管内垂直下降液膜速度与厚度分布特性

doi:10.11949/j.issn.0438-1157.20151953

化工学报 ›› 2016, Vol. 67 ›› Issue (6): 2239-2245.DOI: 10.11949/j.issn.0438-1157.20151953

管内垂直下降液膜速度与厚度分布特性

王晶, 王亦飞, 颜留成, 伍子玮, 于广锁

华东理工大学洁净煤技术研究所, 煤气化及能源化工教育部重点实验室, 上海 200237

收稿日期:2015-12-23 修回日期:2016-02-04 出版日期:2016-06-05 发布日期:2016-06-05
通讯作者: 王亦飞
基金资助:
国家高技术研究发展计划项目(2012AA053101)。

Characteristics of velocity and thickness distribution of liquid film in vertical falling tube

WANG Jing, WANG Yifei, YAN Liucheng, WU Ziwei, YU Guangsuo

Key Laboratory of Coal Gasification and Energy Chemical Engineering of Ministry of Education, Institute of Clean Coal Technology, East China University of Science and Technology, Shanghai 200237, China

Received:2015-12-23 Revised:2016-02-04 Online:2016-06-05 Published:2016-06-05
Supported by:
supported by theNational High Technology Research and Development Program of China (2012AA053101).

摘要/Abstract

摘要：

对洗涤冷却管内垂直降膜的流动特性进行研究,采用超声波多普勒测速仪对管内不同周向以及轴向位置的液膜厚度和速度进行了无接触式的测量,液膜Reynolds数范围为1.0×10⁴~3.1×10⁴。结果表明:在0°周向位置上液膜厚度与速度均达到最大值,导致该位置局部液膜厚度过大而不能保持稳定,部分液体脱离液膜表面,此外还造成了8°和16°位置的液膜厚度激增。在轴向上,当Reynolds数小于2.0×10⁴时,液膜速度在重力作用下随流动距离增加而增加,反之,液膜速度因为流动阻力会随距离增加而减小。随着Reynolds数的增大,液膜平均厚度和速度呈增大趋势。此外,Reynolds数的增大还会使得液膜更加不稳定。

关键词: 气液两相流, 湍动, 膜, 速度测量, 厚度测量, 超声多普勒测速仪

Abstract:

The flow characteristic of the falling liquid film in the scrubbing-cooling tube was researched in this paper. The ultrasound Doppler velocimetry was adopted to measure the velocity and thickness distribution of the liquid film non-instrusively at different circumferential and axial position. The Reynolds number ranged from 1.0×10⁴ to 3.1×10⁴. The results showed that both the velocity and thickness of the liquid film were the largest at the 0° position, leading to unevener thickness distribution and the separation of the local liquid film and the sharp increase of the liquid film thickness at the 8° and 16° positions. In the axial direction, because of the effect of gravity, the liquid film velocity increased with the increase of flow distance when the Reynolds numbers was less than 2.0×10⁴, whereas, it decreased at large Reynolds numbers since that the resistance became a dominant factor. Both of the thickness and velocity of global liquid film increased with increasing Reynolds number. Furthermore, the increase of the Reynolds numbers made the liquid film more unstable.

Key words: gas-liquid flow, turbulence, film, velocity measurement, thickness measurement, ultrasound Doppler velocimetry

中图分类号:

TQ021

王晶, 王亦飞, 颜留成, 伍子玮, 于广锁. 管内垂直下降液膜速度与厚度分布特性[J]. 化工学报, 2016, 67(6): 2239-2245.

WANG Jing, WANG Yifei, YAN Liucheng, WU Ziwei, YU Guangsuo. Characteristics of velocity and thickness distribution of liquid film in vertical falling tube[J]. CIESC Journal, 2016, 67(6): 2239-2245.

参考文献 21

[1]	ZHENG L, FURINSKY E. Comparison of Shell, Texaco, BGL and KRW gasifiers as part of IGCC plant computer simulation [J]. Energy Conversion and Management, 2005, 46(11/12): 1767-1779.
[2]	YU Z H, WANG Y F, ZHOU Z J, et al. A compound bed high temperature gas cooling and washing equipment and its industrial application: 1322795[P]. 2001-11-21.
[3]	颜留成, 王亦飞, 王灵萍, 等. 洗涤冷却环内液体冷态流动行为数值模拟 [J]. 化工学报, 2014, 65(8): 2927-2933. DOI: 10.3969/j.issn. 0438-1157.2014.08.011. YAN L C, WANG Y F, WANG L P, et al. Numerical simulation of cold state liquid flow in scrubbing-cooling ring [J]. CIESC Journal, 2014, 65(8): 2927-2933. DOI: 10.3969/j.issn.0438-1157.2014.08.011.
[4]	宋建, 胡珀, 韦胜杰, 等. 竖直平板水膜表面波演化行为实验研究 [J]. 原子能科学技术,2012,46(7):804-808. SONG J, HU P, WEI S J, et al. Experimental study on surface-wave evolution behavior of water film falling down vertical plate [J]. Atomic Energy Science and Technology, 2012, 46(7): 804-808.
[5]	王灵萍, 王亦飞, 郭强强, 等. 洗涤冷却管内垂直降膜流动特性 [J]. 化工学报, 2013, 64(6): 1959-1968. DOI:10.3969/j.issn.0438-1157. 2013.06.009. WANG L P, WANG Y F, GUO Q Q, et al. Flow characteristics of vertical falling film in scrubbing-cooling pipe [J]. CIESC Journal, 2013, 64(6): 1959-1968. DOI: 10.3969/j.issn.0438-1157.2013.06.009.
[6]	阎维平, 李洪涛, 叶学民, 等. 垂直自由下降液膜厚度的瞬时无接触测量研究 [J]. 热能动力工程, 2007, 22(4): 380-384. DOI:10.3969/j.issn.1001-2060.2007.04.007. YAN W P, LI H T, YE X M, et al. A study of the transient non-contact measurement of vertical free-falling liquid-film thickness [J]. Journal of Engineering for Thermal Energy and Power, 2007, 22(4): 380-384. DOI: 10.3969/j.issn.1001-2060.2007.04.007.
[7]	韦胜杰, 宋建, 胡珀, 等. 竖壁冷态降液膜流动统计特性实验研究 [J]. 原子能科学技术, 2012, 46(6): 674-678. WEI S J, SONG J, HU P, et al. Statistical characteristics of water film falling down large flat plate [J]. Atomic Energy Science and Technology, 2012, 46(6): 674-678.
[8]	ABDULKADIR M, AZZI A, ZHAO D, et al. Liquid film thickness behaviour within a large diameter vertical 180° return bend [J]. Chemical Engineering Science, 2014, 107: 137-148.
[9]	ALEKSEENKO S V, AKTERSHEV S P, CHERDANTSEV A V, et al. Primary instabilities of liquid film flow sheared by turbulent gas stream [J]. International Journal of Multiphase Flow, 2009, 35(7): 617-627.
[10]	KOIZUMI Y, ENARI R, OHTAKE H. Correlations of wave characteristics for a liquid film falling down along a vertical wall [J]. Journal of Heat Transfer, 2009, 131(8): 082901 1-9.
[11]	KIL S H, KIM S S, LEE S K. Wave characteristics of falling liquid film on a vertical circular tube [J]. International Journal of Refrigeration, 2001, 24: 500-509.
[12]	MIN J K, PARK I S. Numerical study for laminar wavy motions of liquid film flow on vertical wall [J]. International Journal of Heat and Mass Transfer, 2011, 54(15/16): 3256-3266.
[13]	李铁, 吴晅,袁竹林.气化炉激冷室下降管内气液两相热质同时传递过程数值研究 [J]. 中国电机工程学报, 2008, 28(26): 35-39.DOI:10.3321/j.issn:0258-8013.2008.26.007. LI T, WU X, YUAN Z L. Numerical investigation of gas-liquid heat and mass concurrent transfer process in vertical pipe in gasifier quenching chamber [J]. Proceedings of the CSEE, 2008, 28(26):35-39. DOI:10.3321/j.issn:0258-8013.2008.26.007.
[14]	FEDDAOUI M, MEFTAH H, MIR A. The numerical computation of the evaporative cooling of falling water film in turbulent mixed convection inside a vertical tube [J]. International Communications in Heat and Mass Transfer, 2006, 33(7): 917-927.
[15]	WANG Y, GUO Q, FU B, et al. Numerical analysis of the flow characteristics and heat and mass transfer of falling-water films in an industrial-scale dip tube of a WSCC in an OMB gasifier [J]. Industrial & Engineering Chemistry Research, 2013, 52(26): 9295-9300.
[16]	BRITO D, NATAF H-C, CARDIN P, et al. Ultrasonic Doppler velocimetry in liquid gallium [J]. Experiments in Fluids, 2001, 31(6): 653-663.
[17]	ECKERT S, GERBETH G, MELNIKOV Vi. Velocity measurements at high temperatures by ultrasound Doppler velocimetry using an acoustic wave guide [J]. Experiments in Fluids, 2003, 35(5): 381-388.
[18]	张欢, 王铁峰, 王金福. 液固循环流化床中颗粒轴向速度的实验研究 [J]. 高校化学工程学报, 2002, 16(4): 2-8. DOI:10.3321/j.issn: 1003-9015.2002.04.010. ZHANG H, WANG T F, WANG J F. Study on the axial velocity of particles in a liquid-solid circulating fluidized bed using the ultrasound-Doppler technique [J]. Journal of Chemical Engineering of Chinese Universities, 2002, 16(4): 2-8. DOI:10.3321/j.issn: 1003-9015. 2002.04.010.
[19]	LONGO S. The effects of air bubbles on ultrasound velocity measurements [J]. Experiments in Fluids, 2006, 41(4): 593-602.
[20]	王铁峰, 王金福, 张欢, 等. 超声多普勒测速仪在液-固和气-液两相流测量中的应用 [J]. 化工学报, 2002, 53(4): 427-432. WANG T F, WANG J F, ZHANG H, et al. Application of ultrasound Doppler velocimetry in multiphase flow measurement [J]. Journal of Chemical Industry and Engineering (China), 2002, 53(4): 427-432.
[21]	NOWAK M. Wall shear stress measurement in a turbulent pipe flow using ultrasound Doppler velocimetry [J]. Experiments in Fluids, 2002, 33(2): 249-255.

管内垂直下降液膜速度与厚度分布特性

Characteristics of velocity and thickness distribution of liquid film in vertical falling tube

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 21

相关文章 15

编辑推荐

Metrics

本文评价

[1]	邵苛苛, 宋孟杰, 江正勇, 张旋, 张龙, 高润淼, 甄泽康. 水平方向上冰中受陷气泡形成和分布实验研究[J]. 化工学报, 2023, 74(S1): 161-164.
[2]	江河, 袁俊飞, 王林, 邢谷雨. 均流腔结构对微细通道内相变流动特性影响的实验研究[J]. 化工学报, 2023, 74(S1): 235-244.
[3]	吴延鹏, 李晓宇, 钟乔洋. 静电纺丝纳米纤维双疏膜油性细颗粒物过滤性能实验分析[J]. 化工学报, 2023, 74(S1): 259-264.
[4]	袁佳琦, 刘政, 黄锐, 张乐福, 贺登辉. 泡状入流条件下旋流泵能量转换特性研究[J]. 化工学报, 2023, 74(9): 3807-3820.
[5]	胡建波, 刘洪超, 胡齐, 黄美英, 宋先雨, 赵双良. 有机笼跨细胞膜易位行为的分子动力学模拟研究[J]. 化工学报, 2023, 74(9): 3756-3765.
[6]	齐聪, 丁子, 余杰, 汤茂清, 梁林. 基于选择吸收纳米薄膜的太阳能温差发电特性研究[J]. 化工学报, 2023, 74(9): 3921-3930.
[7]	何松, 刘乔迈, 谢广烁, 王斯民, 肖娟. 高浓度水煤浆管道气膜减阻两相流模拟及代理辅助优化[J]. 化工学报, 2023, 74(9): 3766-3774.
[8]	李艺彤, 郭航, 陈浩, 叶芳. 催化剂非均匀分布的质子交换膜燃料电池操作条件研究[J]. 化工学报, 2023, 74(9): 3831-3840.
[9]	张佳怡, 何佳莉, 谢江鹏, 王健, 赵鹬, 张栋强. 渗透汽化技术用于锂电池生产中N-甲基吡咯烷酮回收的研究进展[J]. 化工学报, 2023, 74(8): 3203-3215.
[10]	高燕, 伍鹏, 尚超, 胡泽君, 陈晓东. 基于双流体喷嘴的磁性琼脂糖微球的制备及其蛋白吸附性能探究[J]. 化工学报, 2023, 74(8): 3457-3471.
[11]	邢雷, 苗春雨, 蒋明虎, 赵立新, 李新亚. 井下微型气液旋流分离器优化设计与性能分析[J]. 化工学报, 2023, 74(8): 3394-3406.
[12]	胡亚丽, 胡军勇, 马素霞, 孙禹坤, 谭学诣, 黄佳欣, 杨奉源. 逆电渗析热机新型工质开发及电化学特性研究[J]. 化工学报, 2023, 74(8): 3513-3521.
[13]	张贲, 王松柏, 魏子亚, 郝婷婷, 马学虎, 温荣福. 超亲水多孔金属结构驱动的毛细液膜冷凝及传热强化[J]. 化工学报, 2023, 74(7): 2824-2835.
[14]	高金明, 郭玉娇, 鄂承林, 卢春喜. 一种封闭罩内顺流多旋臂气液分离器的分离特性研究[J]. 化工学报, 2023, 74(7): 2957-2966.
[15]	江锦波, 彭新, 许文烜, 门日秀, 刘畅, 彭旭东. 泵出型螺旋槽油气密封泄漏特性及参数影响研究[J]. 化工学报, 2023, 74(6): 2538-2554.