超临界二氧化碳在微细管内的换热特性

doi:10.3969/j.issn.0438-1157.2014.z1.052

化工学报 ›› 2014, Vol. 65 ›› Issue (S1): 323-327.DOI: 10.3969/j.issn.0438-1157.2014.z1.052

超临界二氧化碳在微细管内的换热特性

王珂, 谢金, 刘遵超, 刘彤, 马璐

郑州大学河南省过程换热与节能重点实验室, 河南郑州 450002

收稿日期:2014-02-17 修回日期:2014-02-27 出版日期:2014-05-30 发布日期:2014-05-30
通讯作者: 刘遵超
基金资助:
国家自然科学基金项目（51376163）。

Heat transfer characteristics of supercritical carbon dioxide in a micro-capillary tube

WANG Ke, XIE Jin, LIU Zunchao, LIU Tong, MA Lu

Key Laboratory of Process Heat Transfer and Energy Saving of Henan Province, Zhengzhou University, Zhengzhou 450002, Henan, China

Received:2014-02-17 Revised:2014-02-27 Online:2014-05-30 Published:2014-05-30
Supported by:
supported by the National Natural Science Foundation of China (51376163).

摘要/Abstract

摘要： 建立了内径为1.31 mm单管的三维模型，使用CFD软件Fluent分析了超临界二氧化碳在竖直微细管道内的换热特性，并对热通量、进口质量流速、流动方向和压力对超临界二氧化碳换热和压降的影响进行了研究。数值结果表明：增加进口质量流量能够使壁面边界层减薄，增强换热效果。改变热通量的大小对超临界二氧化碳换热和压降影响很小。由于重力和浮升力的影响，流动方向对换热性能的影响较大，流体竖直向上流动时的传热系数大于竖直向下和水平方向流动时的传热系数。

关键词: 超临界二氧化碳, 微细管, 流动, 换热, 数值模拟, 计算流体力学

Abstract: Three-dimensional model of single tube with an inner diameter of 1.31 mm was established; using CFD software Fluent, the flow and heat transfer characteristics of supercritical carbon dioxide in the micro-capillary tube was analyzed. The influences of the heat flux, inlet mass flow rate, flow direction and pressure on the heat transfer of supercritical carbon dioxide and pressure drop are analyzed. It was shown that: boundary wall thinning by increasing the import mass flow rate; which could enhance heat transfer. Changing the heat flux has little influence on heat transfer and pressure drop of supercritical carbon dioxide. Due to the effects of gravity and buoyancy, the impact of the flow direction on the heat transfer performance was large; the heat transfer coefficient of vertically upward fluid flow is greater than that of the vertical downward flows and horizontal flow.

Key words: supercritical carbon dioxide, micro-capillary tube, flow, heat transfer, numerical simulation, CFD

中图分类号:

TB657

王珂, 谢金, 刘遵超, 刘彤, 马璐. 超临界二氧化碳在微细管内的换热特性[J]. 化工学报, 2014, 65(S1): 323-327.

WANG Ke, XIE Jin, LIU Zunchao, LIU Tong, MA Lu. Heat transfer characteristics of supercritical carbon dioxide in a micro-capillary tube[J]. CIESC Journal, 2014, 65(S1): 323-327.

参考文献 12

[1]	Lorentzen G. Revival of carbon dioxide as a refrigerant(Ⅰ)[J].H & V Engineer, 1993, 66(721): 9-14
[2]	Lorentzen G. Revival of carbon dioxide as a refrigerant(Ⅱ)[J]. H & V Engineer, 1993, 66(722): 10-12
[3]	Dong Qiwu(董其伍), Zhao Songwei(赵松伟), Liu Minshan(刘敏珊). The analysis study of supercritical carbon dioxide flow and heat transfer characteristics in tube[J]. Refrigeration and Air-conditioning(制冷与空调), 2008, 22(1): 1-5
[4]	Zhang Lina(张丽娜), Liu Minshan(刘敏珊), Dong Qiwu(董其伍). Convective heat transfer of supercritical carbon dioxide in D-shape tube[J]. Journal of Nanjing University of Technology(南京工业大学学报), 2009, 31(5): 42-46
[5]	Huai Xiulan, Shigeru Koyama. Heat transfer and pressure drop of supercritical carbon dioxide in multi-port channels [J]. Journal of Engineering Thermo-Physics, 2004, 25(5): 843-845
[6]	Tao Wenquan(陶文铨). Numerical Heat Transfer (数值换热学) [M]. 2nd ed. Xian: Xian Jiaotong University Press, 2001: 362-369
[7]	Wang Ruijin(王瑞金), Zhang Kai (张凯), Wang Gang(王刚). Fluent Fundamental and Applied Examples (Fluent 技术基础与应用实例)[M]. Beijing: Tsinghua University Press, 2008
[8]	Dang Chaobin, Hihara Eijin. In-tube cooling heat transfer of supercritical carbon dioxide(I): Experimental measurement[J]. Int. J. Refrig.,2004(27): 736-747
[9]	Liao S M, Zhao T S. Measurements of heat transfer coefficients from supercritical carbon dioxide flowing in horizontal mini/macro channels[J].Journal of Heat Transfer, 2002,124(3):413-419
[10]	Liao S M, Zhao T S. An experimental investigation of convection heat transfer to supercritical carbon dioxide in miniature tubes[J]. International of Heat and Mass Transfer, 2002,45: 5025-5034
[11]	Liao S M,Zhao T S. A numerical solution to Laminar forced convection of supercritical carbon dioxide in small diameter tubes//Pro. Fifth International Symposium on Heat Transfer[C]. Beijing, 2000, 12-16(8): 592-597
[12]	Gnielinski V. New equations for heat and mass transfer in turbulent pipe and channel flow [J].Int. Chem. Eng.,1976,16:359-368

[1]	周绍华, 詹飞龙, 丁国良, 张浩, 邵艳坡, 刘艳涛, 郜哲明. 短管节流阀内流动噪声的实验研究及降噪措施[J]. 化工学报, 2023, 74(S1): 113-121.
[2]	叶展羽, 山訸, 徐震原. 用于太阳能蒸发的折纸式蒸发器性能仿真[J]. 化工学报, 2023, 74(S1): 132-140.
[3]	张龙, 宋孟杰, 邵苛苛, 张旋, 沈俊, 高润淼, 甄泽康, 江正勇. 管翅式换热器迎风侧翅片末端霜层生长模拟研究[J]. 化工学报, 2023, 74(S1): 179-182.
[4]	张义飞, 刘舫辰, 张双星, 杜文静. 超临界二氧化碳用印刷电路板式换热器性能分析[J]. 化工学报, 2023, 74(S1): 183-190.
[5]	王志国, 薛孟, 董芋双, 张田震, 秦晓凯, 韩强. 基于裂隙粗糙性表征方法的地热岩体热流耦合数值模拟与分析[J]. 化工学报, 2023, 74(S1): 223-234.
[6]	邹启宏, 李乾, 葛天舒. 基于多目标下的两级并联除湿热泵系统实验研究[J]. 化工学报, 2023, 74(S1): 265-271.
[7]	宋嘉豪, 王文. 斯特林发动机与高温热管耦合运行特性研究[J]. 化工学报, 2023, 74(S1): 287-294.
[8]	张思雨, 殷勇高, 贾鹏琦, 叶威. 双U型地埋管群跨季节蓄热特性研究[J]. 化工学报, 2023, 74(S1): 295-301.
[9]	肖明堃, 杨光, 黄永华, 吴静怡. 浸没孔液氧气泡动力学数值研究[J]. 化工学报, 2023, 74(S1): 87-95.
[10]	宋瑞涛, 王派, 王云鹏, 李敏霞, 党超镔, 陈振国, 童欢, 周佳琦. 二氧化碳直接蒸发冰场排管内流动沸腾换热数值模拟分析[J]. 化工学报, 2023, 74(S1): 96-103.
[11]	温凯杰, 郭力, 夏诏杰, 陈建华. 一种耦合CFD与深度学习的气固快速模拟方法[J]. 化工学报, 2023, 74(9): 3775-3785.
[12]	王玉兵, 李杰, 詹宏波, 朱光亚, 张大林. R134a在菱形离散肋微小通道内的流动沸腾换热实验研究[J]. 化工学报, 2023, 74(9): 3797-3806.
[13]	何松, 刘乔迈, 谢广烁, 王斯民, 肖娟. 高浓度水煤浆管道气膜减阻两相流模拟及代理辅助优化[J]. 化工学报, 2023, 74(9): 3766-3774.
[14]	邢雷, 苗春雨, 蒋明虎, 赵立新, 李新亚. 井下微型气液旋流分离器优化设计与性能分析[J]. 化工学报, 2023, 74(8): 3394-3406.
[15]	韩晨, 司徒友珉, 朱斌, 许建良, 郭晓镭, 刘海峰. 协同处理废液的多喷嘴粉煤气化炉内反应流动研究[J]. 化工学报, 2023, 74(8): 3266-3278.

超临界二氧化碳在微细管内的换热特性

Heat transfer characteristics of supercritical carbon dioxide in a micro-capillary tube

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 12

相关文章 15

编辑推荐

Metrics

本文评价