添加剂对NOxOUT脱硝及N2O、CO生成的影响特性

doi:10.3969/j.issn.0438-1157.2014.06.038

摘要/Abstract

摘要： 通过试验研究了NO_x污染的NO_xOUT脱除特点和温室气体N₂O及CO的生成规律，结合动力学分析，探讨了添加剂的作用。结果表明：在不同氨氮比（NSR）下，最佳反应温度为950℃，最高脱硝效率可达76.33%；N₂O随温度的生成曲线类似于效率曲线，在950℃左右达到最大排放量；N₂O的排放随NSR和氧量的增加而升高；温度较高时，N₂O的排放随停留时间的延长先增加后减少；碳酸钠、乙酸钠、谷氨酸钠及乙醇可有效提高低温侧的脱硝效率和拓宽相应的温度窗口，其中谷氨酸钠最为明显；脱硝效率随钠盐添加量的变化与温度有关，钠原子最佳添加量为60 ml·L^-1；上述添加剂均可明显降低中高温段的N₂O、CO排放，低温端则相反；N₂O、CO的排放随温度、添加剂种类及浓度的不同而呈现各自的变化趋势。

关键词: 污染, NO_xOUT, 脱除特点, 温室气体, N₂O, 添加剂, 动力学, 生成规律

Abstract: An experiment was performed to study the removal of NO_x pollution and formation of greenhouse gas (N₂O) and CO in NO_xOUT process. Kinetic analysis was combined with the experiment results to discuss the effect of additives. The optimum reaction temperature was 950℃ and the highest denitration efficiency could reach 76.33% with different normalized stoichimetric ratios (NSR). The formation curves of N₂O with temperature were similar to the efficiency curve and N₂O emission reached a peak value at the temperature around 950℃. Increasing NSR and O₂ concentration made N₂O emission level higher. N₂O emission first increased and then decreased with increasing residence time at higher temperatures (950℃,1000℃). Sodium carbonate, sodium acetate, sodium glutamate and ethanol could effectively improve the denitration efficiency on the low temperature side and extend corresponding temperature window, especially obviously for sodium glutamate. Denitration efficiency was related to temperature when altering the concentration of sodium salts and the optimum addition amount was 60 ml·L^-1 for sodium atom. Above-mentioned additives could all remarkably reduce the emission of N₂O and CO at medium and high temperatures, but adversely at the end point of low temperature. N₂O and CO emission presented respective variation trends with the differences of temperature, type and concentartion of additives.

Key words: pollution, NO_xOUT, removal characteristic, greenhouse gas, N₂O, additive, kinetics, formation rule

中图分类号:

X511

周昊, 张志中, 鲍强, 刘建成, 岑可法. 添加剂对NO_xOUT脱硝及N₂O、CO生成的影响特性[J]. 化工学报, 2014, 65(6): 2232-2240.

ZHOU Hao, ZHANG Zhizhong, BAO Qiang, LIU Jiancheng, CEN Kefa. Influence of additives on NO_xOUT denitration and formation of N₂O and CO[J]. CIESC Journal, 2014, 65(6): 2232-2240.

参考文献 29

[1]	Lü Hongkun(吕洪坤),Yang Weijuan(杨卫娟),Zhou Junhu(周俊虎),Cen Kefa(岑可法),Zhang Ming(张明),Li Fengrui(李凤瑞).Experimental study and mechanism analysis on selective non-catalytic reduction reactions[J].Power System Engineering(电站系统工程),2011,27(2):4-7
[2]	Zhong Zhaoping(仲兆平),Liang Xiujin(梁秀进),Jin Baosheng(金宝升),Chen Xiaolin(陈晓林),Zhang Jubing(张居兵).Experimental study of influence of sodium acetate additive to NOxOUT process[J].Journal of Southeast University(东南大学学报),2010,40(5):997-1002
[3]	Li Qiong(李穹),Wu Yuxin(吴玉新),Yang Hairui(杨海瑞),Lü Junfu(吕俊复). Simulation and optimization of SNCR process[J].CIESC Journal(化工学报),2013,64(5):1789-1795
[4]	Maria Jose Fernandez Gutierrez,David Baxter,Christopher Hunter,Karel Svoboda.Nitrous oxide (N2O) emissions from waste and biomass to energy plants[J].Waste Management & Research,2005,23(2):133-147
[5]	Bernhard Bonn,Gudrun Pelz,Herbert Baumann.Formation and decomposition of N2O in fluidized bed boilers[J].Fuel,1995,74(2):165-170
[6]	Loeffler G,Wartha C,Winter F,Hofbauer H.Study on NO and N2O formation and destruction mechanisms in a laboratory-scale fluidized bed[J].Energy & Fuels,2002,16:1024-1032
[7]	Shen B X,Mi T,Liu D C,Feng B,Yao Q,Franz Winter. N2O emission under fluidized bed combustion condition[J]. Fuel Processing Technology,2003,84:13-21
[8]	Shen Laihong(沈来宏),Yoshizo Suzuki(铃木善三).Experimental study on N2O formation and reduction in fluidized bed combustion[J]. Proceedings of the CSEE(中国电机工程学报),1999,19(1):47-51
[9]	Zhou Haosheng(周浩生),Lu Jidong(陆继东),Zhou Hu(周琥). The reduction of nitrogen oxides N2O/NO in the presence of Fe, its oxides, and CO in fluidized bed combustion of coal[J]. Proceedings of the CSEE(中国电机工程学报),2001,21(1):44-47
[10]	Wang Wenxuan(王文选),Wang Fengjun(王凤君),Han Song(韩松),Chen Chuanmin(陈传敏),Zhao Changsui(赵长遂),Yue Guangxi(岳光溪). A research on N2O emission of petroleum coke combustion blending with coal in CFB[J].Proceedings of the CSEE(中国电机工程学报),2004,24(7):236-240
[11]	Wang Qimin(王启民),Li Yuan(李源),Yang Hairui(杨海瑞),Lü Junfu(吕俊复).Generation, digestion and control of N2O in circulating fluidized bed boiler using coal[J]. Journal of Shenyang Institute of Engineering(沈阳工程学院学报),2007,3(2):108-111
[12]	Carton J A,Narney II J K,Cariappa C,Laster W R.The selective non-catalytic reduction of nitric oxide using ammonia at up to 15% oxygen[J]. Canadian Journal of Chemical Engineering,1995,73(3):345-350
[13]	Alzueta M U,Bilbao R,Millera A,Oliva M,Ibanez J C.Interactions between nitric oxide and urea under flow reactor conditions[J]. Energy & Fuels,1998,12:1001-1007
[14]	Zhou Junhu(周俊虎),Yang Weijuan(杨卫娟),Zhou Zhijun(周志军),Cen Kefa(岑可法). Nitrous oxide formation and emission in selective non-catalytic reduction process[J].Proceedings of the CSEE(中国电机工程学报),2005,25(13):91-95
[15]	Lu Zhimin(卢志民),Zhou Junhu(周俊虎),Cen Kefa(岑可法),Lu Jidong(陆继东).Flow reactor experiments and kinetics modeling on selective non-catalytic removal of NOx under different O2 atmospheres[J]. Proceedings of the CSEE(中国电机工程学报),2008,28(29):78-82
[16]	Renato Rota,Dorota Antos,Everton F Zanoelo,et al.Experimental and modeling analysis of the NOxOUT process[J]. Chemical Engineering Science,2002,57:27-38
[17]	Lü Hongkun(吕洪坤),Yang Weijuan(杨卫娟),Zhou Junhu(周俊虎),Zhou Zhijun(周志军),Huang Zhenyu(黄镇宇),Cen Kefa(岑可法). Impact of NSR and atomization pressure on SNCR used in power plant boiler[J]. Journal of Chemical Industry and Engineering(China)(化工学报),2008,59(11):2898-2903
[18]	Rota R,Zanoelo E F.Influence of oxygenated additives on the NOxOUT process efficiency[J]. Fuel,2003,82:765-770
[19]	Lee S,Park K,Park J W,Kim B H. Characteristics of reducing NO using urea and alkaline additives[J]. Combustion and Flame,2005,141:200-203
[20]	Niu Shengli,Han Kuihua,Lu Chunmei.An experimental study on the effect of operating parameters and sodium additive on the NOxOUT process[J]. Process Safety and Environmental Protection,2011,89:121-126
[21]	Javed M T,Nimmo W,Mahmood A,Irfan N.Effect of oxygenated liquid additives on the urea based SNCR process[J]. Journal of Environmental Management,2009,90:3429-3435
[22]	Yang Weijuan,Zhou Junhu,Zhou Zhijun,et al.Action of oxygen and sodium carbonate in the urea-SNCR process[J]. Combustion and Flame,2009,156:1785-1790
[23]	Zamansky V M,Lissianski V V,Maly P M,et al.Reactions of sodium species in the promoted SNCR process[J]. Combustion and Flame,1999,117(4):821-831
[24]	Han Kuihua,Lu Chunmei.Kinetic model and simulation of promoted selective non-catalytic reduction by sodium carbonate[J]. Chinese Journal of Chemical Engineering,2007,15(4):512-519
[25]	Han Kuihua(韩奎华),Lu Chunmei(路春美),Wang Yongzheng(王永征),Niu Shengli(牛胜利),Liu Zhichao(刘志超),Hao Weidong(郝卫东).Experimental study on de-NOx characteristics of selective non-catalytic reduction[J]. Proceedings of the CSEE(中国电机工程学报),2008,28(14):80-85
[26]	Tayye Javed M,Naseem Irfan,Gibbs B M. Control of combustion-generated nitrogen oxides by selective non-catalytic reduction[J]. Journal of Environmental Management,2007,83:251-289
[27]	Lü Hongkun(吕宏坤). Experimental and mechanism study on selective non-catalytic reduction and advanced reburning[D]. Hangzhou:Zhejiang University,2008
[28]	Zhang Wei(张薇).Study on the effect and reaction mechanism of additives on the selctive non-catalytic reduction[D]. Hangzhou:Zhejiang University,2008
[29]	Liang Xiujin,Zhong Zhaoping,Jin Baosheng,et al.Experimental study of the influence of sodium salts as additive to NOxOUT process[J].Chemical Engineering,2010,27(5):1483-1491

添加剂对NO_xOUT脱硝及N₂O、CO生成的影响特性

Influence of additives on NO_xOUT denitration and formation of N₂O and CO

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 29

相关文章 15

编辑推荐

Metrics

本文评价

[1]	金正浩, 封立杰, 李舒宏. 氨水溶液交叉型再吸收式热泵的能量及分析[J]. 化工学报, 2023, 74(S1): 53-63.
[2]	程成, 段钟弟, 孙浩然, 胡海涛, 薛鸿祥. 表面微结构对析晶沉积特性影响的格子Boltzmann模拟[J]. 化工学报, 2023, 74(S1): 74-86.
[3]	肖明堃, 杨光, 黄永华, 吴静怡. 浸没孔液氧气泡动力学数值研究[J]. 化工学报, 2023, 74(S1): 87-95.
[4]	毕丽森, 刘斌, 胡恒祥, 曾涛, 李卓睿, 宋健飞, 吴翰铭. 粗糙界面上纳米液滴蒸发模式的分子动力学研究[J]. 化工学报, 2023, 74(S1): 172-178.
[5]	于宏鑫, 邵双全. 水结晶过程的分子动力学模拟分析[J]. 化工学报, 2023, 74(S1): 250-258.
[6]	范孝雄, 郝丽芳, 范垂钢, 李松庚. LaMnO₃/生物炭催化剂低温NH₃-SCR催化脱硝性能研究[J]. 化工学报, 2023, 74(9): 3821-3830.
[7]	杨百玉, 寇悦, 姜峻韬, 詹亚力, 王庆宏, 陈春茂. 炼化碱渣湿式氧化预处理过程DOM的化学转化特征[J]. 化工学报, 2023, 74(9): 3912-3920.
[8]	郑佳丽, 李志会, 赵新强, 王延吉. 离子液体催化合成2-氰基呋喃反应动力学研究[J]. 化工学报, 2023, 74(9): 3708-3715.
[9]	汪林正, 陆俞冰, 张睿智, 罗永浩. 基于分子动力学模拟的VOCs热氧化特性分析[J]. 化工学报, 2023, 74(8): 3242-3255.
[10]	吕龙义, 及文博, 韩沐达, 李伟光, 高文芳, 刘晓阳, 孙丽, 王鹏飞, 任芝军, 张光明. 铁基导电材料强化厌氧去除卤代有机污染物：研究进展及未来展望[J]. 化工学报, 2023, 74(8): 3193-3202.
[11]	曾如宾, 沈中杰, 梁钦锋, 许建良, 代正华, 刘海峰. 基于分子动力学模拟的Fe₂O₃纳米颗粒烧结机制研究[J]. 化工学报, 2023, 74(8): 3353-3365.
[12]	李锦潼, 邱顺, 孙文寿. 煤浆法烟气脱硫中草酸和紫外线强化煤砷浸出过程[J]. 化工学报, 2023, 74(8): 3522-3532.
[13]	杨菲菲, 赵世熙, 周维, 倪中海. Sn掺杂的In₂O₃催化CO₂选择性加氢制甲醇[J]. 化工学报, 2023, 74(8): 3366-3374.
[14]	杨越, 张丹, 郑巨淦, 涂茂萍, 杨庆忠. NaCl水溶液喷射闪蒸-掺混蒸发的实验研究[J]. 化工学报, 2023, 74(8): 3279-3291.
[15]	张蒙蒙, 颜冬, 沈永峰, 李文翠. 电解液类型对双离子电池阴阳离子储存行为的影响[J]. 化工学报, 2023, 74(7): 3116-3126.