乙炔电还原制备乙烯的反应机理

doi:10.11949/j.issn.0438-1157.20150424

化工学报 ›› 2016, Vol. 67 ›› Issue (4): 1340-1347.DOI: 10.11949/j.issn.0438-1157.20150424

• 催化、动力学与反应器 • 上一篇下一篇

乙炔电还原制备乙烯的反应机理

宋秀丽^1,2, 贾瑞龙¹, 解学佳¹, 梁镇海¹, 朱珍平³

1. 太原理工大学化学化工学院, 山西太原 030024;
2. 太原师范学院化学系, 山西太原 030031;
3. 中国科学院山西煤炭化学研究所煤转化国家重点实验室, 山西太原 030001

收稿日期:2015-04-07 修回日期:2015-11-24 出版日期:2016-04-05 发布日期:2016-04-05
通讯作者: 梁镇海
基金资助:
国家自然科学基金委员会与神华集团有限责任公司联合资助项目(U1261103);中国科学院山西煤炭化学研究所煤转化国家重点实验室开放基金项目(J12-13-913)。

Reaction mechanism of electrochemical reduction of acetylene to ethylene

SONG Xiuli^1,2, JIA Ruilong¹, XIE Xuejia¹, LIANG Zhenhai¹, ZHU Zhenping³

1. College of Chemistry and Chemical Engineering, Taiyuan University of Technology, Taiyuan 030024, Shanxi, China;
2. Department of Chemistry, Taiyuan Normal University, Taiyuan 030031, Shanxi, China;
3. State Key Laboratory of Coal Conversion, Institute of Coal Chemistry, Chinese Academy of Sciences, Taiyuan 030001, Shanxi, China

Received:2015-04-07 Revised:2015-11-24 Online:2016-04-05 Published:2016-04-05
Supported by:
supported by the National Natural Science Foundation of China and Shenhua Group Corp.(U1261103) and the Open Fund of State Key Laboratory of Coal Conversion, Institute of Coal Chemistry, Chinese Academy of Sciences (J12-13-913).

摘要/Abstract

摘要：

选择钯电还原乙炔制备乙烯并通过气相色谱法对产品进行表征,利用第一性原理计算方法探讨乙炔在催化剂Pd (111)表面的吸附情况,采用循环伏安法研究钯电极在硫酸溶液中还原乙炔的电极过程,测定电极的稳态极化曲线并根据极化曲线推算Tafel斜率,重点结合表观传递系数及反应级数对拟定的乙炔电还原制备乙烯的反应机理进行验证。实验结果表明:乙炔分子在Pd (111)面上呈平行桥键构型时最稳定;钯电极在硫酸溶液中可将乙炔电还原为乙烯;得出了反应最可能的速率控制步骤。

关键词: 乙炔, 乙烯, 吸附, 还原, 电化学机理, 第一性原理, 速率控制步骤

Abstract:

Electrochemical synthesis of ethylene from acetylene was put forward and the synthesized ethylene was characterized by gas chromatography (GC). First-principle calculations were carried out to examine the adsorption of acetylene over the Pd (111) surface. The electrochemical reduction behavior of acetylene has been investigated on a Pd electrode by cyclic voltammetry (CV) and stable polarization curves in sulfuric acid. The formation mechanism of ethylene in the sulfuric acid was proposed and the transfer coefficients of the reaction were calculated. The results showed that the acetylene molecule tended to be adsorbed through the threefold parallel-bridge configuration that was computed to be the most stable because of its lowest adsorption energy. The rate-determining step in the electrolysis process has been obtained. The rate of this step obtained from the assumed process agreed well with the experiment results.

Key words: acetylene, ethylene, absorption, reduction, electrochemistry mechanism, first-principles, rate-determining step

中图分类号:

O643
O646

宋秀丽, 贾瑞龙, 解学佳, 梁镇海, 朱珍平. 乙炔电还原制备乙烯的反应机理[J]. 化工学报, 2016, 67(4): 1340-1347.

SONG Xiuli, JIA Ruilong, XIE Xuejia, LIANG Zhenhai, ZHU Zhenping. Reaction mechanism of electrochemical reduction of acetylene to ethylene[J]. CIESC Journal, 2016, 67(4): 1340-1347.

参考文献 21

[1]	XIE K C, LI W Y, ZHAO W. Coal chemical industry and its sustainable development in China[J]. Energy, 2010, 35: 4349-4355.
[2]	迟洪泉. 国内外乙烯工业现状与展望[J]. 化工技术经济, 2006, 24(4): 6-9, 15. CHI H Q. Current situation and future development of ethylene industry[J]. Chemical Techno-Economics, 2006, 24(4): 6-9, 15.
[3]	YAN B H, XU P C, CLIFF Y G, et al. Experimental study on coal pyrolysis to acetylene in thermal plasma reactors[J]. Chemical Engineering Journal, 2012, 207/208: 109-116.
[4]	WU C N, CHEN J Q, CHENG Y. Thermodynamic analysis of coal pyrolysis to acetylene in hydrogen plasma reactor[J]. Fuel Processing Technology, 2010, 91: 823-830.
[5]	BAO S, SCHINDLER K M, HOFMANN P, et al. The local adsorption structure of acetylene on Cu (111)[J]. Surface Science, 1993, 291(3): 295-308.
[6]	KYRIAKOU G, KIM J, TIKHOV M S, et al. Acetylene coupling on Cu (111): formation of butadiene, benzene, and cyclooctatraene[J]. Journal of Physical Chemistry B, 2005, 109(21): 10952-10956.
[7]	IBACH H, LEHWALD S. Identification of surface radicals by vibration spectroscopy: reactions of C2H2, C2H4, and H2 on Pt (111)[J]. The Journal of Physical Chemistry B, 1978, 15(2): 407-415.
[8]	ORMEROD R M, LAMBERT R M, BENNETT D W, et al. Temperature programmed desorption of co-adsorbed hydrogen and acetylene on Pd (111)[J]. Surface Science, 1995, 330(1): 1-10.
[9]	SONG X L, DU H Y, LIANG Z H, et al. Paired electrochemical synthesis of ethylene and oxalic acid from acetylene[J]. International Journal of Electrochemical Science, 2013, 8(5): 6566-6573.
[10]	HUANG B B, DURANT C, ISSE A A, et al. Highly selective electrochemical hydrogenation of acetylene to ethylene at Ag and Cu cathodes[J]. Electrochemistry Communications, 2013, 34: 90-93.
[11]	梁镇海, 宋秀丽, 段东红, 等. 一种乙炔双极电化学合成乙烯和草酸的方法: ZL201110226331.3[P]. 2012-02-22. LIANG Z H SONG X L, DUAN D H, et al. Method for double-electrode electrochemical synthesis of ethene and oxalic acid from acetylene:ZL201110226331.3[P]. 2012-02-22.
[12]	XIE X J, SONG X L, DONG W Y, et al. Adsorption mechanism of acetylene hydrogenation on the Pd (111) surface[J]. Chinese Journal of Chemistry, 2014, 32: 631-636.
[13]	SHETH P A, NEUROCK M, SMITH C M. A first-principles analysis of acetylene hydrogenation over Pd (111)[J]. Journal of Physical Chemistry B, 2003, 107(9): 2009-2017.
[14]	KANG J H, SHIN E W, KIM W J, et al. Selective hydrogenation of acetylene on TiO2-added Pd catalysts[J]. Journal of Catalysis, 2002, 208(2): 310-320.
[15]	ZHANG Q W, LI J, LIU X X, et al. Synergetic effect of Pd and Ag dispersed on Al2O3 in the selective hydrogenation of acetylene[J]. Applied Catalysis A: General, 2002, 197(2): 221-223.
[16]	王功华. 乙炔加氢动力学研究及反应器模拟计算[D]. 北京: 北京化工大学, 2003. WANG G H. Dynamics study on acetylene hydrogenation and simulating calculation of reactor[D]. Beijing: Beijing University of Chemical Technology, 2003
[17]	BOND G C, WELLS P B. The hydrogenation of acetylene(Ⅱ): The reaction of acetylene with hydrogen catalyzed by alumina-supported palladium[J]. Journal of Catalysis, 1966, 5(1): 65-73.
[18]	BOND G C, WELLS P B. The hydrogenation of acetylene(Ⅲ): The reaction of acetylene with hydrogen catalyzed by alumina-supported rhodium and iridium[J]. Journal of Catalysis, 1966, 5(3): 419-427.
[19]	SHETH P A, NEUROCK M, SMITH C M. A first-principles analysis of acetylene hydrogenation over Pd(111)[J]. The Journal of Physical Chemistry B, 2003, 107: 2009-2017.
[20]	高鹏, 朱永明. 电化学基础教程[M]. 北京: 化学工业出版社, 2013: 108-109. GAO P, ZHU Y M. A Course Book of Electrochemistry[M]. Beijing: Chemical Industry Press, 2013: 108-109.
[21]	YU J G, CAI X J, ZHANG H B, et al. Electrooxidation of hydroxypivalaldehyde in an undivided cell[J]. Chemical Research in Chinese Universities, 2006, 22(5): 626-630.

乙炔电还原制备乙烯的反应机理

Reaction mechanism of electrochemical reduction of acetylene to ethylene

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 21

相关文章 15

编辑推荐

Metrics

本文评价

[1]	晁京伟, 许嘉兴, 李廷贤. 基于无管束蒸发换热强化策略的吸附热池的供热性能研究[J]. 化工学报, 2023, 74(S1): 302-310.
[2]	范孝雄, 郝丽芳, 范垂钢, 李松庚. LaMnO₃/生物炭催化剂低温NH₃-SCR催化脱硝性能研究[J]. 化工学报, 2023, 74(9): 3821-3830.
[3]	刘远超, 关斌, 钟建斌, 徐一帆, 蒋旭浩, 李耑. 单层XSe₂（X=Zr/Hf）的热电输运特性研究[J]. 化工学报, 2023, 74(9): 3968-3978.
[4]	王浩, 王振雷. 基于自适应谱方法的裂解炉烧焦模型化简策略[J]. 化工学报, 2023, 74(9): 3855-3864.
[5]	杨学金, 杨金涛, 宁平, 王访, 宋晓双, 贾丽娟, 冯嘉予. 剧毒气体PH₃的干法净化技术研究进展[J]. 化工学报, 2023, 74(9): 3742-3755.
[6]	孟令玎, 崇汝青, 孙菲雪, 孟子晖, 刘文芳. 改性聚乙烯膜和氧化硅固定化碳酸酐酶[J]. 化工学报, 2023, 74(8): 3472-3484.
[7]	高燕, 伍鹏, 尚超, 胡泽君, 陈晓东. 基于双流体喷嘴的磁性琼脂糖微球的制备及其蛋白吸附性能探究[J]. 化工学报, 2023, 74(8): 3457-3471.
[8]	诸程瑛, 王振雷. 基于改进深度强化学习的乙烯裂解炉操作优化[J]. 化工学报, 2023, 74(8): 3429-3437.
[9]	盛冰纯, 于建国, 林森. 铝基锂吸附剂分离高钠型地下卤水锂资源过程研究[J]. 化工学报, 2023, 74(8): 3375-3385.
[10]	张瑞航, 曹潘, 杨锋, 李昆, 肖朋, 邓春, 刘蓓, 孙长宇, 陈光进. ZIF-8纳米流体天然气乙烷回收工艺的产品纯度关键影响因素分析[J]. 化工学报, 2023, 74(8): 3386-3393.
[11]	张蒙蒙, 颜冬, 沈永峰, 李文翠. 电解液类型对双离子电池阴阳离子储存行为的影响[J]. 化工学报, 2023, 74(7): 3116-3126.
[12]	陈吉, 洪泽, 雷昭, 凌强, 赵志刚, 彭陈辉, 崔平. 基于分子动力学的焦炭溶损反应及其机理研究[J]. 化工学报, 2023, 74(7): 2935-2946.
[13]	张琦钰, 高利军, 苏宇航, 马晓博, 王翊丞, 张亚婷, 胡超. 碳基催化材料在电化学还原二氧化碳中的研究进展[J]. 化工学报, 2023, 74(7): 2753-2772.
[14]	王杰, 丘晓琳, 赵烨, 刘鑫洋, 韩忠强, 许雍, 蒋文瀚. 聚电解质静电沉积改性PHBV抗氧化膜的制备与性能研究[J]. 化工学报, 2023, 74(7): 3068-3078.
[15]	李盼, 马俊洋, 陈志豪, 王丽, 郭耘. Ru/α-MnO₂催化剂形貌对NH₃-SCO反应性能的影响[J]. 化工学报, 2023, 74(7): 2908-2918.