甲烷与正丁烷微小尺度催化燃烧性能比较

doi:10.11949/j.issn.0438-1157.20161322

化工学报 ›› 2017, Vol. 68 ›› Issue (3): 896-902.DOI: 10.11949/j.issn.0438-1157.20161322

• 催化、动力学与反应器 • 上一篇下一篇

甲烷与正丁烷微小尺度催化燃烧性能比较

王业峰, 周俊虎, 赵庆辰, 杨卫娟, 周靖松, 张彦威

浙江大学能源清洁利用国家重点实验室, 浙江杭州 310027

收稿日期:2016-09-21 修回日期:2016-11-21 出版日期:2017-03-05 发布日期:2017-03-05
通讯作者: 杨卫娟,yangwj@zju.edu.cn
基金资助:
国家自然科学基金项目（51336010）；中央高校基本科研业务费专项资金项目（2016FZA4011）。

Comparison of catalytic combustion of methane and n-butane in microtube

WANG Yefeng, ZHOU Junhu, ZHAO Qingchen, YANG Weijuan, ZHOU Jingsong, ZHANG Yanwei

State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, Zhejiang, China

Received:2016-09-21 Revised:2016-11-21 Online:2017-03-05 Published:2017-03-05
Contact: 10.11949/j.issn.0438-1157.20161322
Supported by:
supported by the National Natural Science Foundation of China (51336010) and the Fundamental Research Funds for the Central Universities (2016FZA4011).

摘要/Abstract

摘要：

对微圆管内甲烷和正丁烷在Pt/ZSM-5上的催化燃烧进行实验研究，获得并分析了二者的稳燃范围、产物浓度、壁温分布和壁面散热等燃烧性能。发现在富燃条件下甲烷和正丁烷能够在大当量比下实现催化自稳燃烧。相同流量下正丁烷稳燃当量比范围宽于甲烷，贫燃范围在0.4附近。流量由200 ml·min^-1增大至1000 ml·min^-1，甲烷和正丁烷转化率出现大幅下降。在实验范围内，正丁烷和甲烷的转化率差异不大。化学当量比条件下随流量增大，正丁烷的转化率在600 ml·min^-1开始高于甲烷。甲烷和正丁烷能够在散热比例高达70%的情况下自稳催化燃烧且转化率在95%以上。相同流量下，与甲烷相比，正丁烷催化燃烧的壁温、散热功率和散热比例都更高。整体来看，正丁烷催化稳燃范围较甲烷略宽，两者转化率曲线相近，放热功率和壁面散热功率相差较小，正丁烷在必要时可作为甲烷的替代燃料。

关键词: 甲烷, 正丁烷, 催化剂, 微尺度, 替代

Abstract:

Catalytic combustion of methane and n-butane with Pt/ZSM-5 in a microtube was studied on self-sustaining combustion limits, product concentrations, wall temperature, and surface heat loss. The catalytic combustion of methane and n-butane could be sustained at very high molar ratio (Φ) in rich burn condition. At the same flow rate, n-butane had broader self-sustaining combustion limit than methane with lean burn limit around 0.4. Conversion of the two fuels decreased steeply with flow rate increased from 200 to 1000 ml·min^-1, which were largely due to decrease of residence time and increase of weight hourly space velocity (WHSV). The combustion conversion of methane and n-butane showed minimal difference within the range of experiments. As a result of activation of gas-phase reactions posterior to catalyst and its feedback effect to catalytic reaction, n-butane had higher conversion than methane at the same chemical normality upon flow rate reaching to 600 ml·min^-1. Both methane and n-butane could have self-sustaining combustion with above 95% conversion even when ratio of through-wall heat loss to input power was reached to 70%. Compared to that of methane, n-butane combustion produced higher wall temperature, through-wall heat loss rate, and ratio of through-wall heat loss rate to input power, which was directly related to the activation of gas-phase reactions in n-butane combustion. Overall, considered broader combustion limit, similar conversion curve, minimal difference in heat generate rate and through-wall heat loss, n-butane could be an alternative fuel to methane when necessary.

Key words: methane, n-butane, catalyst, microscale, alternative

中图分类号:

TK16

王业峰, 周俊虎, 赵庆辰, 杨卫娟, 周靖松, 张彦威. 甲烷与正丁烷微小尺度催化燃烧性能比较[J]. 化工学报, 2017, 68(3): 896-902.

WANG Yefeng, ZHOU Junhu, ZHAO Qingchen, YANG Weijuan, ZHOU Jingsong, ZHANG Yanwei. Comparison of catalytic combustion of methane and n-butane in microtube[J]. CIESC Journal, 2017, 68(3): 896-902.

参考文献 30

[1]	JU Y, MARUTA K. Microscale combustion:technology development and fundamental research[J]. Fuel & Energy Abstracts, 2011, 37(6):669-715.
[2]	MIKAMI M, MAEDA Y, MATSUI K, et al. Combustion of gaseous and liquid fuels in meso-scale tubes with wire mesh[J]. Proceedings of the Combustion Institute, 2013, 34(2):3387-3394.
[3]	李军伟, 钟北京. 微细直管燃烧器的散热损失研究[J]. 中国电机工程学报, 2007, 27(20):59-64. LI J W, ZHONG B J. Investigation on heat loss of microtube combustor[J]. Proceedings of the CSEE, 2007, 27(20):59-64.
[4]	KAISARE N S, VLACHOS D G. A review on microcombustion:fundamentals, devices and applications[J]. Progress in Energy and Combustion Science, 2012, 38(3):321-359.
[5]	CHOU S K, YANG W M, CHUA K J, et al. Development of micro power generators-a review[J]. Applied Energy, 2011, 88(1):1-16.
[6]	邓元望, 刘放浪, 刘学英. 天然气及其在内燃机中的应用技术[J]. 拖拉机与农用运输车, 2004, (5):5-6. DENG Y W, LIU F L, LIU X Y. Natural gas and its application to engine[J]. Tractor & Farm Transporter, 2004, (5):5-6.
[7]	QU Z G, FENG X B. Catalytic combustion of premixed methane/air in a two-zone perovskite-based alumina pileup-pellets burner with different pellet diameters[J]. Fuel, 2015, 159:128-140.
[8]	周明月, 杨卫娟, 邓尘, 等. 微型圆管内氢气/甲烷/空气催化燃烧实验[J]. 浙江大学学报(工学版), 2015, 49(12):2276-2281. ZHOU M Y, YANG W J, DENG C, et al. Experiments on hydrogen/methane/air catalytic combustion in micro tube[J]. Journal of Zhejiang University (Engineering Science), 2015, 49(12):2276-2281.
[9]	张力, 闫云飞, 李丽仙, 等. 微型燃烧器内甲烷预混催化燃烧的数值研究[J]. 化工学报, 2009, 60(3):627-633. ZHANG L, YAN Y F, LI L X, et al. Numerical investigation of premixed catalytic combustion of methane in micro-combustor[J]. CIESC Journal, 2009, 60(3):627-633.
[10]	孙路石, 秦晓楠, 逄鹏, 等. La/Mn改性Pd/γ-Al2O3催化剂对甲烷催化燃烧的影响[J]. 中国电机工程学报, 2009, 29(11):26-31. SUN L S, QIN X N, PANG P, et al. Influence of Pd/γ-Al2O3 catalyst modified by La/Mn on methane catalytic combustion[J]. Proceedings of the CSEE, 2009, 29(11):26-31.
[11]	YANG H, FENG Y, WANG X, et al. OH-PLIF investigation of wall effects on the flame quenching in a slit burner[J]. Proceedings of the Combustion Institute, 2013, 34(2):3379-3386.
[12]	YAN Y, HUANG W, TANG W, et al. Numerical study on catalytic combustion and extinction characteristics of pre-mixed methane-air in micro flatbed channel under different parameters of operation and wall[J]. Fuel, 2016, 180:659-667.
[13]	LI Y H, CHEN G B, WU F H, et al. Effects of catalyst segmentation with cavities on combustion enhancement of blended fuels in a micro channel[J]. Combustion & Flame, 2012, 159(4):1644-1651.
[14]	BURCH R, CRITTLE D J, HAYES M J. C-H bond activation in hydrocarbon oxidation on heterogeneous catalysts[J]. Catalysis Today, 1999, 47(1/2/3/4):229-234.
[15]	CIMINO S, BENEDETTO A D, PIRONE R, et al. CO, H2 or C3H8 assisted catalytic combustion of methane over supported LaMnO3 monoliths[J]. Catalysis Today, 2003, 83(1):33-43.
[16]	DEMOULIN O, CLEF B L, NAVEZ M, et al. Combustion of methane, ethane and propane and of mixtures of methane with ethane or propane on Pd/γ-Al2O3 catalysts[J]. Applied Catalysis A General, 2008, 344(s1/2):1-9.
[17]	GOLODETS G I. Heterogeneous Catalytic Reactions Involving Molecular Oxygen[M]. Amsterdam·New York:Elsevier, 1983.
[18]	VESER G, ZIAUDDIN M, SCHMIDT L D. Ignition in alkane oxidation on noble-metal catalysts[J]. Catalysis Today, 1999, 47(1/2/3/4):219-228.
[19]	BEKAT T, INAL F. Effects of dimethyl ether on n-butane oxidation[J]. Fuel, 2014, 115(1):861-869.
[20]	ZHONG B J, FAN Y. Characteristics of hydrogen-assisted catalytic ignition of n-butane/air mixtures[J]. International Journal of Hydrogen Energy, 2012, 37(10):8716-8723.
[21]	胡二江, 黄佐华, 姜雪, 等. C1~C4烷烃预混层流燃烧与着火特性研究[J]. 工程热物理学报, 2013, 34(3):558-562. HU E J, HUANG Z H, JIANG X, et al. Kinetic study on laminar velocities and ignition delay time of C1-C4 alkanes[J]. Journal of Engineering Thermophysics, 2013, 34(3):558-562.
[22]	曹玉春, 冯珍珍, 李晓东. 丁烷层流预混火焰多环芳烃生成化学动力学模拟[J]. 中国电机工程学报, 2012, 32(8):71-77. CAO Y C, FENG Z Z, LI X D. Detailed chemical kinetic modeling of polycyclic aromatic hydrocarbons formation in a laminar premixed n-butane flame[J]. Proceedings of the CSEE, 2012, 32(8):71-77.
[23]	杨帆, 杨庆涛, 钟北京. 微尺度正丁烷催化反应的实验研究[J]. 工程热物理学报, 2009, 30(5):890-892. YANG F, YANG Q T, ZHONG B J. Experimental study on micro-scale n-butane catalytic reaction characteristics[J]. Journal of Engineering Thermophysics, 2009, 30(5):890-892.
[24]	DEUTSCHMANN O, SCHMIDT R, BEHRENDT F, et al. Numerical modeling of catalytic ignition[J]. Symposium on Combustion, 1970, 26(1):1747-1754.
[25]	XIN Y, WANG H, LAW C K. Kinetics of catalytic oxidation of methane, ethane and propane over palladium oxide[J]. Combustion & Flame, 2014, 161(4):1048-1054.
[26]	DENG C, YANG W, ZHOU J, et al. Catalytic combustion of methane, methanol, and ethanol in microscale combustors with Pt/ZSM-5 packed beds[J]. Fuel, 2015, 150:339-346.
[27]	熊鹏飞, 钟北京, 杨帆. C1~C4在Pt催化剂上的多相反应机理[J]. 物理化学学报, 2011, 27(9):2200-2208. XIONG P F, ZHONG B J, YANG F. Heterogeneous mechanism of C1-C4 on a platinum catalyst[J]. Acta Physico-Chimica Sinica, 2011, 27(9):2200-2208.
[28]	杨帆. 正丁烷的微尺度催化着火与燃烧[D]. 北京:清华大学, 2013. YANG F. Micro-scale catalytic ignition and combustion of n-butane[D]. Beijing:Tsinghua University, 2013
[29]	YANG W, WANG Y, ZHOU J, et al. Catalytic self-sustaining combustion of the alkanes with Pt/ZSM-5 packed bed in a microscale tube[J]. Chemical Engineering Science, 2017, 158:30-36.
[30]	LI J, ZHONG B. Experimental investigation on heat loss and combustion in methane/oxygen micro-tube combustor[J]. Applied Thermal Engineering, 2008, 28(7):707-716.

甲烷与正丁烷微小尺度催化燃烧性能比较

Comparison of catalytic combustion of methane and n-butane in microtube

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 30

相关文章 15

编辑推荐

Metrics

本文评价

[1]	高润淼, 宋孟杰, 高恩元, 张龙, 张旋, 邵苛苛, 甄泽康, 江正勇. 冷链装备制冷剂相关温室气体减排研究进展[J]. 化工学报, 2023, 74(S1): 1-7.
[2]	苏伟, 马东旭, 金旭, 刘忠彦, 张小松. 表面润湿性对霜层传递特性影响可视化实验研究[J]. 化工学报, 2023, 74(S1): 122-131.
[3]	李艺彤, 郭航, 陈浩, 叶芳. 催化剂非均匀分布的质子交换膜燃料电池操作条件研究[J]. 化工学报, 2023, 74(9): 3831-3840.
[4]	王玉兵, 李杰, 詹宏波, 朱光亚, 张大林. R134a在菱形离散肋微小通道内的流动沸腾换热实验研究[J]. 化工学报, 2023, 74(9): 3797-3806.
[5]	陈美思, 陈威达, 李鑫垚, 李尚予, 吴有庭, 张锋, 张志炳. 硅基离子液体微颗粒强化气体捕集与转化的研究进展[J]. 化工学报, 2023, 74(9): 3628-3639.
[6]	陈杰, 林永胜, 肖恺, 杨臣, 邱挺. 胆碱基碱性离子液体催化合成仲丁醇性能研究[J]. 化工学报, 2023, 74(9): 3716-3730.
[7]	杨学金, 杨金涛, 宁平, 王访, 宋晓双, 贾丽娟, 冯嘉予. 剧毒气体PH₃的干法净化技术研究进展[J]. 化工学报, 2023, 74(9): 3742-3755.
[8]	杨菲菲, 赵世熙, 周维, 倪中海. Sn掺杂的In₂O₃催化CO₂选择性加氢制甲醇[J]. 化工学报, 2023, 74(8): 3366-3374.
[9]	李凯旋, 谭伟, 张曼玉, 徐志豪, 王旭裕, 纪红兵. 富含零价钴活性位点的钴氮碳/活性炭设计及甲醛催化氧化应用研究[J]. 化工学报, 2023, 74(8): 3342-3352.
[10]	杨欣, 彭啸, 薛凯茹, 苏梦威, 吴燕. 分子印迹-TiO₂光电催化降解增溶PHE废水性能研究[J]. 化工学报, 2023, 74(8): 3564-3571.
[11]	余娅洁, 李静茹, 周树锋, 李清彪, 詹国武. 基于天然生物模板构建纳米材料及集成催化剂研究进展[J]. 化工学报, 2023, 74(7): 2735-2752.
[12]	刘晓洋, 喻健良, 侯玉洁, 闫兴清, 张振华, 吕先舒. 螺旋微通道对掺氢甲烷爆轰传播的影响[J]. 化工学报, 2023, 74(7): 3139-3148.
[13]	李盼, 马俊洋, 陈志豪, 王丽, 郭耘. Ru/α-MnO₂催化剂形貌对NH₃-SCO反应性能的影响[J]. 化工学报, 2023, 74(7): 2908-2918.
[14]	涂玉明, 邵高燕, 陈健杰, 刘凤, 田世超, 周智勇, 任钟旗. 钙基催化剂的设计合成及应用研究进展[J]. 化工学报, 2023, 74(7): 2717-2734.
[15]	张琦钰, 高利军, 苏宇航, 马晓博, 王翊丞, 张亚婷, 胡超. 碳基催化材料在电化学还原二氧化碳中的研究进展[J]. 化工学报, 2023, 74(7): 2753-2772.