气固两相流穿越液池过程颗粒运动及分布特性

doi:10.11949/j.issn.0438-1157.20141596

化工学报 ›› 2015, Vol. 66 ›› Issue (3): 905-914.DOI: 10.11949/j.issn.0438-1157.20141596

气固两相流穿越液池过程颗粒运动及分布特性

吴晅^1,2, 梁盼龙², 王丽芳², 李海广¹, 武文斐¹

1 内蒙古科技大学内蒙古自治区白云鄂博矿多金属资源综合利用重点实验室, 内蒙古包头 014010;
2 内蒙古科技大学能源与环境学院, 内蒙古包头 014010

收稿日期:2014-10-23 修回日期:2014-12-15 出版日期:2015-03-05 发布日期:2015-03-05
通讯作者: 吴晅
基金资助:
国家自然科学基金项目(51166010);内蒙古自治区自然科学基金项目(2014MS0530);内蒙古科技大学创新基金项目(2011NCL020)。

Distribution properties and movement of particles in gas-solids flow passing through liquid bath

WU Xuan^1,2, LIANG Panlong², WANG Lifang², LI Haiguang¹, WU Wenfei¹

1 Inner Mongolia Key Laboratory of Integrated Exploitation of Bayan Obo Multi-Metallic Resources, Inner Mongolia University of Science and Technology, Baotou 014010, Inner Mongolia, China;
2 School of Energy and Environment, Inner Mongolia University of Science and Technology, Baotou 014010, Inner Mongolia, China

Received:2014-10-23 Revised:2014-12-15 Online:2015-03-05 Published:2015-03-05
Supported by:
supported by the National Natural Science Foundation of China (51166010), the Natural Science Foundation of Inner Mongolia (2014MS0530) and the Innovation Fund of Inner Mongolia University of Science and Technology (2011NCL020).

摘要/Abstract

摘要：

为了揭示气固两相流穿越液池过程中的气液固三相流动特性,建立了气液固三相实验平台和基于Euler-Lagrange框架下的数值模拟平台,对该过程中的气液固三相流动过程及颗粒运动分布规律进行研究。获得了5～15 μm、80～110 μm和380～530 μm 3种典型粒径颗粒在三相体系中的微观运动过程及其分布规律。实验与数值模拟结果均能反映出一致的客观规律。研究发现,颗粒浓度沿液池高度方向和径向均呈现多峰分布特征;5～15 μm粒径颗粒更易跟随气体一起穿越液池,其在液池内的浓度分布较为均匀;380～530 μm粒径颗粒与气体的跟随性较差,其浓度峰值主要集中在液池底部。随着下降管出口静态浸没深度的增加,液池内颗粒浓度分布趋于平缓。

关键词: 液池, 多相流, 分布, 数值模拟

Abstract:

In order to study the flow characteristic of gas-liquid-solids three-phase in the process of gas-solids two-phase flow passing through the liquid bath, an experimental platform and a numerical simulation platform based on the Euler-Lagrange method were established respectively to conduct the studies on three-phase flow and particles movement. The distribution characteristics and the movement of three typical particle sizes were obtained, such as 5—15 μm, 80—110 μm and 380—530 μm. The results of experiment were consistent with the results of numerical simulation. A multi-peak distribution of particle concentration existed in the liquid bath along the axial and radial directions. The particles of 5—15 μm in diameter were more easy to follow gas, and their distribution was more uniform. The particles of 380—530 μm in diameter were more difficult to follow gas, and their distribution was mainly concentrated at the bottom of the liquid bath. The increase of static submerged depth of downcomer outlet made the concentration distribution of particles more smoothly in the liquid bath.

Key words: liquid bath, multiphase flow, distribution, numerical simulation

中图分类号:

TQ021.1

吴晅, 梁盼龙, 王丽芳, 李海广, 武文斐. 气固两相流穿越液池过程颗粒运动及分布特性[J]. 化工学报, 2015, 66(3): 905-914.

WU Xuan, LIANG Panlong, WANG Lifang, LI Haiguang, WU Wenfei. Distribution properties and movement of particles in gas-solids flow passing through liquid bath[J]. CIESC Journal, 2015, 66(3): 905-914.

参考文献 22

[1]	Wang Fuchen (王辅臣), Yu Guangsuo (于广锁), Gong Xin (龚欣), et al. Research and development of large-scale coal gasification technology [J]. Chemical Industry and Engineering Progress (化工进展), 2009, 28 (2): 173-180
[2]	Jiang Han (江瀚), Liu Zhongliang (刘中良), Gong Xiaolong (宫小龙). Thermal economics and application of pressurized submerged combustion evaporators [J]. CIESC Journal (化工学报), 2011, 62 (12): 3498-3502
[3]	Vaibhav K A, Ashwani K G. Jet characteristics from a submerged combustion system [J]. Applied Energy, 2012, 89: 246-253
[4]	Wang Rongdong (王荣东), Du Hai'ou (杜海鸥), Gao Yaopeng (高耀鹏), et al. The experimental study on sodium aerosol removal efficiency of water bath scrubber [J]. Nuclear Science and Engineering (核科学与工程), 2012, 32 (4): 319-325
[5]	Wu Xuan (吴晅), Gao Huijie (高慧杰), Li Haiguang (李海广), Wu Wenfei (武文斐). Bubble characteristics of syngas during passing through cistern in gasifier [J]. Journal of Chinese Society of Power Engineering (动力工程学报), 2013, 33 (12): 972-968
[6]	Fu Bihua (付碧华), Wang Yifei (王亦飞), Lin Lan (林岚), Xu Jianliang (许建良), et al. Penetration depth and characteristics of interface fluctuation at quenching pipe outlet [J]. CIESC Journal (化工学报), 2011, 62 (7): 1817-1823
[7]	He Biyun (贺必云). Study on multiphase flow characteristics of the new type of scrubbing-cooling chamber [D]. Shanghai: East China University of Science & Technology, 2005: 11-19
[8]	Xu Yonggui, Liu Mingyan, Tang Can. Three-dimensional CFD-VOF-DPM simulations of effects of low-holdup particles on single-nozzle bubbling behavior in gas-liquid-solid systems [J]. Chemical Engineering Journal, 2013, 222: 292-306
[9]	Baltussen M W, Seelen L J H, Kuipers J A M, Deen N G. Direct numerical simulations of gas-liquid-solid three phase flows [J]. Chemical Engineering Science, 2013, 100: 293-299
[10]	Chen Min (陈敏), Yuan Zhulin (袁竹林), Gao Shiwang (郜时旺). Direct numerical simulation and experimental contrast of the moving granular bed dust filter [J]. Proceedings of the CSEE (中国电机工程学报), 2003, 23 (11): 195-199
[11]	Cai Guiying (蔡桂英), Yuan Zhulin (袁竹林). A study on the filtration performance of ceramic filter by numerical simulation [J]. Proceedings of the CSEE (中国电机工程学报), 2003, 23 (12): 203-207
[12]	Brackbill J U. A continuum method for modeling surface tension [J]. Journal of Computational Physics, 1992, 100 (3): 335-354
[13]	Ouyang J, Li J H. Particle-motion-resolved discrete model for simulating gas-solid fluidization [J]. Chemical Engineering Science, 1999, 54 (13): 2077-2083
[14]	Xiong Y Q, Zhang M Y, Yuan Z L. Three-dimensional numerical simulation method for gas-solid injector [J]. Powder Technology, 2005, 160 (2): 180-189
[15]	Kafui K D, Thornton C, Adams M J. Discrete particle-continuum fluid modeling of gas-solid fluidized beds [J]. Chemical Engineering Science, 2002, 57 (13): 2395-2410
[16]	Zou L M, Guo Y C, Chan C K. Cluster-based drag coefficient model for simulating gas-solid flow in a fast-fluidized bed [J]. Chemical Engineering Science, 2008, 63 (4): 1052-1061
[17]	Zhang Jianping, Fan L S, Chou Zhu, et al. Dynamic behavior of collision of elastic spheres in viscous fluids [J]. Powder Technology, 1999, 106 (1/2): 98-109
[18]	Zhang Jianping, Li Yong, Fan Liang-Shih. Discrete phase simulation of gas-liquid-solid fluidization systems: single bubble rising behavior [J]. Powder Technology, 2000, 113 (3): 310-326
[19]	Tsuji Y, Tanaka T. Cluster patterns in circulating fluidized beds predicted by numerical simulation (discrete particle model versus two-fluid model) [J]. Powder Technology, 1998, 95 (3): 254-264
[20]	Li Jinghai (李静海), Ouyang Jie (欧阳洁), Gao Shiqiu (高士秋), et al. Multi-scale Simulation of Complex System of Particle Fluid (颗粒流体复杂系统的多尺度模拟) [M]. Beijing: Science Press, 2005: 221
[21]	Rouhani S Z. Two-phase flow patterns: a review of research results [J]. Progress in Nuclear Energy, 1983, 11 (3): 219-259
[22]	Wu Xuan (吴晅), Wang Lifang (王丽芳), Gao Huijie (高慧杰), et al. Numerical simulation of the initial impact behavioral characteristics during top-submerged gas injection [J]. Boiler Technology (锅炉技术), 2013, 44 (3): 1-5

气固两相流穿越液池过程颗粒运动及分布特性

Distribution properties and movement of particles in gas-solids flow passing through liquid bath

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 22

相关文章 15

编辑推荐

Metrics

本文评价

[1]	宋嘉豪, 王文. 斯特林发动机与高温热管耦合运行特性研究[J]. 化工学报, 2023, 74(S1): 287-294.
[2]	张思雨, 殷勇高, 贾鹏琦, 叶威. 双U型地埋管群跨季节蓄热特性研究[J]. 化工学报, 2023, 74(S1): 295-301.
[3]	连梦雅, 谈莹莹, 王林, 陈枫, 曹艺飞. 地下水预热新风一体化热泵空调系统制热性能研究[J]. 化工学报, 2023, 74(S1): 311-319.
[4]	宋瑞涛, 王派, 王云鹏, 李敏霞, 党超镔, 陈振国, 童欢, 周佳琦. 二氧化碳直接蒸发冰场排管内流动沸腾换热数值模拟分析[J]. 化工学报, 2023, 74(S1): 96-103.
[5]	叶展羽, 山訸, 徐震原. 用于太阳能蒸发的折纸式蒸发器性能仿真[J]. 化工学报, 2023, 74(S1): 132-140.
[6]	邵苛苛, 宋孟杰, 江正勇, 张旋, 张龙, 高润淼, 甄泽康. 水平方向上冰中受陷气泡形成和分布实验研究[J]. 化工学报, 2023, 74(S1): 161-164.
[7]	张义飞, 刘舫辰, 张双星, 杜文静. 超临界二氧化碳用印刷电路板式换热器性能分析[J]. 化工学报, 2023, 74(S1): 183-190.
[8]	王志国, 薛孟, 董芋双, 张田震, 秦晓凯, 韩强. 基于裂隙粗糙性表征方法的地热岩体热流耦合数值模拟与分析[J]. 化工学报, 2023, 74(S1): 223-234.
[9]	李艺彤, 郭航, 陈浩, 叶芳. 催化剂非均匀分布的质子交换膜燃料电池操作条件研究[J]. 化工学报, 2023, 74(9): 3831-3840.
[10]	王浩, 王振雷. 基于自适应谱方法的裂解炉烧焦模型化简策略[J]. 化工学报, 2023, 74(9): 3855-3864.
[11]	何松, 刘乔迈, 谢广烁, 王斯民, 肖娟. 高浓度水煤浆管道气膜减阻两相流模拟及代理辅助优化[J]. 化工学报, 2023, 74(9): 3766-3774.
[12]	邢雷, 苗春雨, 蒋明虎, 赵立新, 李新亚. 井下微型气液旋流分离器优化设计与性能分析[J]. 化工学报, 2023, 74(8): 3394-3406.
[13]	韩晨, 司徒友珉, 朱斌, 许建良, 郭晓镭, 刘海峰. 协同处理废液的多喷嘴粉煤气化炉内反应流动研究[J]. 化工学报, 2023, 74(8): 3266-3278.
[14]	杨越, 张丹, 郑巨淦, 涂茂萍, 杨庆忠. NaCl水溶液喷射闪蒸-掺混蒸发的实验研究[J]. 化工学报, 2023, 74(8): 3279-3291.
[15]	程小松, 殷勇高, 车春文. 不同工质在溶液除湿真空再生系统中的性能对比[J]. 化工学报, 2023, 74(8): 3494-3501.