. Chemical Engineering Journal, 2010, 164(1):85-91.
[4]	MAHMOUD A, JEREMY O, JEAN V, et al. Electro-dewatering of wastewater sludge:influence of the operating conditions and their interactions effects[J]. Water Research, 2011, 45(9):2795-2810.
[5]	LOGINOV M, CITEAU M, LEBOVKA N, et al. Electro-dewatering of drilling sludge with liming and electrode heating[J]. Separation and Purification Technology, 2013, 104:89-99.
[6]	ZHEN G, LU X, WANG B, et al. Synergetic pretreatment of waste activated sludge by Fe(Ⅱ)-activated persulfate oxidation under mild temperature for enhanced dewaterability[J]. Bioresource Technology, 2012, 124:29-36.
[7]	ZHEN G, LU X, ZHAO Y, et al. Enhanced dewaterability of sewage sludge in the presence of Fe(Ⅱ)-activated persulfate oxidation[J]. Bioresource Technology, 2012, 116:259-265.
[8]	ONCU N B, MERCAN N, BALCIOGLU I A. The impact of ferrous iron/heat-activated persulfate treatment on waste sewage sludge constituents and sorbed antimicrobial micropollutants[J]. Chemical Engineering Journal, 2015, 259:972-980.
[9]	唐海, 沙俊鹏, 欧阳龙, 等. Fe(Ⅱ)活化过硫酸盐氧化破解剩余污泥[J]. 化工学报, 2015, 66(2):785-792. TANG H, SHA J P, OUYANG L, et al. Persulfate activated by Fe(Ⅱ) for oxidation and disintegration of excess sludge[J]. CIESC Journal, 2015, 66(2):785-792.
[10]	SHI Y F, YANG J K, YU W B, et al. Synergetic conditioning of sewage sludge via Fe2+/persulfate and skeleton builder:effect on sludge characteristics and dewaterability[J]. Chemical Engineering Journal, 2015, 270:572-581.
[11]	LI Y L, LIU J W, CHEN J Y, et al. Reuse of dewatered sewage sludge conditioned with skeleton builders as landfill cover material[J]. International Journal of Environmental Science and Technology, 2014, 11(1):233-240.
[12]	ZHAO J Y, ZHANG Y B, QUAN X, et al. Enhanced oxidation of 4-chlorophenol using sulfate radicals generated from zerovalent iron and peroxydisulfate at ambient temperature[J].Separation and Purification Technology, 2010, 71(3):302-307.
[13]	SHI Y F, YANG J K, MAO W, et al. Influence of Fe2+-sodium persulfate on extracellular polymeric substances and dewaterability of sewage sludge[J]. Desalination and Water Treatment, 2015, 53(10):2655-2663.
[14]	GLENDINNING S, MOK C K, KALUMBA D, et al. Design framework for electrokinetically enhanced dewatering of sludge[J]. Journal of Environmental Engineering-ASCE, 2010, 136(4):417-426.
[15]	LARUE O, WAKEMAN R J, TARLETON E S, et al. Pressure electroosmotic dewatering with continuous of electrolysis products[J]. Chemical Engineering Science, 2006, 61(14):4732-4740.
[16]	REDDY K R, URBANEK A, KHODADOUST A P. Electroosmotic dewatering of dredged sediments:bench-scale investigation[J]. Journal of Environmental Management, 2006, 78(2):200-208.
[17]	TUAN P A, JURATE V, MIKA S. Electro-dewatering of sludge under pressure and non-pressure conditions[J]. Environmental Technology, 2008, 29(10):1075-1084.
[18]	PHAM-ANH T, SILLANPAA M. Fractionation of macro and trace metals due to off-time interrupted electrodewatering[J]. Drying Technology, 2010, 28(6):762-772.
[19]	NARASIMHAN B, RANJAN R S. Electrokinetic barrier to prevent subsurface contaminant migration:theoretical model development and validation[J]. Journal of Contaminant Hydrology, 2000, 42(1):1-17.
[20]	CUNDY A B, HOPKINSON L. Electrokinetic iron pan generation in unconsolidated sediments:implications for contaminated land remediation and soil engineering[J]. Applied Geochemistry, 2005, 20(5):841-848.
[21]	HO M Y, CHEN G H. Enhanced electro-osmotic dewatering of fine particle suspension using a rotating anode[J]. Industrial & Engineering Chemistry Research, 2001, 40(8):1859-1863.
[22]	YANG L, NAKHLA G, BASSI A. Electro-kinetic dewatering of oily sludges[J]. Journal of Hazardous Materials, 2005, 125(1):130-140.

电渗透/Fe-过硫酸盐氧化协同强化污泥深度脱水

Coordination of electro-osmotic and Fe-persulfate oxidation process on sewage sludge deep-dewatering

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 22

相关文章 15

编辑推荐

Metrics

本文评价

[1]	胡超, 董玉明, 张伟, 张红玲, 周鹏, 徐红彬. 浓硫酸活化五氧化二钒制备高浓度全钒液流电池正极电解液[J]. 化工学报, 2023, 74(S1): 338-345.
[2]	宋瑞涛, 王派, 王云鹏, 李敏霞, 党超镔, 陈振国, 童欢, 周佳琦. 二氧化碳直接蒸发冰场排管内流动沸腾换热数值模拟分析[J]. 化工学报, 2023, 74(S1): 96-103.
[3]	张义飞, 刘舫辰, 张双星, 杜文静. 超临界二氧化碳用印刷电路板式换热器性能分析[J]. 化工学报, 2023, 74(S1): 183-190.
[4]	范孝雄, 郝丽芳, 范垂钢, 李松庚. LaMnO₃/生物炭催化剂低温NH₃-SCR催化脱硝性能研究[J]. 化工学报, 2023, 74(9): 3821-3830.
[5]	杨百玉, 寇悦, 姜峻韬, 詹亚力, 王庆宏, 陈春茂. 炼化碱渣湿式氧化预处理过程DOM的化学转化特征[J]. 化工学报, 2023, 74(9): 3912-3920.
[6]	陈美思, 陈威达, 李鑫垚, 李尚予, 吴有庭, 张锋, 张志炳. 硅基离子液体微颗粒强化气体捕集与转化的研究进展[J]. 化工学报, 2023, 74(9): 3628-3639.
[7]	程业品, 胡达清, 徐奕莎, 刘华彦, 卢晗锋, 崔国凯. 离子液体基低共熔溶剂在转化CO₂中的应用[J]. 化工学报, 2023, 74(9): 3640-3653.
[8]	米泽豪, 花儿. 基于DFT和COSMO-RS理论研究多元胺型离子液体吸收SO₂气体[J]. 化工学报, 2023, 74(9): 3681-3696.
[9]	陈哲文, 魏俊杰, 张玉明. 超临界水煤气化耦合SOFC发电系统集成及其能量转化机制[J]. 化工学报, 2023, 74(9): 3888-3902.
[10]	杨学金, 杨金涛, 宁平, 王访, 宋晓双, 贾丽娟, 冯嘉予. 剧毒气体PH₃的干法净化技术研究进展[J]. 化工学报, 2023, 74(9): 3742-3755.
[11]	韩晨, 司徒友珉, 朱斌, 许建良, 郭晓镭, 刘海峰. 协同处理废液的多喷嘴粉煤气化炉内反应流动研究[J]. 化工学报, 2023, 74(8): 3266-3278.
[12]	李锦潼, 邱顺, 孙文寿. 煤浆法烟气脱硫中草酸和紫外线强化煤砷浸出过程[J]. 化工学报, 2023, 74(8): 3522-3532.
[13]	杨菲菲, 赵世熙, 周维, 倪中海. Sn掺杂的In₂O₃催化CO₂选择性加氢制甲醇[J]. 化工学报, 2023, 74(8): 3366-3374.
[14]	洪瑞, 袁宝强, 杜文静. 垂直上升管内超临界二氧化碳传热恶化机理分析[J]. 化工学报, 2023, 74(8): 3309-3319.
[15]	李凯旋, 谭伟, 张曼玉, 徐志豪, 王旭裕, 纪红兵. 富含零价钴活性位点的钴氮碳/活性炭设计及甲醛催化氧化应用研究[J]. 化工学报, 2023, 74(8): 3342-3352.