钙碳比对CaSO4-CaCO3-(NH4)2CO3-H2O体系反应-结晶过程的影响

doi:10.11949/j.issn.0438-1157.20171452

摘要/Abstract

摘要：

在CaSO₄-CaCO₃-（NH₄）₂CO₃-H₂O反应体系中，生成碳酸钙与硫酸铵的控速步骤是石膏溶解。溶解表面被新生的碳酸钙结晶覆盖是重要影响因素。基于反应面模型，通过调整钙离子溶出速率与碳酸根加入速率之比（钙碳比），将反应-结晶面控制在溶解表面的固液扩散边界层临界距离之外从而避免覆盖。实验采用表面积一定的天然纯净块状石膏试样，并向溶解体系滴加碳酸铵溶液，使钙碳比分别为0.125、0.25、0.5、1、2、4和8，观察碳酸钙在石膏表面的包覆现象，并预测反应-结晶面与溶解表面之间的微距离。结果显示，当钙碳比为0.125、0.25、0.5和1时，试样表面出现碳酸钙包覆但包覆量随λ增大而减小；当钙碳比为2、4和8时，试样表面不出现包覆，碳酸钙结晶生成于液相主体。将钙碳比为1视为临界值，该条件下反应-结晶面与溶解表面的微距离大于18 μm。

关键词: 反应, 结晶, 包覆, 钙碳比, 二氧化碳捕集

Abstract:

In reaction system of CaSO₄-CaCO₃-(NH₄)₂CO₃-H₂O, gypsum dissolution was the rate-controlling step to produce calcium carbonate and ammonium sulfate. Coverage of dissolution surface by newly formed CaCO₃ crystal was a significant factor. Based on reaction plane model, adjusting ratio of gypsum dissolution rate to carbonate addition rate could control the reaction-crystallization plane beyond critical distance of solid-liquid diffusion boundary layer of the dissolution surface and avoid CaCO₃ coverage on the surface. Pure natural gypsum blocks with constant surface area was used to study CaCO₃ coverage on gypsum surface and to predict micro-distance between reaction-crystallization plane and dissolution surface. Ammonium carbonate solution was added into the dissolution system with ratio of gypsum dissolution rate to carbonate addition rate equal to 0.125, 0.25, 0.5, 1, 2, 4 and 8. The results showed that CaCO₃coating on surface was increased as the ratio of gypsum dissolution rate to carbonate addition rate decreased in the range of 0.125, 0.25, 0.5 and 1, whereas CaCO₃particles were formed in the liquid phase without surface coating with the ratio of gypsum dissolution rate to carbonate addition rate in the range of 2, 4 and 8. At the ratio of gypsum dissolution rate to carbonate addition rate equal to the critical value 1, the micro-distance was more than 18 µm.

Key words: reaction, crystallization, coating, calcium/carbonate ratio, CO₂ capture

中图分类号:

TQ440

宫源, 周加贝, 朱家骅, 罗安安, 薛潇, 田建. 钙碳比对CaSO₄-CaCO₃-(NH₄)₂CO₃-H₂O体系反应-结晶过程的影响[J]. 化工学报, 2018, 69(6): 2533-2539.

GONG Yuan, ZHOU Jiabei, ZHU Jiahua, LUO An'an, XUE Xiao, TIAN Jian. Influence of calcium/carbonate ratio on reaction-crystallization of CaSO₄-CaCO₃-(NH₄)₂CO₃-H₂O system[J]. CIESC Journal, 2018, 69(6): 2533-2539.

参考文献 30

[1]	SANNA A, UIBU M, CARAMANNA G, et al. A review of mineral carbonation technologies to sequester CO2[J]. Chemical Society Reviews, 2014, 43(23):8049-8080.
[2]	AZDARPOUR A, ASADULLAH M, MOHAMMADIAN, E, et al. A review on carbon dioxide mineral carbonation through pH-swing process[J]. Chemical Engineering Journal, 2015, 279(34):615-630.
[3]	LEE M G, JANG Y N, RYU K W, et al. Mineral carbonation of flue gas desulfurization gypsum for CO2 sequestration[J]. Energy, 2012, 47(1):370-377.
[4]	POLETTINI A, POMI R, STRAMAZZO A. Carbon sequestration through accelerated carbonation of BOF slag:influence of particle size characteristics[J]. Chemical Engineering Journal, 2016, 298:26-35.
[5]	MAYORAL M C, ANDRÉS J M, GIMENO M P. Optimization of mineral carbonation process for CO2 sequestration by lime-rich coal ashes[J]. Fuel, 2013, 106(2):448-454.
[6]	HOSSEINI T, HAQUE N, SELOMULYA C, et al. Mineral carbonation of victorian brown coal fly ash using regenerative ammonium chloride-process simulation and techno-economic analysis[J]. Applied Energy, 2016, 175(1):54-68.
[7]	TAYIBI H, CHOURA M, LÓPEZ F A, et al. Environmental impact and management of phosphogypsum[J]. Journal of Environmental Management, 2009, 90(8):2377-2386.
[8]	HWAITI M A, KHASHMAN O A. Health risk assessment of heavy metals contamination in tomato and green pepper plants grown in soils amended with phosphogypsum waste materials[J]. Environmental Geochemistry & Health, 2015, 37(2):287-304.
[9]	Lu S Q, Lan P Q, Wu S F. Preparation of nano-CaCO3 from phosphogypsum by gas-liquid-solid reaction for CO2 sorption[J]. Industrial & Engineering Chemistry Research, 2016, 55(38):10172-10177.
[10]	SONG K, JANG Y N, KIM W, et al. Factors affecting the precipitation of pure calcium carbonate during the direct aqueous carbonation of flue gas desulfurization gypsum[J]. Energy, 2014, 65(2):527-532.
[11]	SONG K, KIM W, PARK S, et al. Effect of polyacrylic acid on direct aqueous mineral carbonation of flue gas desulfurization gypsum[J]. Chemical Engineering Journal, 2016, 301:51-57.
[12]	谢和平, 谢凌志, 王昱飞, 等. 全球二氧化碳减排不应是CCS,应是CCU[J]. 四川大学学报(工程科学版), 2012, 44(4):1-5. XIE H P, XIE L Z, WANG Y F, et al. CCU:a more feasible and economic strategy than CCS for reducing CO2 emissions[J]. Journal of Sichuan University (Engineering Science Edition), 2012, 44(4):1-5.
[13]	朱家骅, 谢和平, 夏素兰, 等. 烟气二氧化碳与磷石膏转化一步法节能节水清洁工艺:201210223218.4[P]. 2014-10-15. ZHU J H, XIE H P, XIA S L, et al. One step clean process to convert flue gas CO2 by phosphogypsum with low energy and water cost:201210223218.4[P]. 2014-10-15.
[14]	DAVID R L. Handbook of Chemistry and Physics[M]. 84 th ed. UK:CRC Press, 2003:1314.
[15]	王子宁, 周加贝, 朱家骅, 等. 二水硫酸钙溶解动力学[J]. 化工学报, 2015,66(3):1001-1006. WANG Z N, ZHOU J B, ZHU J H, et al. Dissolution kinetics of calcium sulfate dihydrate[J]. CIESC Journal, 2015, 66(3):1001-1006.
[16]	鲁厚芳. 杂质对石膏-碳酸铵转化过程的影响[D]. 成都:四川大学, 2002. Lu H F. Effect of impurities on gypsum conversion to ammonium sulfate with ammonium carbonate[D]. Chengdu:Sichuan University, 2002.
[17]	周加贝, 陈昌国, 朱家骅, 等. 工业固废磷石膏矿化烟气反应体系中碳酸根离子浓度对碳酸钙形核的影响[J]. 工程研究-跨学科视野中的工程, 2015, 7(4):398-403. Zhou J B, Chen C G, Zhu J H, et al. Effect of concentration of CO32- on nucleation of CaCO3 in the reaction system which industrial solid waste phosphogypsum mineralize flue gas[J]. Journal of Engineering Studies, 2015, 7(4):398-403.
[18]	王子宁. 磷石膏与二氧化碳矿化反应体系钙离子转移过程研究[D]. 成都:四川大学, 2014. WANG Z N. Research on process of Ca2+ transfer in multi-phase reaction system of CO2 mineralized by phosphogypsum[D]. Chengdu:Sichuan University, 2014.
[19]	Song K, Jang Y N, Kim W, et al. Precipitation of calcium carbonate during direct aqueous carbonation of flue gas desulfurization gypsum[J]. Energy, 2012, 213(213):251-258.
[20]	Elkanzi E M, Chalabi M F. Kinetics of the conversion of calcium sulfate to ammonium sulfate using ammonium carbonate aqueous solution[J]. Industrial & Engineering Chemistry Research, 1991, 30(6):1289-1293.
[21]	张兴法, 赵建军, 陈祥迎, 等. 磷石膏制备硫酸铵反应动力学研究[J]. 合肥工业大学学报(自然科学版), 2002, 25(3):419-422. ZHANG X F, ZHAO J J, CHEN X Y, et al. On the reaction kinetics in the preparation of ammonium sulphate from phosphogypsum and ammonium carbonate[J]. Journal of Hefei University of Technology(Natural Science), 2002,25(3):419-422.
[22]	Cordell G B. Reaction kinetics of production of ammonium sulfate from anhydrite[J]. Industrial & Engineering Chemistry Process Design & Development, 1968,7(2):278-285.
[23]	Jeschke A A, Vosbeck K, Dreybrodt W. Surface controlled dissolution rates of gypsum in aqueous solutions exhibit nonlinear dissolution kinetics[J]. Geochimica Et Cosmochimica Acta, 2001, 65(1):27-34.
[24]	HAMANN C H, HAMNETT A, VIELSTICH W. Electrochemistry[M]. 2nd ed. United States:Wiley-VCH, 2007:16
[25]	Colombani J. Measurement of the pure dissolution rate constant of a mineral in water[J]. Geochimica et Cosmochimica Acta, 2008,72(23):5634-5640.
[26]	Noyes A A, Whitney W R. The rate of solution of solid substances in their own solutions[J]. Journal of the American Chemical Society, 1897, 19(12):930-934.
[27]	BRAVO RV, CAMACHO R F, MOYA V M, et al. Desulphurization of SO2-N2 mixtures by limestone slurries[J]. Chemical Engineering Science, 2002,57(11):2047-2058.
[28]	张成芳. 气液反应和反应器[M]. 北京:化学工业出版社, 1985:33-35. Zhang C f. Gas-Liquid Reaction and the Reactor[M]. Beijing:Chemical Industry Press, 1985:33-35.
[29]	武汉大学. 分析化学[M]. 4版. 北京:高等教育出版社, 2000:34-37. Wuhan University. Analytical Chemistry[M]. 4th ed. Beijing:Higher Education Press, 2000:34-37.
[30]	Wiechers H N S, Sturrock P, Marais G V R, et al. Calcium carbonate crystallization kinetics[J]. Water Research, 1975,9(9):835-845.

钙碳比对CaSO₄-CaCO₃-(NH₄)₂CO₃-H₂O体系反应-结晶过程的影响

Influence of calcium/carbonate ratio on reaction-crystallization of CaSO₄-CaCO₃-(NH₄)₂CO₃-H₂O system

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 30

相关文章 15

编辑推荐

Metrics

本文评价

[1]	于宏鑫, 邵双全. 水结晶过程的分子动力学模拟分析[J]. 化工学报, 2023, 74(S1): 250-258.
[2]	程成, 段钟弟, 孙浩然, 胡海涛, 薛鸿祥. 表面微结构对析晶沉积特性影响的格子Boltzmann模拟[J]. 化工学报, 2023, 74(S1): 74-86.
[3]	陈杰, 林永胜, 肖恺, 杨臣, 邱挺. 胆碱基碱性离子液体催化合成仲丁醇性能研究[J]. 化工学报, 2023, 74(9): 3716-3730.
[4]	傅予, 刘兴翀, 王瀚雨, 李海敏, 倪亚飞, 邹文静, 雷月, 彭永姗. F₃EACl修饰层对钙钛矿太阳能电池性能提升的研究[J]. 化工学报, 2023, 74(8): 3554-3563.
[5]	郑玉圆, 葛志伟, 韩翔宇, 王亮, 陈海生. 中高温钙基材料热化学储热的研究进展与展望[J]. 化工学报, 2023, 74(8): 3171-3192.
[6]	汪林正, 陆俞冰, 张睿智, 罗永浩. 基于分子动力学模拟的VOCs热氧化特性分析[J]. 化工学报, 2023, 74(8): 3242-3255.
[7]	张蒙蒙, 颜冬, 沈永峰, 李文翠. 电解液类型对双离子电池阴阳离子储存行为的影响[J]. 化工学报, 2023, 74(7): 3116-3126.
[8]	陈吉, 洪泽, 雷昭, 凌强, 赵志刚, 彭陈辉, 崔平. 基于分子动力学的焦炭溶损反应及其机理研究[J]. 化工学报, 2023, 74(7): 2935-2946.
[9]	何晓崐, 刘锐, 薛园, 左然. MOCVD生长AlN单晶薄膜的气相和表面化学反应综述[J]. 化工学报, 2023, 74(7): 2800-2813.
[10]	张谭, 刘光, 李晋平, 孙予罕. Ru基氮还原电催化剂性能调控策略[J]. 化工学报, 2023, 74(6): 2264-2280.
[11]	杨峥豪, 何臻, 常玉龙, 靳紫恒, 江霞. 生物质快速热解下行式流化床反应器研究进展[J]. 化工学报, 2023, 74(6): 2249-2263.
[12]	周小文, 杜杰, 张战国, 许光文. 基于甲烷脉冲法的Fe₂O₃-Al₂O₃载氧体还原特性研究[J]. 化工学报, 2023, 74(6): 2611-2623.
[13]	朱风, 陈凯琳, 黄小凤, 鲍银珠, 李文斌, 刘嘉鑫, 吴玮强, 高王伟. KOH改性电石渣脱除羰基硫的性能研究[J]. 化工学报, 2023, 74(6): 2668-2679.
[14]	毛磊, 刘冠章, 袁航, 张光亚. 可捕集CO₂的纳米碳酸酐酶粒子的高效制备及性能研究[J]. 化工学报, 2023, 74(6): 2589-2598.
[15]	王泽栋, 石至平, 刘丽艳. 考虑气泡非均匀耗散的矩形反应器声流场数值模拟及结构优化[J]. 化工学报, 2023, 74(5): 1965-1973.