2,3,6-三甲基苯酚气-液-液氧化反应与传质过程

doi:10.11949/j.issn.0438-1157.20150839

化工学报 ›› 2015, Vol. 66 ›› Issue (8): 2962-2967.DOI: 10.11949/j.issn.0438-1157.20150839

2,3,6-三甲基苯酚气-液-液氧化反应与传质过程

陈志荣, 杨伟涛, 周凯, 黄海平, 尹红, 袁慎峰

浙江大学化学工程与生物工程学院, 浙江杭州 310027

收稿日期:2015-06-05 修回日期:2015-06-18 出版日期:2015-08-05 发布日期:2015-08-05
通讯作者: 尹红
基金资助:
浙江省重点科技创新团队计划资助项目(2011R50007)。

Gas-liquid-liquid mass transfer of 2,3,6-trimethylphenol oxidation

CHEN Zhirong, YANG Weitao, ZHOU Kai, HUANG Haiping, YIN Hong, YUAN Shenfeng

College of Chemical and Biological Engineering, Zhejiang University, Hangzhou 310027, Zhejiang, China

Received:2015-06-05 Revised:2015-06-18 Online:2015-08-05 Published:2015-08-05
Supported by:
supported by the Program for Zhejiang Leading Team of S&T Innovation(2011R50007).

摘要/Abstract

摘要：

对2,3,6-三甲基苯酚(TMP)的气-液-液纯氧常压三相氧化反应与传质过程进行了研究。该反应为液膜传质控制的快速反应,氧气消耗速率对原料TMP为1级。在液膜控制条件下探讨了水相体积分数(ε)、搅拌转速(n)、搅拌桨直径(d)和通气量(V)对反应的影响。结果表明,体系在e达到0.58后产生相变,相变后液相体积传质系数随ε变化趋势发生改变,液相体积传质系数(k_L(O₂)a)随n、d、V的增加而增大。综合考虑上述因素对k_L(O₂)a的影响,得到了液相体积传质系数的量纲一关联式,根据关联式计算得到的液相体积传质系数值与实验值接近,平均相对偏差为4.53%,表明关联式拟合效果较好。

关键词: 2,3,6-三甲基苯酚, 氧化, 多相反应, 传质, 液相体积传质系数

Abstract:

The purpose of this paper is to investigate the gas-liquid-liquid mass transfer of 2,3,6-trimethylphenol (TMP) oxidation under oxygen. The reaction can be regarded as rapid and takes place in liquid-film. The oxidation rate is in first order with respect to TMP concentration. Under the condition of liquid film controlling, the effects of water phase volume fraction (ε), stirring speed (n), impeller diameter(d) and gas ventilation (V) on k_L(O₂)a were investigated. The results showed that a phase inversion took place when ε surpassed 0.58, and the trend of k_L(O₂)a changed significantly, k_L(O₂)a increased with increasing n, d and V. Considering the effects of all the four factors on k_L(O₂)a, a dimensionless correlation equation of k_L(O₂)a can be obtained. The calculated values are in good agreement with the experimental values with the relative deviation between 1.18% and 10.15%, and the average relative deviation of 4.53%, which shows that the equation fitting is reasonable.

Key words: 2,3,6-trimethylphenol, oxidation, multiphase reaction, mass transfer, liquid phase volumetric mass transfer coefficient

中图分类号:

TQ013.2

陈志荣, 杨伟涛, 周凯, 黄海平, 尹红, 袁慎峰. 2,3,6-三甲基苯酚气-液-液氧化反应与传质过程[J]. 化工学报, 2015, 66(8): 2962-2967.

CHEN Zhirong, YANG Weitao, ZHOU Kai, HUANG Haiping, YIN Hong, YUAN Shenfeng. Gas-liquid-liquid mass transfer of 2,3,6-trimethylphenol oxidation[J]. CIESC Journal, 2015, 66(8): 2962-2967.

参考文献 23

[1]	Li Y, Zhang P, Wu M, et al. An effective oxidation of 2,3,6-trimethylphenol to 2,3,5-trimethylbenzoquinone using Fenton's reagent under mild conditions [J]. Chemical Engineering Journal, 2009, 146(2): 270-274.
[2]	Kholdeeva O A, Trukhan N N, Vanina M P, et al. A new environmentally friendly method for the production of 2,3,5-trimethyl-p-benzoquinone [J]. Catalysis Today, 2002, 75(1): 203-209.
[3]	Bodnar Z, Mallat T, Baiker A. Oxidation of 2,3,6-trimethylphenol to trimethyl-1,4-benzoquinone with catalytic amount of CuCl2 [J]. Journal of Molecular Catalysis A: Chemical, 1996, 110(1): 55-63.
[4]	Guan W, Wang C, Yun X, et al. A mild and efficient oxidation of 2,3,6-trimethylphenol to trimethyl-1,4-benzoquinone in ionic liquids [J]. Catalysis Communications, 2008, 9(10): 1979-1981.
[5]	Wang C, Guan W, Xie P, et al. Effects of ionic liquids on the oxidation of 2,3,6-trimethylphenol to trimethyl-1,4-benzoquinone under atmospheric oxygen [J]. Catalysis Communications, 2009, 10(5): 725-727.
[6]	Takehira K, Shimizu M, Watanabe Y, et al. A novel oxygenation of 2,3,6-trimethylphenol to trimethyl-p-benzoquinone by dioxygen with copper (Ⅱ) chloride/amine hydrochloride catalyst [J]. Tetrahedron Letters, 1989, 30(48): 6691-6692.
[7]	Sun H, Harms K, Sundermeyer J. Aerobic oxidation of 2,3,6-trimethylphenol to trimethyl-1,4-benzoquinone with copper (Ⅱ) chloride as catalyst in ionic liquid and structure of the active species [J]. Journal of the American Chemical Society, 2004, 126(31): 9550-9551.
[8]	Freitas E R, Gum C R. Shells higher olefins process [J]. Chemical Engineering Progress, 1979, 75(1): 73-76.
[9]	Gaunand A. Oxidation of Cu (Ⅰ) by oxygen in concentrated NaCl solutions (Ⅲ): Kinetics in a stirred two-phase and three-phase reactor [J]. Chemical Engineering Science, 1986, 41(1): 1-9.
[10]	Mills P L, Chaudhari R V. Multiphase catalytic reactor engineering and design for pharmaceuticals and fine chemicals [J]. Catalysis Today, 1997, 37(4): 367-404.
[11]	Yoshida F, Yamane T, Miyamoto Y. Oxygen absorption into oil-in-water emulsions. A study on hydrocarbon fermentors [J]. Industrial & Engineering Chemistry Process Design and Development, 1970, 9(4): 570-577.
[12]	Brilman D W F. Mass Transfer and Chemical Reaction in Gas-Liquid-Liquid Systems[M]. Netherlands: Thesis University of Twente, 1998
[13]	Sorokin A B, Tuel A. Metallophthalocyanine functionalized silicas: catalysts for the selective oxidation of aromatic compounds [J]. Catalysis Today, 2000, 57(1): 45-59.
[14]	Ito S, Aihara K, Matsumoto M. Ruthenium-catalyzed oxidation of phenols with hydrogen peroxide [J]. Tetrahedron Letters, 1983, 24(47): 5249-5252.
[15]	Sheldon R A, Kochi J K. Metal Catalyzed Oxidation of Organic Compounds[M]. New York: Academic Press, 1981: 373.
[16]	Palacio M, Villabrille P I, Romanelli G P, et al. Preparation, characterization and use of V2O5-TiO2 mixed xerogels as catalysts for sustainable oxidation with hydrogen peroxide of 2,3,6-trimethylphenol [J]. Applied Catalysis A: General, 2012, 417: 273-280.
[17]	Kholdeeva O A, Ivanchikova I D, Guidotti M, et al. How to reach 100% selectivity in H2O2-based oxidation of 2,3,6-trimethylphenol to trimethyl-p-benzoquinone over Ti,Si-catalysts [J]. Catalysis Today, 2009, 141: 330-336.
[18]	Kuntz E G. Homogeneous catalysis in water [J]. Chem. Tech., 1987: 570-575.
[19]	Li Y, Liu W, Wu M, et al. Selective photoinduced oxidation of 2,3,5-trimethylphenol to 2,3,5-trimethylbenzoquinone catalyzed by hypocrellins/CuCo2O4 [J]. Mendeleev Communications, 2010, 20(4): 218-219.
[20]	Zhou J, Hua Z, Cui X, et al. Hierarchical mesoporous TS-1 zeolite: a highly active and extraordinarily stable catalyst for the selective oxidation of 2,3,6-trimethylphenol [J]. Chemical Communications, 2010, 46(27): 4994-4996.
[21]	Levenspiel O, Godfery J H. A gradientless contactor for experimental study of interphase mass transfer with/without reaction [J]. Chemical Engineering Science, 1974, 29(8): 1723-1730.
[22]	Dumont E, Delmas H. Mass transfer enhancement of gas absorption in oil-in-water systems: a review [J]. Chemical Engineering and Processing, 2003, (42): 419-438.
[23]	Yagi H, Yoshida F. Gas absorption by Newtonian and non-Newtonian fluids in sparged agitated vessels [J]. Industrial & Engineering Chemistry Process Design and Development, 1975, 14(4): 488-493.

2,3,6-三甲基苯酚气-液-液氧化反应与传质过程

Gas-liquid-liquid mass transfer of 2,3,6-trimethylphenol oxidation

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献 23

相关文章 15

编辑推荐

Metrics

本文评价

[1]	晁京伟, 许嘉兴, 李廷贤. 基于无管束蒸发换热强化策略的吸附热池的供热性能研究[J]. 化工学报, 2023, 74(S1): 302-310.
[2]	胡超, 董玉明, 张伟, 张红玲, 周鹏, 徐红彬. 浓硫酸活化五氧化二钒制备高浓度全钒液流电池正极电解液[J]. 化工学报, 2023, 74(S1): 338-345.
[3]	宋瑞涛, 王派, 王云鹏, 李敏霞, 党超镔, 陈振国, 童欢, 周佳琦. 二氧化碳直接蒸发冰场排管内流动沸腾换热数值模拟分析[J]. 化工学报, 2023, 74(S1): 96-103.
[4]	张义飞, 刘舫辰, 张双星, 杜文静. 超临界二氧化碳用印刷电路板式换热器性能分析[J]. 化工学报, 2023, 74(S1): 183-190.
[5]	范孝雄, 郝丽芳, 范垂钢, 李松庚. LaMnO₃/生物炭催化剂低温NH₃-SCR催化脱硝性能研究[J]. 化工学报, 2023, 74(9): 3821-3830.
[6]	杨百玉, 寇悦, 姜峻韬, 詹亚力, 王庆宏, 陈春茂. 炼化碱渣湿式氧化预处理过程DOM的化学转化特征[J]. 化工学报, 2023, 74(9): 3912-3920.
[7]	米泽豪, 花儿. 基于DFT和COSMO-RS理论研究多元胺型离子液体吸收SO₂气体[J]. 化工学报, 2023, 74(9): 3681-3696.
[8]	李艺彤, 郭航, 陈浩, 叶芳. 催化剂非均匀分布的质子交换膜燃料电池操作条件研究[J]. 化工学报, 2023, 74(9): 3831-3840.
[9]	陈美思, 陈威达, 李鑫垚, 李尚予, 吴有庭, 张锋, 张志炳. 硅基离子液体微颗粒强化气体捕集与转化的研究进展[J]. 化工学报, 2023, 74(9): 3628-3639.
[10]	程业品, 胡达清, 徐奕莎, 刘华彦, 卢晗锋, 崔国凯. 离子液体基低共熔溶剂在转化CO₂中的应用[J]. 化工学报, 2023, 74(9): 3640-3653.
[11]	陈哲文, 魏俊杰, 张玉明. 超临界水煤气化耦合SOFC发电系统集成及其能量转化机制[J]. 化工学报, 2023, 74(9): 3888-3902.
[12]	杨学金, 杨金涛, 宁平, 王访, 宋晓双, 贾丽娟, 冯嘉予. 剧毒气体PH₃的干法净化技术研究进展[J]. 化工学报, 2023, 74(9): 3742-3755.
[13]	孟令玎, 崇汝青, 孙菲雪, 孟子晖, 刘文芳. 改性聚乙烯膜和氧化硅固定化碳酸酐酶[J]. 化工学报, 2023, 74(8): 3472-3484.
[14]	汪林正, 陆俞冰, 张睿智, 罗永浩. 基于分子动力学模拟的VOCs热氧化特性分析[J]. 化工学报, 2023, 74(8): 3242-3255.
[15]	李锦潼, 邱顺, 孙文寿. 煤浆法烟气脱硫中草酸和紫外线强化煤砷浸出过程[J]. 化工学报, 2023, 74(8): 3522-3532.